Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7425–50K
11950–75K
23375–100K
488100–150K
209150K+
1,211 reports with mileage · 183 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 459 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 434 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 153 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports20 fire reports20 injury reports
What owners actually said
1,394 reports
158,000 miles · Feb 20, 2018
Structure
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING 50 MPH, THE CONTACT NOTICED A VERY LOUD NOISE AS IF GLASS WERE BREAKING. THE CONTACT PULLED THE VEHICLE OFF THE ROAD AND TURNED OFF THE ENGINE. THE CONTACT WALKED TO THE REAR OF THE VEHICLE AND NOTICED THAT THE TOWER WAS DISCONNECTED FROM THE WELL OF THE WHEEL. THE CONTACT D…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING 50 MPH, THE CONTACT NOTICED A VERY LOUD NOISE AS IF GLASS WERE BREAKING. THE CONTACT PULLED THE VEHICLE OFF THE ROAD AND TURNED OFF THE ENGINE. THE CONTACT WALKED TO THE REAR OF THE VEHICLE AND NOTICED THAT THE TOWER WAS DISCONNECTED FROM THE WELL OF THE WHEEL. THE CONTACT DROVE THE VEHICLE HOME AND THEN TO AN INDEPENDENT AUTO MECHANIC. THE TECHNICIAN WOULD NOT TOUCH THE VEHICLE DUE TO THE DANGER OF THE FAILURE. IT WAS UNKNOWN IF A DEALER WAS CONTACTED. THE MANUFACTURER INFORMED THE CONTACT THAT SHE SHOULD NOT BELIEVE EVERYTHING POSTED ON THE INTERNET AND STATED THAT THE VEHICLE WAS OLD. THE FAILURE MILEAGE WAS 158,000.
NHTSA ODI #11073962
129,000 miles · Feb 20, 2018
Structure
HEAR A LOUD BANG WHILE DRIVING. I FOUND EXTENSIVE CORROSION ON THE REAR PASSENGER WHEEL WELL. I CHECKED THE OTHER WHEEL WELLS AND THE OTHER THREE ARE FINE, NO ISSUES. THIS CAR IS A LITTLE OLDER, BUT THERE SHOULD NOT BE AN ISSUE LIKE THIS. THIS IS A GARAGE KEPT VEHICLE AND IS NOT OUT IN THE ELEMENTS ALL THE TIME.
NHTSA ODI #11073869
5 miles · Feb 20, 2018
Electrical SystemElectronic Stability Control (esc)Unknown Or Other
WHILE DRIVING THE CAR ON THE FREEWAY THE CAR JOLTED. AFTER 3-5 MORE MILES THE CAR KEPPED JOLTING AS IF IT WANTED TO DIE THEN LOST ALL POWER, EVEN THE EMERGENCY LIGHTS WOULDNT COME ON. ONCE I TURNED THE CAR OFF IT TURNED BACK ON FINE THEN CONTINUED THE PROCESS. THE CAR FOR NO APPARENT REASON DIED ON THE FREEWAY AND I COULD HAVE B…
Read full complaint
WHILE DRIVING THE CAR ON THE FREEWAY THE CAR JOLTED. AFTER 3-5 MORE MILES THE CAR KEPPED JOLTING AS IF IT WANTED TO DIE THEN LOST ALL POWER, EVEN THE EMERGENCY LIGHTS WOULDNT COME ON. ONCE I TURNED THE CAR OFF IT TURNED BACK ON FINE THEN CONTINUED THE PROCESS. THE CAR FOR NO APPARENT REASON DIED ON THE FREEWAY AND I COULD HAVE BEEN IN AN ACCIDENT TO WHERE MY LIFE WAS ALMOST LOST. I MADE IT TO MY MECHANIC SHOP THEY RAN THE CARE FOR CODES AND NO CODES CAME UP AT ALL. MY MECHANIC HAS DONE RESEARCH AND FOUND THAT SOME 2005-2008 FORED ESCAPES HAVE RECALLS. HE FEELS AS MY CAR IS ONE BECAUSE MY CAR HAS THE EXACT SAME SYMPTOMS AS THE RECALL. IN THIS ARTICLE I HAVE HAD ALL OF THESE ISSUES.THE 2005 ESCAPE HAS PROBLEMS WHERE THE ENGINE SHUTS DOWN WHILE DRIVING. FORD FINALLY ISSUED A SEPTEMBER 2014 RECALL. TIME WILL TELL IF THE RECALL FIX REALLY SOLVES THE PROBLEM. HOWEVER THE 2005 ESCAPE ALSO HAS A DEFECT WHERE THE PCM (POWER CONTROL MODULE) FRIES AT AROUND 100K MILES. FORD EXTENDED THE PCM WARRANTY TO 80,000 MILES, BUT ONLY AFTER MOST OWNERS WERE PAST THE MILEAGE LIMIT. NOW OWNERS ARE ON THE HOOK FOR THE AVERAGE REPAIR COST OF OVER $2,000 (!!)
