RUST CAUSED THE SEPARATION OF THE LOWER CONTROL ARM FROM THE SUBFRAME OF THE VEHICLE. THE VEHICLE WAS PRIMARILY USED IN A SALT-BELT STATE. THE ISSUE BECAME EVIDENT AFTER A SMALL POTHOLE CAUSED THE REAR FRAME TO PUNCTURE THROUGH THE PASSENGER REAR WHEELHOUSE INTO THE CAB OF THE VEHICLE CAUSING A HIGH-PITCHED SQUEAL AND STEERING D…
Read full complaint
RUST CAUSED THE SEPARATION OF THE LOWER CONTROL ARM FROM THE SUBFRAME OF THE VEHICLE. THE VEHICLE WAS PRIMARILY USED IN A SALT-BELT STATE. THE ISSUE BECAME EVIDENT AFTER A SMALL POTHOLE CAUSED THE REAR FRAME TO PUNCTURE THROUGH THE PASSENGER REAR WHEELHOUSE INTO THE CAB OF THE VEHICLE CAUSING A HIGH-PITCHED SQUEAL AND STEERING DIFFICULTIES..
NHTSA ODI #11011765
88,000 miles · Apr 1, 2016
Seats
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT AN UNKNOWN SPEED, THE PASSENGER RIDING IN THE REAR SEAT NOTICED A HOLE IN THE BACK SIDE OF THE DRIVER SEAT. A PIECE OF METAL, APPROXIMATELY EIGHT INCHES LONG, WAS PROTRUDING FROM THE SEAT. THE VEHICLE WAS SCHEDULED TO BE EVALUATED AT THE DEALER. THE MANUFACTURER WAS NOTIF…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT AN UNKNOWN SPEED, THE PASSENGER RIDING IN THE REAR SEAT NOTICED A HOLE IN THE BACK SIDE OF THE DRIVER SEAT. A PIECE OF METAL, APPROXIMATELY EIGHT INCHES LONG, WAS PROTRUDING FROM THE SEAT. THE VEHICLE WAS SCHEDULED TO BE EVALUATED AT THE DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.
NHTSA ODI #10852879
65,000 miles · Jan 1, 2016
Seats
THE LAST FEW TIMES I TURNED ON THE HEATED SEAT WHILE DRIVING IN TRAFFIC IT FELT LIKE IT WAS GETTING EXTREMELY HOT TO THE POINT WHERE I HAD TO LIFT MY UPPER LEG UP OFF THE SEAT. I'M SURE THAT IF I HADN'T SHUT IT OFF IT WOULD HAVE BURNT ME. THERE IS NO WARNING SYSTEM TO INDICATE THE HEATED SEAT IS MALFUNCTIONING OR GETTING TOO HOT…
Read full complaint
THE LAST FEW TIMES I TURNED ON THE HEATED SEAT WHILE DRIVING IN TRAFFIC IT FELT LIKE IT WAS GETTING EXTREMELY HOT TO THE POINT WHERE I HAD TO LIFT MY UPPER LEG UP OFF THE SEAT. I'M SURE THAT IF I HADN'T SHUT IT OFF IT WOULD HAVE BURNT ME. THERE IS NO WARNING SYSTEM TO INDICATE THE HEATED SEAT IS MALFUNCTIONING OR GETTING TOO HOT. THIS NEEDS TO BE ADDRESSED.
NHTSA ODI #10817343
130,000 miles · Mar 6, 2015
SeatsFire
TL*THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT 15 MPH, THE PASSENGER'S SIDE SEAT BEGAN BURNING AND AN UNKNOWN WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOT…
Read full complaint
TL*THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT 15 MPH, THE PASSENGER'S SIDE SEAT BEGAN BURNING AND AN UNKNOWN WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF FAILURE. THE FAILURE MILEAGE WAS 130,000.
NHTSA ODI #10692531
80,000 miles · Nov 15, 2014
Seats
PASSENGER SEAT GETS REAL HOT.,STARTS TO SMOKE HAVE TO SHUT IT OFF. *TR
NHTSA ODI #10655188
50,000 miles · Feb 10, 2012
SeatsFire
WHILE SITTING IDLE AT A STOP LIGHT THE SEAT HEATER IN THE DRIVER'S SEAT IGNITED THE UPPER PORTION OF THE SEAT, CAUSING THE SEAT TO BURN AND FILLING THE CABIN WITH SMOKE. THE SEAT THEN CAUSED MY HUSBAND'S JACKET TO START ON FIRE. THE FIRE IN THE VEHICLE HAD TO BE EXTINGUISHED BY PACKING IT WITH SNOW. *TR
NHTSA ODI #10447429
8,500 miles · Nov 1, 2005
Seats
DT: THE CONTACT STATES THE HEAD RESTRAINT POSTS ON THE FRONT SEATS ARE DANGEROUS. THERE IS NO PADDING TO COVER THE METAL POSTS IN THE BACK OF THE SEAT. IN THE EVENT OF AN ACCIDENT THE REAR SEAT OCCUPANTS WOULD NOT HAVE ANY PROTECTION FROM THE METAL POSTS. THE SERVICE DEALER SAID THIS IS THE DESIGN OF THE CLOTH SEATS IN THIS…
Read full complaint
DT: THE CONTACT STATES THE HEAD RESTRAINT POSTS ON THE FRONT SEATS ARE DANGEROUS. THERE IS NO PADDING TO COVER THE METAL POSTS IN THE BACK OF THE SEAT. IN THE EVENT OF AN ACCIDENT THE REAR SEAT OCCUPANTS WOULD NOT HAVE ANY PROTECTION FROM THE METAL POSTS. THE SERVICE DEALER SAID THIS IS THE DESIGN OF THE CLOTH SEATS IN THIS TYPE OF VEHICLE. *AK UPDATED 12/07/05. *JB
NHTSA ODI #10141387
Mileage unknown · Aug 24, 2005
Seats
D: THE DRIVERS SEAT MATERIAL IS SO HARD IT PUTS THE CONSUMER'S LEG TO SLEEP. THE CONSUEMR FEELS THT THIS IS A SAFETY ISSUE BECAUSE SHE CANNOT DRIVE THIS VEHICLE VERY FAR WITHOUT HAVING TO STOP AND WALK AROUND THE VEHICLE TO WAKE LEGS BACK UP. THE PASSENGERS SEAT APPEARS THIS WAY ALSO. STARTED NOTICING THIS ABOUT 3 WEEKS AFTER…
Read full complaint
D: THE DRIVERS SEAT MATERIAL IS SO HARD IT PUTS THE CONSUMER'S LEG TO SLEEP. THE CONSUEMR FEELS THT THIS IS A SAFETY ISSUE BECAUSE SHE CANNOT DRIVE THIS VEHICLE VERY FAR WITHOUT HAVING TO STOP AND WALK AROUND THE VEHICLE TO WAKE LEGS BACK UP. THE PASSENGERS SEAT APPEARS THIS WAY ALSO. STARTED NOTICING THIS ABOUT 3 WEEKS AFTER BUYING THE VEHICLE. THIS HAPPENS WHEN I'M IN IT FOR ABOUT 45 MIN TO AN HOUR. *NM *NM
NHTSA ODI #10128316
300 miles · Apr 17, 2005
Seats
THE FRONT DRIVER SIDE SEAT IN MY 2005 FORD ESCAPE XLT IS LEANING AND POINTING TO LEFT. AFTER SPEAKING WITH THE DEALER, THEY SAID THAT FORD PURPOSELY MADE THE FOAM ON THE DRIVERS SIDE SEAT LESS DENSE THAN ON THE RIGHT SIDE FOR EASIER ACCESS AND EXIT OF THE VEHICLE. STILL THE SLIGHT TWISTING AND DEFECTION OF THE SEAT TO THE LEFT…
Read full complaint
THE FRONT DRIVER SIDE SEAT IN MY 2005 FORD ESCAPE XLT IS LEANING AND POINTING TO LEFT. AFTER SPEAKING WITH THE DEALER, THEY SAID THAT FORD PURPOSELY MADE THE FOAM ON THE DRIVERS SIDE SEAT LESS DENSE THAN ON THE RIGHT SIDE FOR EASIER ACCESS AND EXIT OF THE VEHICLE. STILL THE SLIGHT TWISTING AND DEFECTION OF THE SEAT TO THE LEFT LEAVES ME FEELING LIKE IM IN A POOR DRIVING POSITION. THE SERVICE MANAGER ALSO STATED THAT HED BEEN TOLD BY FORD MOTOR COMPANY THAT THEY ARE AWARE OF THE ISSUE AND THAT THERE IS NOTHING THEY CAN DO AT THIS TIME, MAYBE A RECALL IN THE FUTURE BUT NOTHING RIGHT NOW. I CANT BE THE ONLY PERSON CONCERNED BY THE ODD SEATING POSITION AND THE FEELING OF DISTRACTION WHILE IM DRIVING, WHICH THEN BECOMES A SAFETY ISSUE IN MY EYES. JUST THOUGHT THIS WAS WORTH A MENTION. *AK
NHTSA ODI #10118020
Mileage unknown · Apr 26, 2004
Seats
FRONT DRIVERS SEAT LEANS AND IS POINTING TO LEFT. DEALER STATED THAT FORD PURPOSELY MADE THE FOAM ON THE DRIVERS SIDE SEAT LESS DENSE THAN ON THE RIGHT SIDE FOR EASIER ACCESS AND EXIT OF THE VEHICLE. THIS STILL DOESN'T EXPLAIN WHY THE SEAT ALSO FEELS SLIGHTLY TWISTED OR POINTING THE LEFT. I WAS ALSO TOLD BY THE DEALER WHO CALLED…
Read full complaint
FRONT DRIVERS SEAT LEANS AND IS POINTING TO LEFT. DEALER STATED THAT FORD PURPOSELY MADE THE FOAM ON THE DRIVERS SIDE SEAT LESS DENSE THAN ON THE RIGHT SIDE FOR EASIER ACCESS AND EXIT OF THE VEHICLE. THIS STILL DOESN'T EXPLAIN WHY THE SEAT ALSO FEELS SLIGHTLY TWISTED OR POINTING THE LEFT. I WAS ALSO TOLD BY THE DEALER WHO CALLED FORD MOTOR COMPANY AND THAT THEY ARE AWARE OF THE ISSUE AND THAT THERE IS NOTHING THEY CAN DO AT THIS TIME. MY CONCERN THAT I FEEL DISTRACTED WHILE DRIVING WHICH MAY LEAD TO A SAFETY ISSUE FOR MYSELF AND OTHERS. PLEASE NOTE THAT THIS IS FOR A 2005 FORD XLT. THIS WEB SITE DOES NOT YET ALLOW YOU TO SELECT 2005 AS AN OPTION IN THE "YEAR" PULL DOWN MENU.*AK
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration