Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7425–50K
11950–75K
23375–100K
488100–150K
209150K+
1,211 reports with mileage · 183 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 459 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 434 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 153 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports20 fire reports20 injury reports
What owners actually said
1,394 reports
Mileage unknown · Dec 22, 2025
Unknown Or Other
I bought a 2005 Ford escape the VIN number on the dash and the title do match however the ECU and the door jamb VIN [XXX] which is for a 2006 Ford escape 4 cylinder 2.3. the vehicle I bought should be a 6 cylinder with a 3.0 l the mechanic says mismatched VIN the dealership refuses to listen. About the vehicle on [XXX] drove it…
Read full complaint
I bought a 2005 Ford escape the VIN number on the dash and the title do match however the ECU and the door jamb VIN [XXX] which is for a 2006 Ford escape 4 cylinder 2.3. the vehicle I bought should be a 6 cylinder with a 3.0 l the mechanic says mismatched VIN the dealership refuses to listen. About the vehicle on [XXX] drove it 30 miles then was able to call the mechanic for some maintenance as his car was for my daughter and that is when I got to bad news of a mismatched VIN. Not even your odometer reading is correct has less on it now than it did back in 2018 and it's documented as accurate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11706432
199,876 miles · Dec 17, 2025
Electrical System
Odometer Fraud. The contact purchased a 2005 Ford Escape on November 25, 2025. The contact discovered a mileage and VIN discrepancy after the purchase. The vehicle was a dealer sale. At the time of purchase, the mileage was 199,500. The vehicle was taken to the dealer for a routine inspection, and the dealer informed the contact…
Read full complaint
Odometer Fraud. The contact purchased a 2005 Ford Escape on November 25, 2025. The contact discovered a mileage and VIN discrepancy after the purchase. The vehicle was a dealer sale. At the time of purchase, the mileage was 199,500. The vehicle was taken to the dealer for a routine inspection, and the dealer informed the contact that during the diagnostic test there was another VIN was associated with the vehicle, and the mileage listed on the diagnostic test was 199,345. The other VIN linked in the diagnostic test for the vehicle was associated with a 2006 Ford Escape, and the mileage was 199,345. It was later discovered that the dealer who had sold the vehicle to the contact had purchased the vehicle in 2018, and the mileage was 199,876. The contact stated that the mileage on the reverse side of the Title was 199,876. The Police were notified; however, no assistance was provided.
NHTSA ODI #11705617
Mileage unknown · Dec 3, 2025
Service Brakes
I had just started up my 05 Ford hybrid Escape reversed out of a parking space, applied my brakes and a loud warning noise went off, the ABS light & the Brake light went on, then I tried to brake while backing out of the parking stall. I had no brakes, petal went all the way to the floor. I shifted into drive to pull forward. Th…
Read full complaint
I had just started up my 05 Ford hybrid Escape reversed out of a parking space, applied my brakes and a loud warning noise went off, the ABS light & the Brake light went on, then I tried to brake while backing out of the parking stall. I had no brakes, petal went all the way to the floor. I shifted into drive to pull forward. The car wouldn’t stop petal just went right to the floor, had very little resistance. I almost drove through the front glass doors of the P/T office across from the pharmacy in Cool, CA. The roads are mountainous windy and steep. I was definitely scared for my safety. I had to coast very slowly on the way home. I was on my way to work but instead I dropped it off at home and called ride share to take me to work! I had to use my emergency brake to make the turn up my dirt road. I still had little to no brakes to stop the car. I parked it and haven’t driven it since. Much to dangerous to drive this car. I could have easily been killed not having brakes. It Showed no codes, had no warning at all. I just bought the car about 6 months prior. The next day it was as if it never happened.
NHTSA ODI #11702633
Mileage unknown · Apr 28, 2025
Unknown Or Other
Front Subframe rusted out causing loss of steering and control. Car came to a complete skidded stop . The front wheel nearly came off. The subframe issue is the same problem that resulted in a recall of the 2001-2004 Ford Escape.
