2023 Ford F-150

I was driving down the highway and the right, rear window shattered and blew glass all over the inside of my truck (the cab). There was no incident, no stress cracks, etc. The window simply “exploded”. I drove to the nearest Ford Dealership, assuming it would be covered under my bumper to bumper warranty. After the dealership had my vehicle a full week, they informed me Ford would not pay. I told them to order the window and replace it as I needed my vehicle back. I ended up being without my truck for two weeks. I paid $591.60 and called Ford today, to ask for reimbursement. I was told they cannot do so as the warranty only covers “windshields” for 12 months. I reminded the agent that this is a rear passenger window to no avail. After a little research, I’ve found that hundreds of F-150 owners have had this occur. *My granddaughter could have been in that seat as it was the rear passenger seat! This is a dangerous issue. I am still cleaning up glass, I continue to find all over the cab.

Today 6/18/2026 I was stopped at a stoplight and the engine cut off as if often does and when the light changed and I stepped on the gas instead of restarting the car went into park and remained off until I restarted the truck. This is similar to the safety issue built into the truck if stopped and the front door is opened the truck automatically goes into park. This is the second time it has happened in the past year- the truck being stopped at a light and the engine stops running and when I step on the gas instead of restarting it has gone into park.

There is a manufacturing defect that is causing water to to enter the vehicle when driving in the rain. Where this becomes a significant safety issue is that the water enters somewhere near the bottom of the windshield (source still not determined) and runs down the pillar over the fuse box and BCM (neither is protected from the water). This could lead to an electrical short on any of the major modules of the vehicle unpredictably. the leak is confirmed but source is still to be determined by the dealership after 2 visits. In searching the web, this seems to be a fairly common issue on this generation of F150 trucks. I'll attach the pictures I could get but can never get one with the water actually coming in live

The turn signal stalk on my 2023 Ford F-150 Lightning intermittently requires excessive force to manually cancel after turns and lane changes. The stalk self-cancels normally roughly 50% of the time, but when the steering wheel does not rotate far enough to trigger automatic cancellation the driver must manually return the stalk to center. The condition is most reliably reproduced when the cabin has been elevated in temperature for an extended period and subsides once cooled. The issue predominantly affects right-hand turns and lane changes. The affected component is the turn signal stalk switch pack (multifunction switch), available for inspection. Diagnostic scanning confirmed DTC B124C stored in the SCCM. Based on my research this code indicates a Turn Indicator Stalk Switch Pack fault. The safety risk is threefold: first, a stalk that does not self-cancel sends false signals to other drivers. Second, manually forcing the stalk back to center diverts driver attention from vehicle control. Third, when the stalk releases under applied force it does so suddenly and without warning, and if the driver's hand is on the steering wheel this can cause an involuntary steering input, risking unintended lane departure at highway speeds. I am the second owner, having purchased from a dealership at approximately 60,000 miles. The defect was present at purchase and has worsened progressively to approximately 76,000 miles. The vehicle has not been inspected by a dealer as it is outside warranty. No warning lamp is present; however DTC B124C is confirmed via diagnostic scanning. I documented the issue in a video post which received responses from numerous affected owners: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle is subject to an active safety recall (rear axle hub bolt / axle assembly). The issue has been confirmed by a dealer inspection in November 2025. Despite confirmation, no repair was performed because the dealer did not initially order the required parts. This resulted in several months of delay. After escalation to the manufacturer, a parts order was finally placed in April 2026 and marked as priority. The dealer has since confirmed there is still no estimated time of arrival for the required parts, and the repair cannot be completed. This conflicts with recall information indicating that parts are available. The recall states that failure of the axle hub components can lead to loss of motive power or unintended vehicle movement. The vehicle is used regularly for towing and hauling, which increases concern about potential failure under load. The safety issue remains unresolved after several months, and there is no timeline for repair despite repeated attempts to address it through both the dealer and manufacturer.

After a crash into a tree on the passenger side the airbags deployed and the truck immediately caught fire and the doors locked and would not open for any reason. The only way I was able to exit was busting through the front windshield. had I been severely injured or knocked unconscious the outcome of this would have been much different. The truck burned to the ground in 11 minutes. It has been inspected by the police and awaiting insurance representative to inspect. There were no warning no recalls regarding a crash that would lock the doors and not allow me to exit.

I heard noise coming from my truck, sounded like it was in my wheel. Feb. 4, 2026 I took it to a repair shop. They told me it was the recall on my truck and gave the nut and bolt that had broken off my truck. I called Stanley Ford where I bought the truck to get the recall fixed. They told me they had the part and would get it out the next day (Friday) because I was leaving that Sunday on a work trip. They called me on Friday and said the part they had was for another vehicle and it would be 3-4 mths before they would have the part and I couldn't drive the truck. The software was not updating (even with a battery change) and I asked them to reset since we changed the battery. They told me it would $400 plus to fix that. They have not offered a vehicle for me to drive and neither has Ford. Ford was called and everything was explained to them. I am without a vehicle, with no real estimated time on when I will get my truck back and nothing has been done. No loaner, no paying for my truck since I do not have it. I have been without a vehicle for a month and 1/2. I work a full time job. I have a statement from repair shop and pic, but it won't let me upload.

The moonroof on our F-150 exploded going down the interstate. Nothing was hit and it sounded like a gunshot. The headliner remains intact with no damage and glass blew out at an upward angle. We submitted to Ford for a warranty claim but they denied it. Based on my research this is a known problem from Ford and they are not addressing it.