NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
27 reportsClear category filter32,500 miles · Oct 27, 2025
EngineFuel System, Gasoline
The contact owns a 2023 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power, and the vehicle failed to accelerate. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that the cylinder #6 port injector had failed. The d…
Read full complaint
The contact owns a 2023 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power, and the vehicle failed to accelerate. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that the cylinder #6 port injector had failed. The dealer replaced cylinder #6 port injector, but the failure persisted. The vehicle was taken back to the dealer, who determined that cylinder #4 port injector had failed and replaced the port injector. The failure recurred, and the vehicle was taken back to the dealer for the third time. And it was determined that cylinder #1 port injector had failed and needed to be replaced. The vehicle was not repaired. The contact sent the manufacturer a certified letter notifying the manufacturer of the failure. The failure mileage was approximately 32,500.
NHTSA ODI #11695821
Mileage unknown · Sep 10, 2025
EngineFire
Reported a burning oil/chemical smell to the Ford service center early August and was told nothing was wrong. 2 days ago same smell appeared accompanied with large amount of smoke while driving. Immediately stopped and found flames behind drivers side front tire in engine. Put out the fire ourselves with fire extinguisher and wa…
Read full complaint
Reported a burning oil/chemical smell to the Ford service center early August and was told nothing was wrong. 2 days ago same smell appeared accompanied with large amount of smoke while driving. Immediately stopped and found flames behind drivers side front tire in engine. Put out the fire ourselves with fire extinguisher and was towed to nearest Ford service center. Ford states was a mechanical issue with the front differential causing an oil to leak, cause metal shavings, and ignite in flames.
NHTSA ODI #11686402
7,400 miles · Jun 2, 2025
Electrical SystemEngine
The contact owns a 2023 Ford F-150. The contact stated that when the vehicle was started, the check engine and other unknown warning lights illuminated. Additionally, the contact stated that while driving the vehicle, the vehicle was driving rough. The vehicle was towed to a dealer where to was diagnosed and determined that rode…
Read full complaint
The contact owns a 2023 Ford F-150. The contact stated that when the vehicle was started, the check engine and other unknown warning lights illuminated. Additionally, the contact stated that while driving the vehicle, the vehicle was driving rough. The vehicle was towed to a dealer where to was diagnosed and determined that rodents had eaten through the wires, and all the wiring harnessed in the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 7,400.
NHTSA ODI #11664287
Mileage unknown · May 16, 2025
Electrical SystemEngineForward Collision Avoidance
•Resolution Requested oFull refund for $67,227.63 - Total Money Spent Down Payment Trade In Monthly Payment Aftermarket Accessories oPremium Care Warranty for Purchase of next Ford Vehicle •Issues oEngine and Electrical Issue Electronic Gauge Screen goes black while driving resulting in a safety violation Significant lat…
Read full complaint
•Resolution Requested oFull refund for $67,227.63 - Total Money Spent Down Payment Trade In Monthly Payment Aftermarket Accessories oPremium Care Warranty for Purchase of next Ford Vehicle •Issues oEngine and Electrical Issue Electronic Gauge Screen goes black while driving resulting in a safety violation Significant latency of acceleration upon starting resulting in dangerous driving conditions Issue started Mar 2024 Remote Start Not Working Issue started Mar 2024 oSafety Failure Error Messages •6 X Anti-Lock Brake Fault •18 X Tire Pressure Monitor System •9 X Restraints Indicator Lamp •28 X Pre-Collision Assist Not Available •4 X Power Train Malfunction •Attempted Repairs – the service department has stated they do not know the issue and will need to keep the car for several more weeks to determine a fix oNumber of Times 5 Times oDuration 28 Days oDates 10 APR 2024 – 1 Day 09 May 2024 – 1 Day 09 Sep 2024 – 5 Days 07 JAN 2025 – 10 Days 14 MAY – 1 Day
NHTSA ODI #11661526
Mileage unknown · Apr 25, 2025
Electrical SystemEngineUnknown Or OtherFireInjury
This vehicle started having issues. The truck would shut off going down the highway at 60-65 mph. The radio would blink on and off. The truck would shut down and not turn back on for multiple hours. Dealer couldn't replicate the problem. Our son utilized the truck to go and pick up LP gas for us from his shop. On the way back to…
Read full complaint
This vehicle started having issues. The truck would shut off going down the highway at 60-65 mph. The radio would blink on and off. The truck would shut down and not turn back on for multiple hours. Dealer couldn't replicate the problem. Our son utilized the truck to go and pick up LP gas for us from his shop. On the way back to our home, he stopped at a stop sign and suddenly noticed smoke coming from the dash. He attempted to put out the fire which was then raging under the dashboard and hood. He got the fire out, fire department arrived, truck ignited again. The fire department put out the truck. Son was burned trying to not have the truck explode with gas tanks in the back.
