2019 Ford F-150

The contact owns a 2019 Ford F-150. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. No warning lights were illuminated. Additionally, occasionally, while shifted into drive, the transmission failed to shift as intended. The dealer was made aware of the failure several times; however, the contact was informed that the repair was not covered under recall. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the failure was a known failure with similar vehicles. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

Dear NHTSA Office of Defects Investigation, I am submitting this complaint to formally report a transmission failure involving a vehicle equipped with the 10R80 automatic transmission, which I believe represents a serious safety concern and may be part of a larger pattern of premature failures. The transmission began showing signs of failure at approximately 52,000 miles. Early symptoms included hesitation, harsh or delayed shifting, inconsistent engagement, and warning signs related to drivetrain or transmission performance. I sought service and diagnosis, but despite many similar failures being reported by other owners, no corrective action or goodwill repair was offered by the manufacturer or dealership. I was quoted approximately $9,000 by the dealership for a full transmission replacement. Due to the high cost, I continued operating the vehicle while monitoring the issue. Over time, the condition worsened significantly. As the transmission continued to fail, the vehicle would sometimes move forward and then suddenly stall or lose drive power while in traffic. This occurred while my family was in the vehicle and created a major safety concern, as the truck could unexpectedly lose movement in active traffic lanes, putting us at risk of a collision and leaving us unable to safely accelerate or clear intersections. On January 30, 2026, the transmission failed completely. The vehicle no longer moved when placed in gear, leaving it inoperable and unsafe to drive. Because assistance was denied and no recall or corrective action was available, I was forced to repair the vehicle at an independent repair shop at my own expense. The repair cost is approximately $7,000 out of pocket. This failure occurred at relatively low mileage for a major drivetrain component and appears consistent with numerous reports from other owners experiencing similar transmission issues. It is concerning that consumers are being required to absorb expensive repairs despite what appears t

After a stop sign, I turned right onto a busy street. With foot on the accelerator, vehicle would not accelerate, and I had to quickly turn off into the right of way to avoid a collision. Fortunately there wasn’t a curb there. The vehicle was in “D”. I believe the transmission is faulty. It has happened multiple times. Also, the vehicle occasionally will not go into Park, more evidence of a faulty transmission. I believe Ford should recall and replace the transmission before it causes a serious accident.

My 2019 Ford F-150 (2.7L EcoBoost) is subject to Emission Recall 24E12, which addresses a defective PCM calibration that Ford acknowledges "could, over time, reduce the effectiveness of the emissions control system and the monitoring accuracy of the catalytic converter's efficiency." COMPONENT: Catalytic converter system and powertrain control module (PCM). Vehicle is available for inspection at Rich Ford in Albuquerque, NM, where it has been serviced for this issue. TIMELINE: Prior to the 24E12 recall repair, my truck had intermittent P0420/P0430 codes (catalyst efficiency below threshold). The check engine light would illuminate and then clear on its own. I brought the vehicle to Rich Ford for the 24E12 PCM reprogram. Within approximately one month of the recall repair, the same catalytic converter codes returned, except now the condition is constant and no longer clears. This timeline is documented in my FordPass app and the dealer's service records. SAFETY RISK: The constant check engine light prevents the vehicle from passing Bernalillo County emissions testing, which is required for registration in Albuquerque, NM. I am unable to legally register my vehicle due to a condition caused by a manufacturer-acknowledged defect. DEALER CONFIRMATION: Rich Ford diagnosed the recurring P0420/P0430 codes. They initially attempted to charge me $300+ for extended diagnostics. They are now consulting with Ford about whether a catalytic converter replacement will be covered under the recall. PRIOR SYMPTOMS: The intermittent check engine light with P0420/P0430 codes existed before the recall repair but was not constant. The recall repair worsened the condition from intermittent to persistent. PATTERN: Ford's recall documentation states the MIL "may illuminate even though a catalytic converter repair may not be necessary," yet numerous owners report being quoted $1,900-$2,100+ for cat replacement at their own expense after the 24E12 reprogram. Ford corporate confirmed the $300

Transmission shifting is erratic at the best times and likes to randomly downshift from 10th gear to 1st gear and having to take drastic action to avoid a serious rear end collision in heavy traffic as many others who've reported the same issues. Ford is VERY aware of this issue but will not address it for most of the owners. The issue is well enough known Ford has had issued many TSBs but limited the action to a handful only with the most recent being TSB 22-2428. They have publicly stated the problems with the 10R80 Valve body and CDF clutch assembly, corrected it, but will not make it right with the thousands of owners. I contacted my dealer, who forwarded me to Ford corporate. I was informed that Ford WILL NOT do anything about it, and I was advised by the Ford CSR to make a complaint here. Will the US government hold Ford accountable; probably not unfortunately as looking through the endless history of reports here shows this is probably a wasted attempt. I have tried to upload PDFs of documentation, but the system WILL NOT accept them.

The tailgate latch actuator came open while I was driving home spilling all my tools out into the roadway including extension ladders that were folded down I had a bed cover on so I never seen or heard the tailgate there's no warning there's no lights there's no dinging and then don't come up on the camera or nothing like that I've contacted Ford dealership we have a case and police reports I've got it had a witness with me I'm having it inspected sometime soon I'm contacting the insurance agent now there was no warning labels whatsoever but over $10,000 worth of tools I had car batteries hand tools shovels tool boxes you name it come flying out this is the second time that this has happened but kk first time I caught it heard it I was this the second time I wasn't there was on the highway at night I came back luckily some kids had been cleaning some of it off they had took off most of my tools by then but I caught them they had the extension ladder and some other things thank God cuz it was laying in a blind curve on a highway at night

Truck started smoking from under the hood in the area of the battery compartment while driving. Then truck burst into flames. 53,000 miles. No injuries. Hillsborough County Fire Rescue came to the scene with report number XXX-XXX and can be reached at [XXX] . Sticker shows built in May 2019. There was a recall 19S40 which applied to vehicles made in June 2019. So I was only one month prior to the official recall date. However, 19S40 specifically mentions fire risk. I believe my truck had this defect and was not recalled when it should have been. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have had my 2019 Ford F-150 for 5 years now and always noticed that it was consuming oil. After further investigation I discovered that Ford put out TSB 19-2365 (and 19-2338) which I never received pertaining to oil consumption. I talked to Ford and they said they would inspect for a mere $199.00 dollars for a problem they new was a problem for my 5.0 liter coyote engine. Since the problem began I now have a faulty catalytic converter and 02 sensors because of this defect. I also have to purchase a catch can to prevent oil getting through to the catalytic converter.