IllustrationSTARTED HEARING A CLUNKING SOUND ON THE REAR SHOCK. BACK REAR SHOCK TOWER ROTTED OUT. NOT EVEN ANYTHING TO WELD IT TOO. HAD TO HAVE IT REBUILT.
2005 Ford Escape
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Ford Escape do not stand out strongly from the model-year median of 996.
About this comparison →How this year compares
Owner complaints by model year
Compare all Escape years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7425–50K
11950–75K
23375–100K
488100–150K
209150K+
1,211 reports with mileage · 183 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 459 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 434 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 153 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports20 fire reports20 injury reports
What owners actually said
1,394 reportsTL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING OVER A HUMP IN THE ROAD, THE CONTACT HEARD A LOUD BANGING NOISE. THE CONTACT PERFORMED A TEST DRIVE AND DISCOVERED THAT THE REAR PASSENGER WHEEL WELL HAD A RUSTED HOLE UNDERNEATH THE VEHICLE AND THE SHOCK ABSORBER WAS DETACHED FROM THE ORIGINAL MOUNT. THE MANUFACTURER WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING OVER A HUMP IN THE ROAD, THE CONTACT HEARD A LOUD BANGING NOISE. THE CONTACT PERFORMED A TEST DRIVE AND DISCOVERED THAT THE REAR PASSENGER WHEEL WELL HAD A RUSTED HOLE UNDERNEATH THE VEHICLE AND THE SHOCK ABSORBER WAS DETACHED FROM THE ORIGINAL MOUNT. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 70,000.
RIGHT REAR SHOCK TOWER MOUNT IS COMPLETELY RUSTED AWAY. THE SHOCK HAS FORCED THE TOWER UP INTO THE WHEEL WELL, THROUGH THE PLASTIC IN THE INTERIOR OF THE CAR. THE CAR IS UNSAFE TO DRIVE. FORD ISSUED A RECALL FOR THE EXACT SAME PROBLEM FOR 2001-2004 ESCAPE VEHICLES MANUFACTURED, BUT NOT FOR THE 2005 MODEL WHICH HAS THE EXACT SAME…
Read full complaint
RIGHT REAR SHOCK TOWER MOUNT IS COMPLETELY RUSTED AWAY. THE SHOCK HAS FORCED THE TOWER UP INTO THE WHEEL WELL, THROUGH THE PLASTIC IN THE INTERIOR OF THE CAR. THE CAR IS UNSAFE TO DRIVE. FORD ISSUED A RECALL FOR THE EXACT SAME PROBLEM FOR 2001-2004 ESCAPE VEHICLES MANUFACTURED, BUT NOT FOR THE 2005 MODEL WHICH HAS THE EXACT SAME PROBLEM.
I HAVE A 2005 FORD ESCAPE THAT STARTED MAKING SOUNDS IN THE BACK OF THE VEHICLE WHILE DRIVING IN THE TOWN STREETS COMING HOME WHEN I HIT BUMPS. WE LOOKED AT THE REAR PASSENGER SIDE TIRE WELL AND THE SHOCK MOUNT IS RUSTED THROUGH. THE BODY IS RESTING ON THE COIL. I AM AFRAID TO DRIVE IT DUE TO THE DANGER OF THE BODY COMING DOW…
Read full complaint
I HAVE A 2005 FORD ESCAPE THAT STARTED MAKING SOUNDS IN THE BACK OF THE VEHICLE WHILE DRIVING IN THE TOWN STREETS COMING HOME WHEN I HIT BUMPS. WE LOOKED AT THE REAR PASSENGER SIDE TIRE WELL AND THE SHOCK MOUNT IS RUSTED THROUGH. THE BODY IS RESTING ON THE COIL. I AM AFRAID TO DRIVE IT DUE TO THE DANGER OF THE BODY COMING DOWN ON THE WHEEL.
RIGHT REAR WHEEL WELL ROTTED OUT CAUSING SHOCK TO BREAK THROUGH TRUNK AND CAUSE LOUD BANGING. FORD CHARGES $1,548.40 TO FIX. NOW AS IN OTHER ESCAPES, YEARS 2001-2004, THE 2005 SUB FRAME OR SUSPENSION CONTROL ARM IS RUSTED THAT HOLDS UP THE ENGINE AND THE FRONT OF THE CAR! THERE IS A VIDEO ON YOUTUBE THAT SHOWS THE CORROSION ON T…
Read full complaint
RIGHT REAR WHEEL WELL ROTTED OUT CAUSING SHOCK TO BREAK THROUGH TRUNK AND CAUSE LOUD BANGING. FORD CHARGES $1,548.40 TO FIX. NOW AS IN OTHER ESCAPES, YEARS 2001-2004, THE 2005 SUB FRAME OR SUSPENSION CONTROL ARM IS RUSTED THAT HOLDS UP THE ENGINE AND THE FRONT OF THE CAR! THERE IS A VIDEO ON YOUTUBE THAT SHOWS THE CORROSION ON THE PARTICULAR SPOT. THIS IS EXTREMELY DANGEROUS TO DRIVE. HIT ONE POTHOLE OR BUMP AND ENTIRE ENGINE AND FRONT OF CAR CAN COLLAPSE! FACEBOOK HAS ENTIRE PAGE FOR 2005 FORD ESCAPE SUB FRAME RUSTING!!! SOMEONE IS GOING TO GET HURT!