NHTSA ODI #11073748
234,000 miles · Feb 17, 2018
StructureSuspension
THE PASSENGER SIDE REAR WHEEL WELL AND SHOCK TOWER HAS EXCESSIVELY RUSTED OUT CAUSING THE CAR TO BE UNSAFE.
NHTSA ODI #11073345
200 miles · Feb 16, 2018
EngineUnknown Or Other
I HAVE THE SAME OIL LEAK PROBLEMS OTHER CUSTOMERS IS EXPERIENCING WHAT THE 2005 FORD ESCAPE OIL LEAK AROUND IN A COOLING SENSOR CRANKSHAFT VALVE COVER GASKETS OR SEAL SEAT AS WELL AS I'M EXPERIENCING THE PROBLEM WITH THE STALLING GAS PEDAL STICKING AND WON'T MOVE IT JUST STIFF AND I CAN'T PRESS IT AT TIMES I AM SPIRITS THE SAME …
Read full complaint
I HAVE THE SAME OIL LEAK PROBLEMS OTHER CUSTOMERS IS EXPERIENCING WHAT THE 2005 FORD ESCAPE OIL LEAK AROUND IN A COOLING SENSOR CRANKSHAFT VALVE COVER GASKETS OR SEAL SEAT AS WELL AS I'M EXPERIENCING THE PROBLEM WITH THE STALLING GAS PEDAL STICKING AND WON'T MOVE IT JUST STIFF AND I CAN'T PRESS IT AT TIMES I AM SPIRITS THE SAME BECAUSE THE OTHER CUSTOMERS HAVE HAD ON HIS VEHICLE FOR THESE ISSUES THAT I'M HAVING AND I WAS WONDERING WHY MY VIN NUMBER IS NOT PULLING UP THESE RECALLS FOR MY VIN NUMBER AS WELL AS THE OIL LEAK HEAVEN TO DO THE OVERHEATING OVER THE PRESSURE PUSHING THROUGH THE CRANKSHAFT AND MAKING A OIL PRESSURE WEEK AS WELL AS THE OTHER PROBLEMS THAT I HAVE WITH THE RECALL SO GO TO CUSTOMERS HAS EXPERIENCE WITH THE STICK AND GAS PEDAL WON'T LET YOU GO NOWHERE IS STUCK
NHTSA ODI #11073282
100,000 miles · Feb 15, 2018
StructureSuspension
PURCHASED VEHICLE IN APRIL 2017 2 MONTHS LATER HEARD A BANGING NOISE FROM REAR PASSENGER SIDE UPON FURTHER INVESTIGATION DISCOVERED THE WHEEL WELL RUSTED OUT AND THE SHOCK HAD CAME THROUGH. I CONTINUED DRIVING IT BECAUSE I COULDN'T AFFORD TO FIX IT AND IT WAS MY ONLY CAR NOW THERE IS NO WHEEL WELL LEFT AND HAD TO REMOVE THE SHOC…
Read full complaint
PURCHASED VEHICLE IN APRIL 2017 2 MONTHS LATER HEARD A BANGING NOISE FROM REAR PASSENGER SIDE UPON FURTHER INVESTIGATION DISCOVERED THE WHEEL WELL RUSTED OUT AND THE SHOCK HAD CAME THROUGH. I CONTINUED DRIVING IT BECAUSE I COULDN'T AFFORD TO FIX IT AND IT WAS MY ONLY CAR NOW THERE IS NO WHEEL WELL LEFT AND HAD TO REMOVE THE SHOCK.
NHTSA ODI #11073001
Mileage unknown · Jan 31, 2018
Electrical SystemElectronic Stability Control (esc)Exterior Lighting
CAR ALARM ALWAYS GOING OFF CAUSES INTERIOR LIGHTS TO RUN BATTERY DOWN. ALARM WILL NOT RESET LOCK DOORS. SENSOR LIGHT COMES ON WITH DOOR AJAR AND ALARM REFUSES TO SET. HAS BEEN GOING ON FOR A YEAR OR MORE. COMPLAINTS ON INTERNET FROM OTHER PEOPLE WITH THE SAME PROBLEM BUT THERE IS NO RECALL. OTHERS ARE SAYING IT IS THE LATCH …
Read full complaint
CAR ALARM ALWAYS GOING OFF CAUSES INTERIOR LIGHTS TO RUN BATTERY DOWN. ALARM WILL NOT RESET LOCK DOORS. SENSOR LIGHT COMES ON WITH DOOR AJAR AND ALARM REFUSES TO SET. HAS BEEN GOING ON FOR A YEAR OR MORE. COMPLAINTS ON INTERNET FROM OTHER PEOPLE WITH THE SAME PROBLEM BUT THERE IS NO RECALL. OTHERS ARE SAYING IT IS THE LATCH THAT NEEDS TO BE REPLACE BUT FORD COMPANY CAN'T TELL US THIS. IT DOESN'T MATTER IF THE VEHICLE IS MOVING OR NOT FOR THE DOOR TO BE AJAR.
