2019 Ford F-150

PowerTrain Malfunction Failed, notification on my vehicle appeared on 4/28/23, although I had been notifying dealer for 3 months prior the safety issue I was experiencing, and nearly got killed on a major interstate, on 4/26/23 my truck stalled as foot pedal would not work. Major safety of semi-trucks and other vehicles on main I30 Interstate were trying to avoid hitting me due to my vehicle abruptly downshifts from 10- to 1st gear. Foot pedal inoperable during that time. Yes, the dealer and Ford on 4/28/23 provided me a rental vehicle after my near collision experience until they figure out what to do, replace transmission or rebuild, unresolved. No the vehicle had no warnings, but did have symptons, which I took to dealer and they ran a diagnostic, and found nothing, they said there are TSBs out there with the downshifting issues, and stalling, jerking of transmission. But they said just wait it out initially, and I had to call Ford Corporate relations and raise the roof, after I nearly got killed by semi trucks from being stuck in a major interstate highway. December 2022 when it began, the dealer kept doing a reset, which seemed to make it worse, then when I told them how unsafe it was they ignored me, until April 26th when I left a voice mail after nearly being killed. I demanded service as I have a warranty and they ignored the symptoms for so long. Multiple people could have been killed on the interstate when my truck stalled, I had to try and coast to the side of interstate as the truck foot pedal did not work after downshifting from 8 to 1.

My 2019 F-150 has the 10-speed transmission which shifts erratically. Driving down the interstate the transmission goes into a "neutral mode" which greatly reduces the speed, thus nearly causing me to be rear-ended. When this happens, I've noticed the gear selection lights on the dash go from 10th gear to 1st gear during the "neutral mode". This has happened on numerous occasions. The last couple of times this has happened a "gear" light will display on the cluster. Shifting between 1-3 , 4-6, and 7-9 seems to shift very hard and erratic, sometimes missing gears. The truck is presently at the dealership, but it has been acting up for a month. The dealership was booked and couldn't get it in until 5/1/2023

The contact owns a 2019 Ford F-150. The contact stated that at startup, she heard a rattling sound at the hood of the vehicle. The contact then stated that while driving at an undisclosed speed, the vehicle stalled. The vehicle was able to be restarted. The contact was unsure of any warning lights. The vehicle was taken to the dealer where it was diagnosed that the PCM needed reprogramming with the 21B10 update. The vehicle was repaired; however, the failure recurred. The contact stated that while driving at an undisclosed speed, the vehicle started to shudder, and the vehicle stalled, without warning. The vehicle was taken to a different dealer where it was diagnosed that the Cam phaser, bolts, seal, engine valves, engine gasket, and crank shaft oil needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer was notified of the failure and the contact was informed that the warranty had expired and advised to contact the NHTSA Hotline. The failure mileage was approximately 107,328.

After purchasing my 2019 Ford F150 equipped with a V8 engine I noticed a loud knocking or tapping noise coming from the engine and a large consumption of oil happening. With no visible leaks I was putting about 1.5 to 2 quarts of oil a month in the engine to keep it filled. Loosing that much oil so fast could cause the engine to experience a catastrophic engine failure at any driving speed causing danger to me, my family, or other drivers on the road. Not to mention the environmental impacts caused by the engine burning so much oil so fast in possibly thousand of trucks across the country. I scheduled service with a Ford dealership. I have taken the truck in twice to have it looked at. Dealership has performed several service bulletins on it but it is still making a knocking and tapping noise and using excess amounts of oil. I have been told by ford dealership that they are aware of the problem and unable to determine if, or when, problem will be able to be fixed. This seems unacceptable knowing the truck is still under factory warranty. I have looked for answers online and found this engine in 2018-2021 Ford F-150 trucks is causing the same problem for a HUGE amount of other Ford truck owners as well.

The contact owns a 2019 Ford F-150. The contact stated while accelerating from a complete stop to 35 MPH, the vehicle hesitated and jolted while shifting into gear. Additionally, the contact stated that while at a complete stop and depressing the brake pedal, the vehicle revved. There was no warning light illuminated. The contact stated that the failure had been reoccurring. The vehicle was taken to the local dealer, where it was diagnosed that the fuel was contaminated and a gasoline additive was added; however, the failure persisted. The vehicle was taken back to the same dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 80,000. The contact stated that when the transmission issues started, the local dealer informed the contact that they were short staffed and could not provide a loaner vehicle. After taking the vehicle to a second dealer, it was found that the transmission needed to be replaced.

I got the truck with 10,00 miles and currently have 47,000 miles. I have been having oil burning issues since the beginning, but it has gotten worse. When I was adding the oil myself before having the dealership do it I was having to add almost 4 qts per 5-6 thousand miles. I have been taking it to the dealership every 1000 miles for oil consumption test. Typically, my oil burns over 1/2 qt per 1000 miles so the dealership claims. I have also claimed about harsh shifting and clunking noises. Most recently I took it in for the harsh shifting of the transmission and 4 wheel drive while the did the oil test. They reflashed the transmission and topped off the oil. The dealership then forgot to put the oil cap back on (I didn't think I had to check their work) the next day after a short drive there was oil all over my engine, electrical systems, battery, suspension and underbody because of the missing cap. They took the truck back and then claimed only a 1/2 qt was gone. The dealership after a few days tells me it is all cleaned and ready to go. I got the truck with oil all over the place. So they keep the truck yet again, few days later I get the truck back and my truck is shifting worse in some ways now than before the flash. Today I had to take the truck in for an engine light about the catalytic converter failing. While they had the truck there it then gave a bunch of codes of powertrain body control all related to lack of power and powertrain failure. displaying a bunch of red lights including a gear wrench on the instrument cluster. These only appeared after the tech scan the first code. The dealership now has my truck yet again and have said it will be at least a few days.