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 154,235.
WENT TO REPLACE REAR SHOCKS. REAR PASSENGER WHEEL WELL HAS RUSTED AND I COULD MOVE SHOCK MOUNT TOWER WHEN TRUCK IS BOUNCED. ALSO HAVE BANGING AND BOUNCING GOING ON. RIDES ROUGH AND HAVE A RUST HOLE AND CAN SEE TIRE BELOW. BAD ENGINEERING DESIGN. THE FORD MOTOR COMPANY SHOULD FESS UP AND CORRECT THIS, BUT THEY WON'T THEY GOT …
Read full complaint
WENT TO REPLACE REAR SHOCKS. REAR PASSENGER WHEEL WELL HAS RUSTED AND I COULD MOVE SHOCK MOUNT TOWER WHEN TRUCK IS BOUNCED. ALSO HAVE BANGING AND BOUNCING GOING ON. RIDES ROUGH AND HAVE A RUST HOLE AND CAN SEE TIRE BELOW. BAD ENGINEERING DESIGN. THE FORD MOTOR COMPANY SHOULD FESS UP AND CORRECT THIS, BUT THEY WON'T THEY GOT THEIR MONEY!!!
ACCELERATOR STICKING IN NEUTRAL POSITION. MECHANICS CAN'T FIND WHATS WRONG AND ITS VERY LIKELY TO CAUSE AN ACCIDENT. I HAVE READ MANY ARTICLES THAT THIS IS COMMON IN OLDER MODELS
THE VEHICLE BEGAN TO STALL AND DIE WHILE DRIVING. BEFORE THE INCIDENT NO PREVIOUS WARNING SIGNS HAD BEEN PRESENT. THE DAY THE INCIDENT OCCURRED THE VEHICLE BEGAN TO ROCK BACK AND FORTH DURING A COMPLETE STOP. WHEN THE VEHICLE BEGAN DRIVING AGAIN EVERYTHING SEEMED FINE, UNTIL THE SEVERAL WARNING LIGHTS FLASHED ON AND THEN OFF (…
Read full complaint
THE VEHICLE BEGAN TO STALL AND DIE WHILE DRIVING. BEFORE THE INCIDENT NO PREVIOUS WARNING SIGNS HAD BEEN PRESENT. THE DAY THE INCIDENT OCCURRED THE VEHICLE BEGAN TO ROCK BACK AND FORTH DURING A COMPLETE STOP. WHEN THE VEHICLE BEGAN DRIVING AGAIN EVERYTHING SEEMED FINE, UNTIL THE SEVERAL WARNING LIGHTS FLASHED ON AND THEN OFF (ENGINE, TIRE PRESSURE..) AND THE VEHICLE SPEED BEGAN TO REDUCE. AFTER A MOMENT THE SPEED RETURNED TO NORMAL, AND THEN THE VEHICLE LOST POWER AND DIED ON A CITY STREET. I RESTARTED THE CAR AND RESUMED DRIVING, BUT WITHIN 5 MINUTES THE WARNING LIGHTS FLASHED ON/OFF AGAIN AND THE CAR LOST POWER AND DIED AGAIN. THIS HAPPENED 3 TIMES WITHIN AN 30 MINUTES AS I DROVE TO THE FORD SERVICE CENTER. ON THE 3RD TIME THE CAR WAS STOPPED AT A RED LIGHT AND BEGAN TO MOVE BACK AND FORTH, AND STARTED TO LOSE POWER. WHEN THE LIGHT TURNED GREEN AND I BEGAN TO TURN THE VEHICLE IT AGAIN LOST POWER. AFTER THE 1ST POWER LOSS I HEADED TO THE FORD SERVICE CENTER WHICH WAS LOCATED 5 MILES AWAY. THE VEHICLE DIED 3 TIMES BEFORE I REACHED THE SERVICE CENTER. THE SERVICE CENTER DETERMINED THAT IT WAS THE THROTTLE BODY ASSEMBLY.
I WAS DRIVING WITH MY DAUGHTER IN THE CAR CAME TO A STOP AND THE SUB FRAME BEING ROTTED COLLAPSED AND MY TIRE KINKED OUT.
Official recalls
415V606000 · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:floor Shift
Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
14V526000 · Hybrid Propulsion System
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
06V111000 · Seats:front Assembly:head Restraint
Apr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
04V602000 · Latches/locks/linkages:doors:latch
Dec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.