Power Train. Review the 726 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 319 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 98 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

17 crash reports7 fire reports13 injury reports

Unknown Or Other complaints

130 reports

Clear category filter

Mileage unknown · Aug 27, 2024

Unknown Or Other

Unintended tailgate opening which hit a trailer jack while under tow. $3,652.38 in damages to repair tailgate.

NHTSA ODI #11611154

Mileage unknown · Jul 20, 2024

Electrical SystemUnknown Or Other

When we come to a complete stop and going at highway speed the transmission slips from 10th gear to 1st gear while driving then through other gears until it catches back up to the correct gear. The whole truck will stall until the correct gear is found causing us to possibly be hit

NHTSA ODI #11603510

Mileage unknown · Jul 18, 2024

Unknown Or Other

Read full complaint

Tail gate will not latch/lock properly. Tail gate will not latch into the closed position when pushed closed, and sometimes only partially latches. This may allow the cargo to fall on the road, putting other motorists in danger. Tail gate external latch handle remains in the open position and does not properly retract under spring pressure to the unopen position after manually opening. Tail gate latch handle must be forcibly manually closed with significant pressure to allow the tail gate to latch closed on the two side plate bosses. With out this manually effort, tail gate lock will not engage the locking bosses. If one is not careful to ensure full retraction the tail gate lock may not fully latch and could open while driving. I have Lubricated the latch handle mechanism latch locking mechanism and all joints, with no significant improvement. Defect or tolerance problem in latch mechanism is very likely. Prior recall on model year F-150’s have reported very similar problem

NHTSA ODI #11603109

Mileage unknown · Jun 20, 2024

Unknown Or Other

The truck rolls down my driveway while in park if the parking brake isn't applied. Has been repeated has not been inspected. Almost hit one of my children and went into the road. It is available for inspection. No warnings.

NHTSA ODI #11595620

Mileage unknown · Jun 10, 2024

Electrical SystemUnknown Or Other

Air conditioner loses cold air flow; suspects that the evaporator continuously freezes. Unable to defog windows causing loss of visibility while driving. Also, causes heat stress/ exhaustion from lack of cold air produced by vehicle.

NHTSA ODI #11593353

Mileage unknown · Jan 22, 2024

Unknown Or OtherVisibilityVisibility/wiper

Rear glass in sliding window shattered to pieces while driving.

NHTSA ODI #11566958

Mileage unknown · Jan 21, 2024

Electrical SystemUnknown Or OtherFire

While using remote start, the rear sliding glass window shattered and set the defroster on fire. The fire was above the rear seat where my child's car seat was.

NHTSA ODI #11566751

Mileage unknown · Jan 15, 2024

Unknown Or OtherVisibility

Read full complaint

On Sunday Jan [XXX], I had to drive 40min to the Hospital in Oconomowoc to pick up my daughter from ER, when leaving as I was backing out of the parking spot the back window bowed outward and shattered. Glass flew everywhere both inside the truck and outward. It was very cold in Wisconsin - but the vehicle was more than warm, and the back entire window just shattered. Luckily no one was in the back seat, or they would have been seriously cut by some of the small shards of glass that came into the vehicle. There was no damage to the rear window prior, and it basically exploded for no apparent reason. It does appear Ford has been aware of this but has not placed a recall. I have tried to contact a dealer to find out if this is covered under my extended warranty but cannot seem to get ahold of just the service department to discuss further. I think Ford needs to take more responsibility for these vehicles, I have never seen anything like this in my life. This is a 2019 Ford F150 Lariat with heated defroster and slide window that exploded without cause or fault of owner. I have filed a claim with my insurance company, but it's considered a glass issue and they don't usually send out an adjuster for glass- and based on deductible would be out of pocket cost for me when I feel this is a defective issue ford should be addressing. I do have an large amount of photos, but it wont let me upload all of them. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11565527

Mileage unknown · Dec 17, 2023

EngineUnknown Or OtherVehicle Speed Control

Read full complaint

Approximately 2 weeks after purchasing the truck I noticed some harsh shifting, jerking, and sudden acceleration, and hesitation issues. They were intermittent and I was advised this is not uncommon with this model vehicle. However, these issues have become more frequent and severe. Next, I noticed the gears began slipping and the truck seemed to not be able to “find” the gear it needed to be in. The transmission would slam into gear or begin slipping under acceleration. There is no rhyme or reason to it, I have not been able to pinpoint it to a specific gear or up/down shift. It simply loses power and neither the gas nor brake work. It will coast until the wrench (check engine?) symbol comes on and then the gas will function. This week the transmission has started intermittently locking into a specific gear without the ability to shift. It’s now happened 3 times. You cannot reverse or drive, the transmission puts itself in park while the dash still indicates its in drive or reverse. After parking the truck for a couple of hours, I could start and drive as usual. Most importantly, twice Saturday the truck seemed to shift out of gear, so hard my head hit the steering wheel, and lost power going 70mph on I64. I have attempted to video these events to help diagnose the issues, but obviously driving and recording are dangerous and difficult.

NHTSA ODI #11560536

Mileage unknown · Sep 1, 2023

Unknown Or Other

Read full complaint

The trucks computer has a glitch the past few weeks where it will request permission repeatedly for OTA updates. Since this started, the rear view camera sometimes stays on after shifting from reverse to drive. It has remained on up to 30-40mph before the screen goes completely black. When the screen goes black, no functions work on the screen or audio/nav/camera controls except the radio on/off manual button. A hard reset fixes the issue temporarily by restarting the SYNC system, however it reoccurs frequently. This issue can be a safety concern because it is very distraction and the audio/phone controls cannot be changed or used during driving (i.e. handsfree or nav if you were in the middle of using them). It also puts into question whether or not the rear view camera system works or if it is properly interfacing with the rear parking sensors of the vehicle.

NHTSA ODI #11542115

Official recalls

26V373000 · Exterior Lighting:headlights

Jun 9, 2026

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."

Consequence & remedy

Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.

Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

24V852000 · Equipment:other:labels

Nov 8, 2024

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

22V252000 · Back Over Prevention: Sensing System: Camera

Apr 14, 2022

Ford Motor Company (Ford) is recalling certain 2019 F-150, Super Duty F-250, F-350, F-450, and F-550 vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence & remedy

Consequence: A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

20V097000 · Exterior Lighting:headlights

Feb 21, 2020

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."

Consequence & remedy

Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.

19V805000 · Electrical SYSTEM:12V/24V/48V Battery:cables

Nov 12, 2019

Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.

Consequence & remedy

Consequence: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.

Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.

19V633000 · Seats:front Assembly:recliner; Seats:mid/rear Assembly

Aug 28, 2019

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Consequence & remedy

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

Additional source detail variants (2)

Seats:mid/rear Assembly

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

Seats:front Assembly:recliner

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

19V278000 · Engine; Equipment:electrical

Apr 8, 2019

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.

Consequence & remedy

Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.

Additional source detail variants (2)

Engine

Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.

Equipment:electrical

Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

18V894000 · Engine

Dec 18, 2018

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.

Consequence & remedy

Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.

Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE23001 · Windshield Trim Molding Item Detachment

Opened Jan 27, 2023 · Closed Feb 8, 2024

Status: closed (inferred from source dates) · Structure:body:roof And Pillars

On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.