NHTSA ODI #11657235
105,000 miles · Apr 8, 2024
Power Train
The contact owns a 2005 Ford Escape. Upon starting of the vehicle, the contact placed the vehicle into drive(D); however, the vehicle failed to accelerate upon the depression of the accelerator pedal. The contact stated that prior to the failure, the check engine warning light illuminated and remained illuminated on the instrume…
Read full complaint
The contact owns a 2005 Ford Escape. Upon starting of the vehicle, the contact placed the vehicle into drive(D); however, the vehicle failed to accelerate upon the depression of the accelerator pedal. The contact stated that prior to the failure, the check engine warning light illuminated and remained illuminated on the instrument panel. The contact stated while driving at highway speeds, the vehicle independently downshifted and the vehicle failed to accelerate above 30 MPH. The vehicle was shaking, and the vehicle failed to accelerate upon the depression of the accelerator pedal. The vehicle was taken to an independent mechanic where and the contact was informed that the transmission torque converter was defective and needed to be replaced. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 105,000.
NHTSA ODI #11581658
Mileage unknown · Mar 13, 2024
Suspension
The right lower control arm separated from the subframe due to subframe rust. It caused loss of handling and rendered the car immobile. It was caused by a panic stop at a low speed. The car was towed to an independent garage where it is awaiting repair. Parts affected were the subframe, CV axle joint and the front fender (From t…
Read full complaint
The right lower control arm separated from the subframe due to subframe rust. It caused loss of handling and rendered the car immobile. It was caused by a panic stop at a low speed. The car was towed to an independent garage where it is awaiting repair. Parts affected were the subframe, CV axle joint and the front fender (From the wheel hitting it when it broke).
NHTSA ODI #11577074
Mileage unknown · Jan 17, 2024
SteeringStructureSuspensionCrash
Hello, The engine cradle subframe on my 2005 Ford Escape has completely rusted through on the right hand side where it attaches to the steering control arm. As I was driving the subframe broke which made it impossible to steer the car. This pulled my car off the road to the passenger side. Fortunately I was not injured. Hav…
Read full complaint
Hello, The engine cradle subframe on my 2005 Ford Escape has completely rusted through on the right hand side where it attaches to the steering control arm. As I was driving the subframe broke which made it impossible to steer the car. This pulled my car off the road to the passenger side. Fortunately I was not injured. Having now researched this issue, it is a common problem with 2005 Ford Escapes. This is very dangerous, and it should be addressed as it creates a life threatening situation.
NHTSA ODI #11565921
Mileage unknown · Jul 20, 2023
Unknown Or Other
The right back tire shock and spring mount broke right off
NHTSA ODI #11533399
Mileage unknown · Jun 1, 2023
Fuel/propulsion System
I had the hybrid battery replaced by Bill Brandt Ford in Brentwood California. A few days after having it replaced. The car broke down on a very dangerous highway. I had the car towed back to Bill Brandt Ford. They replaced the hybrid battery again. I received the car back on May 9. The car just broke down again today. Roughly B…
Read full complaint
I had the hybrid battery replaced by Bill Brandt Ford in Brentwood California. A few days after having it replaced. The car broke down on a very dangerous highway. I had the car towed back to Bill Brandt Ford. They replaced the hybrid battery again. I received the car back on May 9. The car just broke down again today. Roughly Bill Brandt Ford had my car for over 250 days. I found a recall one for S as in Sam 19 for my vehicle when I type in the Vin number it says that it doesn’t pertain to my car. But when I look at the recall issue, my car is having the exact same problems. Now I need to have the car towed back yet again to the dealership. Any help would be greatly appreciated. I have over $3000 invested in this car now with Bill Brandt Ford and they’ve had it longer than I’ve had it.
NHTSA ODI #11524932
Mileage unknown · May 14, 2023
Fuel/propulsion SystemPower Train
Stalled out while driving down hwy. At 70 mph. Cars swirved and I almost got hit from behind due to my vehicle just cutting out. No warning lights came on it just shut off battery light n engine light then came on after vehicle lost power and I had to get off road without causing an accident which almost occurred due to the spe…
Read full complaint
Stalled out while driving down hwy. At 70 mph. Cars swirved and I almost got hit from behind due to my vehicle just cutting out. No warning lights came on it just shut off battery light n engine light then came on after vehicle lost power and I had to get off road without causing an accident which almost occurred due to the speed and area I was driving at time vehicle cut out I still have not figured out why it just cut out. Very dangerous all around.
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration