seat back with an improperly assembled recliner mechanism not adequately restrain The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat Transmission shifts extremely hard. It clunks most of the time when I turn the vehicle on. Often, when I shift from park to drive the …
Read full complaint
seat back with an improperly assembled recliner mechanism not adequately restrain The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat Transmission shifts extremely hard. It clunks most of the time when I turn the vehicle on. Often, when I shift from park to drive the trunk lurches forward even with my foot pressed down all the way on the break. It's in the ford dealer right now and all they can find is low transmission fluid. Although I've never had a warning light or anything on before. dropping from 10th gear to 5th gear when cruise is set and accelerator is pressed Truck will set advanced traction control warning off and slam so hard into 5th gear you are destructed looking to see if you were in a accident.. I have videos that were provided to Ford Motor Company and have had in 2 Ford dealership s 3 times for repairs.Ford Motor Company has 2 engineer cases opened on truck the second case they told dealership it was my fault with the abrupt shifting slamming and traction control warning at 72 mph on interstate. Ford refuses to address the safety issue. It is a hazard to me and passengers in my vehicle as well as the motoring public. Ford motor company has been notified they can assume liability if I am in a accident and someone is injured due to their negligence or refusal to fix defect. Truck has had issues since around 3500 on the odometer it now has 16,567 miles currently.This as well as any other erratic shifting complaints with said 10R180 should be fully investigated and taken seriously because it will and I am sure has contributed to crashes!!!! The vehicle has the technology package which allows you to start /stop the vehicle with an app in your phone. I assume the motor has bluetooth attached to it. The problem is that when your driving the vehicle will just shut down. Once this happens you have to stop the vehicle, put it in park, and restart the engine.
NHTSA ODI #11427243
Mileage unknown · Jun 11, 2021
Engine
While driving on a residential street the vehicle turned off and displayed “auto startstop shift to P then restart”. This happened several times until I pulled into my driveway.
NHTSA ODI #11420596
Mileage unknown · May 11, 2021
EnginePower Train
MY 2019 FORD F150 HAS A RECALL FOR THE PHASER NOCKING BUT LIVERMORE FORD DON'T WANT TO FIX IT UNTIL FURTHER NOTICE FROM FORD CORPORATE, I CAN NOT DRIVE MY TRUCK AND I CAN NOT SELL IT BECAUSE OF THE KNOCKING NOISE. I AM STUCK WITH 30K TRUCK, PLEASE SEE ATTACHMENT FROM FORD
NHTSA ODI #11416194
13,000 miles · Apr 19, 2021
Engine
ENGINE RATTLES DURING ACCELERATION. RATTLE NOISE WHEN YOU LEFT OFF GAS PEDAL WHEN ENGINE IS COLD AND WHILE DRIVING.
NHTSA ODI #11412941
13,487 miles · Apr 10, 2021
Engine
THE VEHICLE APPEARS TO BE USING AN EXCESSIVE AMOUNT OF OIL AND AFTER OPERATING FOR PERIODS OF TIME, THE SMELL OF BURNT OIL IS APPARENT. VEHICLE HAS LESS THAN 14,000 MILES; THERE ARE NO VISIBLE LEAKS, NO VISIBLE DAMAGE OR DEFECT TO THE OIL PAN, AND NO VISIBLE DEFECT OR DAMAGE TO THE QUICK DRAIN ASSEMBLY. VEHICLE OIL WAS AT MAXIMU…
Read full complaint
THE VEHICLE APPEARS TO BE USING AN EXCESSIVE AMOUNT OF OIL AND AFTER OPERATING FOR PERIODS OF TIME, THE SMELL OF BURNT OIL IS APPARENT. VEHICLE HAS LESS THAN 14,000 MILES; THERE ARE NO VISIBLE LEAKS, NO VISIBLE DAMAGE OR DEFECT TO THE OIL PAN, AND NO VISIBLE DEFECT OR DAMAGE TO THE QUICK DRAIN ASSEMBLY. VEHICLE OIL WAS AT MAXIMUM THRESHOLD ONE MONTH AGO AND IS NOW AT LOWER EYELET OF THE DIP STICK INDICATOR. INTELLIGENT OIL LIFE INDICATOR STATES THAT OIL LIFE IS AT 65%.
NHTSA ODI #11407372
18,405 miles · Mar 23, 2021
Electrical SystemEngine
VEHICLE SHUT DOWN WHILE MOVING AND DISPLAYED MESSAGE ' AUTO START STOP SHIFT TO P THEN RESTART ENGINE' AFTER COMING TO A STOP WITH NO POWER BRAKES OR STEERING, VEHICLE TOOK APPROXIMATELY FIVE SECONDS TO RESTART AND HAD A DIFFICULT TIME DOING SO
NHTSA ODI #11404399
9,400 miles · Mar 2, 2021
Engine
STALLS WITH NO NOTICE
NHTSA ODI #11398770
14,230 miles · Jan 3, 2021
Engine
OIL CONSUMPTION ENGINE USING AT LEAST 2 QUARTS OF OIL EVERY 1500 T0 2000 MILES SINCE I BOUGHT THIS VEHICLE I HAVE CHANGED THE OIL TWICE AND EACH TIME IT GOES THREW 2 PLUS QUARTS WITHIN 1500 T0 2000 MILES OF BEING CHANGED..ADDED 5W20 SYNTHETIC OIL EACH TIME 4 TO 5 QTS. SINCE HAVING THE TRUCK. MILEAGE NOW 14,230 THIS IS NOT ACCEPT…
Read full complaint
OIL CONSUMPTION ENGINE USING AT LEAST 2 QUARTS OF OIL EVERY 1500 T0 2000 MILES SINCE I BOUGHT THIS VEHICLE I HAVE CHANGED THE OIL TWICE AND EACH TIME IT GOES THREW 2 PLUS QUARTS WITHIN 1500 T0 2000 MILES OF BEING CHANGED..ADDED 5W20 SYNTHETIC OIL EACH TIME 4 TO 5 QTS. SINCE HAVING THE TRUCK. MILEAGE NOW 14,230 THIS IS NOT ACCEPTABLE FOR A NEW ENGINE!
NHTSA ODI #11386217
6,370 miles · Nov 13, 2020
Electrical SystemEnginePower Train
VEHICLE SHUTS DOWN. I WAS WAITING IN LINE OF TRAFFIC FOR THE TRAFFIC LIGHT TO TURN GREEN. MOTOR STOPS, LIGHTS GO OUT. PLACED IN NEUTRAL AND TRIED TO RESTART, WOULD NOT START UNTIL AFTER 3 - 4 MINUTES.
NHTSA ODI #11374595
28,300 miles · Oct 24, 2020
EngineSteeringVehicle Speed Control
THIS HAPPENED TWICE TODAY 10/24/2020. FIRST TIME I WAS STOPPED AT A TURNING LIGHT ON A MAIN ROAD AND AS SOON AS I LET OFF THE BREAK THE ENGINE SHUTOFF. SECOND TIME I WAS IN A RESIDENTIAL NEIGHBORHOOD MAKING A TURN AND THE ENGINE SHUTOFF ONCE AGAIN DISPLAYING THE IMAGE ATTACHED.
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Ford Motor Company (Ford) is recalling certain 2019 F-150, Super Duty F-250, F-350, F-450, and F-550 vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.
Consequence & remedy
Consequence: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Consequence & remedy
Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2019 Ford F-150 Problems, Complaints & Recalls | Skip That Year
Illustration