NHTSA ODI #11656711
Mileage unknown · Apr 9, 2025
EnginePower Train
The engine and/or power train malfunctioned, rendering the vehicle difficult to bring to a stop. The longer than normal stopping distance carried the vehicle past the stop line, crosswalk and into the intersection of a crossing roadway. Anyone in the crosswalk or vehicle in the crossing roadway in the path of the vehicle would …
Read full complaint
The engine and/or power train malfunctioned, rendering the vehicle difficult to bring to a stop. The longer than normal stopping distance carried the vehicle past the stop line, crosswalk and into the intersection of a crossing roadway. Anyone in the crosswalk or vehicle in the crossing roadway in the path of the vehicle would have been impacted. By placing the gear selector into Neutral, the vehicle was finally brought to stop. It is at this point I noted the tachometer read approximately 3500 RPM then slowly reduced to normal idle RPM. These aforementioned symptoms have not recurred since. The incident was brought to the attention of the manufacturer who referred me to the service department (local Ford dealer) who, in turn, did not identify any malfunctions. Service instructed me to monitor the operation of the vehicle and advise them of any problems. No malfunction codes/warnings/lights were present immediately before or after the incident.
NHTSA ODI #11653697
8,000 miles · Mar 19, 2025
Electrical SystemEngine
The contact owns a 2023 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer to be diagnosed, and it was determined that the wiring harness had failed due to rodents…
Read full complaint
The contact owns a 2023 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer to be diagnosed, and it was determined that the wiring harness had failed due to rodents chewing on the wires. The contact was informed that the wiring harness needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 8,000.
NHTSA ODI #11649336
125,000 miles · Mar 3, 2025
EnginePower Train
The contact owns a 2023 Ford F-150. The contact stated that while driving at various speeds, the vehicle experienced a loss of automotive power and independently shifted into park(P). Several unknown warning lights were illuminated. In addition, the contact stated that the vehicle failed to restart for several minutes and was un…
Read full complaint
The contact owns a 2023 Ford F-150. The contact stated that while driving at various speeds, the vehicle experienced a loss of automotive power and independently shifted into park(P). Several unknown warning lights were illuminated. In addition, the contact stated that the vehicle failed to restart for several minutes and was unable to shift of out park(P). The vehicle was previously taken to a local dealer and the engine control module was repaired; however, the failure persisted. The vehicle remained with the dealer for additional diagnostic testing. The manufacturer was made aware of the failure. The failure mileage was approximately 125,000.
NHTSA ODI #11645939
Mileage unknown · Feb 10, 2025
Engine
2.7 liter ecobost engine . Cam Phaser Failure, cam phasers control the performance, air intake and exhaust of the engine. Failure from these parts will affect engine performance and can cause engine damage. Similar recalls were issued for similar ford 3.5 liter engine in the past.
NHTSA ODI #11641625
Mileage unknown · Jan 29, 2025
Electrical SystemEngineFuel/propulsion System
I was driving down the road at approximately 35mph. The vehicle began to sputter and then started loosing power. I was only able to drive approximately another 150 meters and get over to the shoulder of the road. Once stopped the vehicle stopped running all together. The vehicle did have power but only to the electronics. T…
Read full complaint
I was driving down the road at approximately 35mph. The vehicle began to sputter and then started loosing power. I was only able to drive approximately another 150 meters and get over to the shoulder of the road. Once stopped the vehicle stopped running all together. The vehicle did have power but only to the electronics. The engine had shut down. I shut off the vehicle all the way and then restarted. It ran fine after that. This was on 01/29/2025. The vehicle had a previous instance where it did not start. It would crank the motor for approximately 6 to 8 seconds, the engine would fire and then shut off after about 1-2 seconds. The fuse box and wiring harness have both been replaced and the vehicle still seems to be having issues that could cause major damage and or injuries/death to the occupants.
NHTSA ODI #11639381
Official recalls
13Sep 9, 2026
Ford Motor Company (Ford) is recalling certain 2023-2027 F-150 vehicles. The fuel tank may be improperly secured and leak fuel, or detach from the vehicle while driving.
Consequence & remedy
Consequence: A detached tank can create a road hazard, increasing the risk of a crash. In addition, a fuel leak can cause an engine stall or increase the risk of a fire.
Remedy: Dealers will inspect and replace the fuel tank straps, as necessary, free of charge. Owner notification letters are expected to be mailed September 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S69. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 14, 2026.