NHTSA ODI #11066014
112,000 miles · Jan 28, 2018
Electrical SystemService BrakesSteering
TERRIFYING! POTENTIALLY FATAL . POWER JUST CUT OUT ON HIGHWAY WHILE GOING APPROXIMATELY 55 MPH. NO STEERING, NO BRAKES. NO POWER. ALL WARRING LIGHTS ABLAZE, BUT NO WARNING BEFOREHAND! GRATEFULLY, I WAS IN THE RIGHT LANE AND MANAGED TO GET THE CAR INTO THE MEDIAN. AFTER SEVERAL MINUTES, CAR RESTARTED. LUCKILY I WAS ONLY 1/4 MILE …
Read full complaint
TERRIFYING! POTENTIALLY FATAL . POWER JUST CUT OUT ON HIGHWAY WHILE GOING APPROXIMATELY 55 MPH. NO STEERING, NO BRAKES. NO POWER. ALL WARRING LIGHTS ABLAZE, BUT NO WARNING BEFOREHAND! GRATEFULLY, I WAS IN THE RIGHT LANE AND MANAGED TO GET THE CAR INTO THE MEDIAN. AFTER SEVERAL MINUTES, CAR RESTARTED. LUCKILY I WAS ONLY 1/4 MILE FROM THE EXIT. I READ ABOUT THIS WELL KNOWN ELECTRICAL PROBLEM. IT IS THE PCM. APPARENTLY FORD USED FAULTY SPARK PLUGS. THE FIX IS TOO COSTLY. I WILL HAVE TO PURCHASE A NEW VEHICLE. FORD RECALLED THE 2005 ESCAPE HYBRID BUT NOT THIS MODEL? CRIMINAL
NHTSA ODI #11065559
105,000 miles · Jan 27, 2018
Service BrakesStructure
BACK WHEEL RIGHT WHEELWELL AROUND SHOCK RUSTED OUT, SON DROVE HOME FROM SCHOOL SAID BACK WHEEL MAKING NOISE, UPON FURTHER INSPECTION TOOK OFF BACK PANEL RIGHT SIDE, FOUND WHEELWELL RUSTED OUTBY SHOCK AND CAN SEE DAYLIGHT WHEEL WAS MAKING NOISE WHEN HE DROVE HOME, HAD BRAKE MAN LOOK AT FOUND DEBRIS FROM PANEL IN WHEEL WHERE BRAKE…
Read full complaint
BACK WHEEL RIGHT WHEELWELL AROUND SHOCK RUSTED OUT, SON DROVE HOME FROM SCHOOL SAID BACK WHEEL MAKING NOISE, UPON FURTHER INSPECTION TOOK OFF BACK PANEL RIGHT SIDE, FOUND WHEELWELL RUSTED OUTBY SHOCK AND CAN SEE DAYLIGHT WHEEL WAS MAKING NOISE WHEN HE DROVE HOME, HAD BRAKE MAN LOOK AT FOUND DEBRIS FROM PANEL IN WHEEL WHERE BRAKES ARE. FIXED AND CLEANED, CHECKED BRAKES, PUT BACK TOGETHER. WHEELWELL RUSTED OUT . WANT FORD TO DO SOMETHING. ALSO HAD CAR 1 YR BOUGHT FROM COLUMBIANA FORD WENT BACK TOLD DEALER THEY SHOULD HAVE TOLD US ABOUT THIS ISSUE MY SON COULD HAVE BEEN HURT OR ME.
NHTSA ODI #11065456
135,000 miles · Jan 25, 2018
Suspension
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING 15 MPH OVER A BUMP IN THE ROAD, THE CONTACT HEARD AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO LASCO FORD (2525 OWEN RD, FENTON, MI) WHERE IT WAS DIAGNOSED THAT THE SHOCK ABSORBER WENT THROUGH THE WHEEL WELL AND WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND REF…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING 15 MPH OVER A BUMP IN THE ROAD, THE CONTACT HEARD AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO LASCO FORD (2525 OWEN RD, FENTON, MI) WHERE IT WAS DIAGNOSED THAT THE SHOCK ABSORBER WENT THROUGH THE WHEEL WELL AND WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration