2023 Ford F-150

Complete electrical shut down driving on the highway on two separate occasions. While driving engine shuts off, dash board goes black, infotainment center goes black. Required to shift vehicle into park to restart after occurrence. Huge safety risk! When taken to Ford service; unable to find any issues and was told “vehicle is safe to drive”

After the vehicle sat parked for 12 days, upon initial startup, the vehicle experienced a total failure of the Electronic Brake Booster (EBB). The dashboard displayed multiple critical fault codes including "Brake System Failure," "Service AdvanceTrac," and "Check Brake System." The vehicle software triggered a safety interlock, refusing to shift out of Park, rendering the vehicle completely disabled. This failure is a direct match to the defect described in NHTSA Campaign 25V488 (Ford Recall 25S77). Ford’s official filing for that recall admits the EBB module is "susceptible to normal but infrequent voltage disturbances" which causes the EBB motor to enter a "faulted state" or shut down. My 2023 Lightning is currently excluded from this recall despite experiencing the exact same "voltage disturbance" failure mode upon waking from a sleep cycle. This is a critical safety defect that resulted in a total loss of power braking assist and vehicle immobilization. Ford is currently refusing to cover the $2,800 repair cost under the recall, despite the identical nature of the failure

The contact's mother owns a 2023 Ford F-150. The contact stated that the owner received notification of NHTSA Campaign Number: 25V512000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that there was an abnormal squealing sound coming from underneath the vehicle, near the brakes upon depression of the brake pedal. The vehicle was taken to the dealer, who advised the contact to not be concerned about the squealing sound. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the issue. The failure mileage was 18,614.

While slowing down the vehicle on a downward slop, vehicle applied Parking Break by itself and stopped the vehicle suddenly with Parking Break sign on the odometer. There was no object or anything in the front of the vehicle and it was being driven on forward direction. So, this abruptly applying of Parking Break by itself created a confusion and unsafe situation.

I was parking my car and pressed down on the brake. The car continued to roll forward so I pressed down farther. The car kept rolling forward. I took my foot off the brake and then pressed down hard and came to a stop. The brake fluid is clean and at max levels. The brake pads are relatively new. No visible signs of damage or leaking.

On [XXX] at [XXX] I dropped my wife and 2 children off at the Funland Arcade in Deep Creek, Maryland. The parking lot was full from the holiday weekend and I was planning on taking the Lightning to a nearby charger while the family gamed so I double parked perpendicular to the arcade entrance, put the hazards on, and let them out. After the 3 of them got out, I placed the Lightning in reverse to back up 5-10 feet so that I could exit the parking lot through the same way I came in. Once I had enough space from reversing so I could make the turn to exit I placed the Lighting in drive. The moment the Lightning switched to drive it accelerated at a very high speed as if I was flooring the gas pedal, which I was not. The lightning was in one-petal mode which I always use unless I’m on a highway. I immediately began pumping the brakes but the truck would not stop, I probably slammed on the brake petal 4-5 times to no avail. I even tried shifting the truck back into park but it would not shift out of drive. I was able to luckily steer the truck into a hillside approximately 150 feet away. The truck ran over numerous small trees and shrubs before crashing to a stop approximately 16 feet up the hill. Shortly after the shock wore off, I slowly reversed the truck down the hill, exited the truck, and informed dozens of onlookers who came out of the arcade to see what the noise in the parking lot was from, that the truck just took off on its own but that I was fine. I called 911 and the police came. Luckily no people or vehicles were between the arcade entrance and the hillside or the outcome would have been significantly worse. This crash was witnessed first hand by wife and 2 children. I have grave safety concerns about this truck now and will not put my family or self back in it until Ford fixes this problem. I am making this complaint in case this information can help prevent future crashes of this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving my 2023 Ford F-150 XLT through a parking lot at low speed, I attempted to stop and shift into reverse to avoid a tight turn between parked vehicles. With my foot firmly on the brake, I shifted into reverse—though the gear shift was abnormally resistant. The system indicated the vehicle was in reverse. Despite keeping my foot on the brake, the truck suddenly and forcefully accelerated on its own, overriding my braking input. It collided with two parked vehicles before I was able to bring it to a stop by turning off the engine. The vehicle continued to accelerate even while I applied firm pressure to the brake pedal, which depressed all the way to the floor and failed to stop the truck. At no point did I press the gas pedal. After impact, the gear shift remained in reverse with a blinking red light. No airbags deployed. This was an extremely dangerous situation that could have seriously injured someone had they been standing nearby. Additionally, for some time leading up to the incident, I noticed increasing difficulty shifting gears even with the brake fully depressed. At times when in park the light for other gear modes would turn on.  Indicating the vehicle may be in another mode other than park.  The brake pedal has also felt inconsistent, often requiring unusually deep and forceful pressure to stop, whether on highways, city streets, or in parking lots. This appears to be a critical failure of both the braking and transmission systems. I am extremely concerned for my safety and that of other Ford drivers. I am requesting a formal investigation into this matter

My 2023 F150 has been having issues with the key fob connecting to the vehicle and responding to commands (unlock/lock, remote start etc). On the date of this incident the truck was not responding to the remote start key fob function. While standing outside the vehicle from a distance of about 10 feet I attempted the remote start function with no success approximately five times. On the last attempt I heard the audible sound of the parking brake releasing (moving from the “brake on” mode to the “brake off” mode). Once inside the vehicle I confirmed that the parking brake had been released. I was ultimately able to get the truck started and driving in a normal condition. The parking brake has not malfunctioned since. The key fob / truck connection continues to malfunction to various degrees. Sometimes no response, sometimes no remote start, sometimes the truck will be running and display a dashboard message indicating the key fob is not present leaving the truck running but “locked” in park. During this parking brake incident the vehicle was parked and locked with the parking brake set as normal (on or about May 10 , 2025). It was on level ground in a parking lot. No other vehicles were parked near mine. It was morning time, the truck was “cold” after being parked all night. No other unusual condition were noted. Weather conditions were dry and mild (50 degree temperatures). The remote connection issues have been going on about 6-8 months. I have replaced the battery in the remote 2x with no improvement. The vehicle has been inspected by the selling dealer once for the fob with no results (April 17, 2025). I have an appointment for the latest issues on June 2 2025. It is my belief that the random release of the parking brake system poses a risk for myself and other members of the public that may be injured by a sudden “roll away” of this vehicle by parking brake failure. I am in possession of the vehicle and it’s available for inspection. .