Power Train. Review the 726 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 319 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 98 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

17 crash reports7 fire reports13 injury reports

Unknown Or Other complaints

130 reports

Clear category filter

Mileage unknown · Jul 27, 2025

Back Over PreventionUnknown Or Other

Back up camera stops working intermittently.

NHTSA ODI #11676450

Mileage unknown · Jul 11, 2025

Unknown Or Other

The APIM/Radio keep losing saved/stored info after vehicle is turned off. The rear back up camera will go blank while in reverse or will activate while driving or will stay stuck on the rear view mode after putting vehicle in drive or park. Screen will also go black while in operation making it impossible to use hands free mode …

Read full complaint

NHTSA ODI #11672724

Mileage unknown · Jul 8, 2025

Unknown Or Other

Back up camera went black, then a very distorted picture came back on. I could not see to safely back up. Diagnosed by dealer found internal failure of back up camera.

NHTSA ODI #11672064

Mileage unknown · Jul 2, 2025

Unknown Or Other

Back up camera is foggy, can't make out objects, when it rains hard and your backing up camera alert signal goes off even if nothing is there. When rain stops and there are a few dry days of weather the camera is still foggy and unable to make out objects. The service department can examine the camera and easily see the problem.…

Read full complaint

NHTSA ODI #11670889

Mileage unknown · Jun 14, 2025

Power TrainUnknown Or Other

Need software update for Transmission and SYNC to 4 or 5 Speed sensor

NHTSA ODI #11666939

Mileage unknown · Jun 3, 2025

StructureUnknown Or Other

Read full complaint

Rear window ford part number 1542006 - Back window glass has 1" cracks in glass where the glass connects to the body on the left passenger side of the crew cab. Cracks have caused leaks into the cab interior and has caused the modem, mounted behind the rear passenger set on the back wall to stop working as water has infiltrated the electronics. Vehicle was inspected at dealership and their 3rd party glass leak specialists discovered the cracks in the glass connection. I have no idea as to how long this has been going on, estimate a few months as I recently discovered I could not communicate with the vehicle through the Ford Connect App and called Ford Connect, they identified an issue with the modem and when I pulled back the upholstery to see, there was water dripping inside the vehicle. Unknown if cracks will propagate, however they are leaking when it rains. I will be replacing the glass to prevent further leaks from occurring. I have extended warranty through Ford and "glass" is not covered. Reached out to Ford Care and they would not cover. Suggested that I put in a report here so that if later recall or other action, I might be able to get refund for the repair that I am now going to have to pay for to replace the glass and possibly the modem. No other symptoms other than the filaure of the modem that alerted to the issue.

NHTSA ODI #11664565

Mileage unknown · May 29, 2025

Unknown Or Other

I see there is a current recall on 2021-2024 Ford F150 vehicles for backup camera failure. I am having the exact issue on my 2019 Ford F150. How can I get my vehicle added to the recall list to fix the issue?

NHTSA ODI #11663616

Mileage unknown · May 29, 2025

Unknown Or Other

Camera will freeze or not appear at all if switching into reverse right after starting the vehicle.

NHTSA ODI #11663600

Mileage unknown · May 28, 2025

Back Over PreventionElectrical SystemUnknown Or Other

Read full complaint

Rear view camera used to glitch when put in reverse. Now it goes completely black (or blue) when vehicle is in reverse. There was a recall on this involving 2021 and newer models but I believe this problem goes back even further. Because it’s a truck, I have a huge blind spot in the back when reversing and I worry mostly about a potential accident involving property, persons, or even my own children. It’s very unsafe. I want to note that I was in contact with Ford Customer Service but they said that my vehicle wasn’t covered under the recall and that there was nothing they can do for me.

NHTSA ODI #11663512

Mileage unknown · May 21, 2025

Forward Collision AvoidanceUnknown Or Other

Rear Camera Recalls for the F-150 are well documented, yet my VIN is omitted. For over a year, the image will be intermittently blue, black, and colored lines.

NHTSA ODI #11662391

Official recalls

26V373000 · Exterior Lighting:headlights

Jun 9, 2026

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."

Consequence & remedy

Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.

Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

24V852000 · Equipment:other:labels

Nov 8, 2024

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

22V252000 · Back Over Prevention: Sensing System: Camera

Apr 14, 2022

Ford Motor Company (Ford) is recalling certain 2019 F-150, Super Duty F-250, F-350, F-450, and F-550 vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence & remedy

Consequence: A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

20V097000 · Exterior Lighting:headlights

Feb 21, 2020

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."

Consequence & remedy

Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.

19V805000 · Electrical SYSTEM:12V/24V/48V Battery:cables

Nov 12, 2019

Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.

Consequence & remedy

Consequence: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.

Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.

19V633000 · Seats:front Assembly:recliner; Seats:mid/rear Assembly

Aug 28, 2019

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Consequence & remedy

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

Additional source detail variants (2)

Seats:mid/rear Assembly

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

Seats:front Assembly:recliner

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

19V278000 · Engine; Equipment:electrical

Apr 8, 2019

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.

Consequence & remedy

Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.

Additional source detail variants (2)

Engine

Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.

Equipment:electrical

Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

18V894000 · Engine

Dec 18, 2018

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.

Consequence & remedy

Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.

Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE23001 · Windshield Trim Molding Item Detachment

Opened Jan 27, 2023 · Closed Feb 8, 2024

Status: closed (inferred from source dates) · Structure:body:roof And Pillars

On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.