Jul 28, 2026
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Additional source detail variants (2)
Back Over Prevention:display Function
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Back Over Prevention:software
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Additional source detail variants (2)
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Electrical System: Integrated Trailer Brake Control
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
Consequence & remedy
Consequence: A detached wind deflector can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.
Aug 8, 2025
Ford Motor Company (Ford) is recalling certain 2023-2025 F-150 vehicles equipped with the Trailer Tow Max Duty package and a 9.75-inch heavy duty axle with a 3/4 float axle design. The rear axle hub bolt may fatigue and break, which can result in damage to the axle hub splines.
Consequence & remedy
Consequence: Damaged axle hub splines can result in a vehicle rollaway when in park without the parking brake applied or cause a loss of drive power. Either of these conditions can increase the risk of a crash.
Remedy: Dealers will replace the left and right rear axle shaft assemblies, free of charge. This is a phased recall. Ford owners will receive letters in multiple phases, beginning August 2025 through Winter 2025. Phase 1 will include 2023 F-150 model year vehicles. Phase 2 will include 2025 F-150 model year vehicles and Phase 3 will include 2024 F-150 model year vehicles. Interim owner notification letters informing owners of the safety risk were mailed August 22, 2025. Owner notification letters were mailed August 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S82. This recall expands previous NHTSA recall number 23V896.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Consequence & remedy
Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Dec 22, 2023
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with the Trailer Tow Max Duty package and a 9.75-inch heavy duty axle with a 3/4 float axle design. The rear axle hub bolt may fatigue and break, which can result in damage to the axle hub splines.
Consequence & remedy
Consequence: Damaged axle hub splines can result in a vehicle rollaway when the vehicle is in park without the parking brake applied or cause a loss of drive power. Both of these conditions can increase the risk of a crash.
Remedy: Dealers will replace the left and right rear axle shaft assemblies, free of charge. Owner notification letters were mailed on May 9, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S65.
Dec 15, 2023
Ford Motor Company (Ford) is recalling certain 2023 F-150 and Ford SD F250, F350, F450, F550, and F600 vehicles. The steering wheel clock spring may have an insufficient weld, causing a loss of electrical connection to the driver's frontal air bag.
Consequence & remedy
Consequence: A deactivated air bag will not deploy during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the clock spring as necessary, free of charge. Owner notification letters were mailed on May 3, 2024. Owners may contact Ford customer service at 1-866-436-7332.
Additional source detail variants (2)
Air Bags:frontal:driver Clockspring/spiral Cassette
Ford Motor Company (Ford) is recalling certain 2023 F-150 and Ford SD F250, F350, F450, F550, and F600 vehicles. The steering wheel clock spring may have an insufficient weld, causing a loss of electrical connection to the driver's frontal air bag.
Consequence: A deactivated air bag will not deploy during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the clock spring as necessary, free of charge. Owner notification letters were mailed on May 3, 2024. Owners may contact Ford customer service at 1-866-436-7332.
Steering:column
Ford Motor Company (Ford) is recalling certain 2023 F-150 and Ford SD F250, F350, F450, F550, and F600 vehicles. The steering wheel clock spring may have an insufficient weld, causing a loss of electrical connection to the driver's frontal air bag.
Consequence: A deactivated air bag will not deploy during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the clock spring as necessary, free of charge. Owner notification letters were mailed on May 3, 2024. Owners may contact Ford customer service at 1-866-436-7332.
Jul 21, 2023
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with a single exhaust system. Contact with the rear axle housing may damage the wiring harness, causing the electric parking brake to activate unexpectedly.
Consequence & remedy
Consequence: Unexpected activation of the electric parking brake while driving increases the risk of a crash.
Remedy: Dealers will install a protective tie strap, tape wrap, and replace the harness as necessary, free of charge. Owner notification letters were mailed February 12, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S35.
Feb 24, 2023
Ford Motor Company (Ford) is recalling certain 2023 F-150, Expedition, and Lincoln Navigator vehicles. The front axle pinion may not have been heat-treated, which can cause it to fracture.
Consequence & remedy
Consequence: A fractured pinion can result in a loss of 4-wheel drive and may cause the front wheels to lock up, increasng the risk of a crash.
Remedy: Dealers will replace the front axle pinion gear set. If there is a broken front axle pinion, the entire axle assembly will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed April 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S07.
Feb 10, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."
Consequence & remedy
Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.
Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.
Feb 10, 2023
Ford Motor Company (Ford) is recalling certain 2023 F-150 vehicles. The instrument panel top cover on the passenger-side may prevent the air bag from deploying as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers will replace the passenger instrument panel top cover, free of charge. Owner notification letters were mailed March 16, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C01.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration