IllustrationUnknown about what causes the issue but was Told it was manufacturers fault not mine. Insurance adjuster came out as well and said that my full coverage won’t cover anything at this point and told me as well to go contact the manufacturers to see what the option are available
2007 Ford Expedition
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Ford Expedition do not stand out strongly from the model-year median of 155.
About this comparison →How this year compares
Owner complaints by model year
Compare all Expedition years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
560–25K
2425–50K
3250–75K
2875–100K
26100–150K
20150K+
186 reports with mileage · 29 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports5 fire reports5 injury reports
Engine complaints
21 reportsI HAVE TO REPLACE SPARK PLUGS EVERY WEEK. THE ENGINE EITHER KEEPS MAKING THE PLUGS FOUL OUT, OR IT BURNS THE TIP RIGHT OFF THE ENGINE. I'M STARTING TO SEE FROM THE COMPLAINTS THIS IS A COMMON ISSUE. I DON'T FEEL SAFE DRIVING THE VEHICLE WITH MY 6 KIDS BECAUSE OF HOW BAD IT KEEPS MISSING AND TRYING TO DIE. I CHANGE PLUGS THEN DR…
Read full complaint
I HAVE TO REPLACE SPARK PLUGS EVERY WEEK. THE ENGINE EITHER KEEPS MAKING THE PLUGS FOUL OUT, OR IT BURNS THE TIP RIGHT OFF THE ENGINE. I'M STARTING TO SEE FROM THE COMPLAINTS THIS IS A COMMON ISSUE. I DON'T FEEL SAFE DRIVING THE VEHICLE WITH MY 6 KIDS BECAUSE OF HOW BAD IT KEEPS MISSING AND TRYING TO DIE. I CHANGE PLUGS THEN DRIVES WELL FOR ABOUT A WEEK.
ENGINE STARTED MAKING NOISE. PULLED IT A PART AND FOUND THE COMMON 5.4 LITER PROBLEM. THE CAM LOBS WAS EATEN UP ROLLER HAD FROZEN UP AND EATEN CAM UP AND TAPET HAS WENT BAD ALSO. VECH WAS IN USE WHEN THIS STARTED.
I HAVE A 2007 FORD EXPEDITION WILL START UP IN THE MORNING AND BE FINE UNTIL IT WARMS UP THEN IT WILL STALL OUT IN THE MIDDLE OF THE ROAD OR AT STOP SIGHS OR LIGHTS THESE MOTORS ARE KNOW TO HAVE PROBLEMS FROM FACTORY IT IS MY ONLY CAR I HAVE TO GO TO COLLEGE I NEED HELP RESOLVING THIS ISSUE
CAR HAS ALWAYS BUCKED AND TRUCK AND TRIED TO CATCH UP TO IT SELF. NOW I HAVE A TICKING SOUND COMING FROM UNDER MY HOOD. TICKING STAYS THE SAME RUNNING LOW RPM OR AT A HIGHER RPM.
DELEVOPED A TICKING NOISE TIMING CHAINS WERE REPLACED ALL ROCKERS AND LIFTERS ARE IN GOOD SHAPE THE TRUCK LOOSES POWER IT STARTS UP ROUGH AT ABOUT 1800 RPM YOU CAN HEAR THE TICKING LOUD PAST 2000 RPM THE TICKING GOES AWAY I HAVE RECENTLY BEEN NOTIFIED THAT THESE ENGINES HAVE CAM PHASER PROBLEMS IT RECENTLY DEVELOPED A P0022 CODE…
Read full complaint
DELEVOPED A TICKING NOISE TIMING CHAINS WERE REPLACED ALL ROCKERS AND LIFTERS ARE IN GOOD SHAPE THE TRUCK LOOSES POWER IT STARTS UP ROUGH AT ABOUT 1800 RPM YOU CAN HEAR THE TICKING LOUD PAST 2000 RPM THE TICKING GOES AWAY I HAVE RECENTLY BEEN NOTIFIED THAT THESE ENGINES HAVE CAM PHASER PROBLEMS IT RECENTLY DEVELOPED A P0022 CODE WHICH IS INT CAM POSITION TIMING OVER RET BANK 2 I HAVE REPLACED THE VVT SELONOIDS AND STILL HAS THE SAME PROBLEM VEHICLE LOST POWER ON HIGHWAY SPEED DROPPED FROM 70 AND WOULD NOT GO PAST 30 VERY UNSAFE INCEDENT ON THE INTERSTATE
TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED AND THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS PUSHED TO THE SIDE OF THE ROAD AND TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT A SENSOR NEXT TO THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED AND THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS PUSHED TO THE SIDE OF THE ROAD AND TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT A SENSOR NEXT TO THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. IN ADDITION, WHILE DRIVING 60 MPH, THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 219,935.
THE ENGINE HAS CAUSED THE VEHICLE TO HAVE COMPLETE LOSS OF POWER. IT IS STALLING OUT AND WILL NOT DRIVE AT ALL.
MY TRUCK WAS PURCHASED NEW AND I HAVE RECENTLY HAD MORE FUEL GAS WASTE QUICKLY IN THE PAST YEAR. I RECENTLY HAD THE FUEL LINE CHANGED IN JUNE 2017 BECAUSE A SPARK PLUG BURNT OUT AND CAUSED IT TO HAVE A LEAK THAT WAS DANGEROUSLY CLOSE TO THE GAS TANK. I HAVE 123K MILES ON IT AND THE CHECK ENGINE LINE COMES ON EVERY TIME AFTER HAL…
Read full complaint
MY TRUCK WAS PURCHASED NEW AND I HAVE RECENTLY HAD MORE FUEL GAS WASTE QUICKLY IN THE PAST YEAR. I RECENTLY HAD THE FUEL LINE CHANGED IN JUNE 2017 BECAUSE A SPARK PLUG BURNT OUT AND CAUSED IT TO HAVE A LEAK THAT WAS DANGEROUSLY CLOSE TO THE GAS TANK. I HAVE 123K MILES ON IT AND THE CHECK ENGINE LINE COMES ON EVERY TIME AFTER HALF A GAS TANK IS DONE. I HAD THE TRUCK DRIVING AND IT SHUTS OFF ON ITS OWN. SOMETIMES IT WILL HAVE A STRONG SHAKING OF THE MOTOR OR NO WARNING AT ALL WHILE DRIVING ON THE ROAD. I'M VERY CONCERNED BECAUSE WE THOUGHT IT WAS THE CAMSHAFT WHICH IS WHAT THE ERROR CODE POPS UP AND THE SPARK PLUGS AND COILS HAVE BEEN REPLACED. EVERY THING ELSE HAS BEEN MAINTAINED BUT I'M STILL HAVE THE ENGINE AND FUEL PROBLEM. THE GAS GOES SO FAST AND THIS IS A V8 WHERE I USUALLY DRIVE A 6 MILE TO WORK NOW SAYS IT HAS BEEN A 40 MILE DRIVE. DON'T KNOW WHAT ELSE TO DO AND MAY TAKE IT BACK TO TRADE FOR ANOTHER VEHICLE BRAND. I HAD TO PARK THE TRUCK AFTER IT SHUT OFF ON ME AGAIN ON A SIDE STREET BEFORE GETTING ON THE HIGHWAY.
I HAVE THE 5.4 ENGINE IN MY 2007 FORD EXPEDITION WITH ONLY 70,000 MILES WHICH I PURCHASED IN 2007. I AM NOW EXPERIENCING CAM SENSOR PROBLEMS, THROTTLE BODY PROBLEMS AND NEED MAJOR REPAIRS. I HAVE VISITED MANY SITES AND UNDERSTAND THAT FORD HAS BEEN SUED BECAUSE OF COMPLAINTS WITH THIS PARTICULAR ENGINE AND NOTHING CAME FROM TH…
Read full complaint
I HAVE THE 5.4 ENGINE IN MY 2007 FORD EXPEDITION WITH ONLY 70,000 MILES WHICH I PURCHASED IN 2007. I AM NOW EXPERIENCING CAM SENSOR PROBLEMS, THROTTLE BODY PROBLEMS AND NEED MAJOR REPAIRS. I HAVE VISITED MANY SITES AND UNDERSTAND THAT FORD HAS BEEN SUED BECAUSE OF COMPLAINTS WITH THIS PARTICULAR ENGINE AND NOTHING CAME FROM THIS SUIT. THIS STARTED AROUND 2-3 WEEKS AGO, I HAD BEEN TRAVELING FOR 2-1/2 HOURS AND JUST PULLED OFF THE HIGHWAY TO ENTER INTO MY HOUSING PLAN, WHEN MY CAR LOST RPMS, BECAME VERY ROUGH, AND THEN STALLED. WHEN THE VEHICLE IS ON OPEN IT ROAD IT RIDES GREAT UNTIL YOU SLOW DOWN AND THE RPM FALLS, THEN IT STUMBLES AND STALLS. I HAD AT THE DEALERSHIP A COUPLE OF TIMES, BUT UNTIL CHECK ENGINE LIGHT CAME ON, I COULD NOT GET IT DIAGNOSED. OVER THE WEEKEND THE CHECK ENGINE LIGHT FINALLY LITE AND AS I STATED IT IS THE CAM POSITION SENORS AND STATES THAT THE SYSTEMS TOO RICH. I TALKED WITH A FORD REP TODAY AND THIS WILL BE ABOUT A $2000 REPAIR BILL, BUT UNTIL I CAN GET IT TO THEM AND THEY PLACE ON THEIR COMPUTER, THEY CANNOT GIVE ME THEIR FINAL ESTIMATE IF IT CAN BE REPAIRED OR I NEED A NEW ENGINE. I HAVE MANY MISGIVINGS ABOUT THIS SINCE ALL THAT I HAVE READ ON THE INTERNET ABOUT ALL THE PROBLEMS WITH THIS PARTICULAR ENGINE. FORD SHOULD BE HELD ACCOUNTABLE FOR A FAULTY ENGINE, AND BUYERS SHOULD BE MADE AWARE OF THIS PROBLEM ESPECIALLY WHEN THEY ARE BUYING A USED VEHICLE FROM A FORD DEALERSHIP WHO IS DEFINITELY AWARE OF THIS PROBLEM.
Official recalls
208V057000 · Fuel System, Gasoline:fuel Injection System:fuel Rail
Feb 5, 2008
FORD IS RECALLING 57,199 MY 2006-2007 E-150, E-250, E-350, AND MY 2007 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES EQUIPPED WITH 5.4L ENGINES. THE FUEL RAIL CROSS-OVER HOSE MAY CONTAIN WEAK AREAS. AS A RESULT, THE HOSE MAY CRACK, WHICH COULD CAUSE A FUEL ODOR AND/OR FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL RAIL ASSEMBLY. THE RECALL BEGAN ON MARCH 3, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
08V058000 · Latches/locks/linkages:doors:latch
Feb 5, 2008
FORD IS RECALLING 123,632 MY 2007-2008 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES. THE DOOR HANDLE HOUSING EMBOSSMENT RETAINING THE BOTTOM OF THE INTERIOR DOOR HANDLE SPRING ON ALL SIDE DOORS MAY FRACTURE DURING NORMAL CUSTOMER USAGE. THIS CAN RESULT IN INSUFFICIENT SPRING FORCE TO RETURN THE HANDLE TO THE FULLY CLOSED POSITION. THE HANDLE MAY BE LOOSE CAUSING A RATTLE OR NOISE AND THE HANDLE MAY NOT RETURN TO THE FULLY CLOSED POSITION. THIS CONDITION MAY ALSO PROVIDE A DELAYED RESISTANCE WHEN ACTUATING THE HANDLE PRIOR TO OPENING THE DOOR.
Consequence & remedy
Consequence: IN THE EVENT OF A SIDE IMPACT CRASH, THE INTERIOR DOOR HANDLE MAY CAUSE THE DOOR LATCH TO OPEN INCREASING THE RISK OF INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE INTERIOR HANDLE SPRING ON ALL SIDE DOORS. THE RECALL BEGAN ON MARCH 5, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO