Electrical System. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

22 crash reports27 fire reports23 injury reports

What owners actually said

257 reports

Mileage unknown · Oct 25, 2017

Air BagsSeat Belts

AIRBAG (CODE 13 AND 51) LIGHTS FLASHING

NHTSA ODI #11039844

93,000 miles · Aug 12, 2013

Electrical SystemFire

Read full complaint

VAN HAD BEEN DRIVEN FOR APPROXIMATELY TWO HOURS OR SO, AROUND THE LOCAL CITY COMMUNITIES. VAN HAD BEEN PARKED FOR APPROXIMATELY FIVE MINUTES, WHEN NEIGHBORS NOTIFIED ME OF FIRE. INTENSE FIRE WAS COMING FROM DRIVER'S SIDE/WINDSHIELD/IGNITION/FRONT SEAT AREA, EVENTUALLY CONSUMING ENTIRE INTERIOR OF VAN. NORFOLK FIRE DEPARTMENT RESPONDED WITHIN FIVE MINUTES, OR SO, STATION ONLY ABOUT 150 YARDS FROM MY RESIDENCE. FIRE WAS EXTINGUISHED WITHIN FIVE MINUTES OR SO, BUT THE VAN WAS COMPLETELY CONSUMED BY FIRE AND TOTALLY DESTROYED BY THEN. VAN WAS JUNKED/SALVAGED. PAID ONLY $100.00 FOR SALVAGE/JUNK/TOWING, ETC. PRIOR TO THIS INCIDENT, I HAD NO PROBLEMS WITH MY VAN. VAN ONLY HAD 93000 MILES. HAD PURCHASED NEW FROM FREEDOMS FORD IN NORFOLK, VA. INFORMED BY ASSOCIATE THAT I SHOULD REPORT THIS "FIRE HAZARD/PROBLEM," BECAUSE OTHER 1994 FORD AEROSTAR VANS HAVE EXPERIENCED SIMILAR "FIRE PROBLEMS/INCIDENTS/REPORTS," AND THE LIKE. PLEASE INFORM ME OF WHAT ACTIONS I NEED TO TAKE TO RECOUP SOME MONETARY VALUE FOR THIS "FIRE INCIDENT," ETC. MY VEHICLE PAPERWORK WAS BURNED/DESTROYED IN THE FIRE. HOWEVER, THE NORFOLK FIRE DEPARTMENT DID MAKE AN "OFFICIAL FIRE REPORT/RECORD" OF THE INCIDENT, ETC. ALSO, MINOR DAMAGE WAS DONE TO THE ALUMINUM SIDING OF MY HOUSE FROM THE VEHICLE FIRE. *TR

NHTSA ODI #10534938

Mileage unknown · Jun 13, 2012

Electrical System

HAD THE CLOCK RING REPAIRED (YEAR 2000)DUE TO THE AIRBAG LIGHT STAYED ON. NOW THE AIRBAG LIGHT STAYS ON ,THERE IS NO HORN AND THE CRUISE CONTROL DOESNT WORK. THERE HAS TO BE A RECALL FOR THIS SAFETY PROBLEM. *TR

NHTSA ODI #10461633

Mileage unknown · Jul 8, 2009

Electrical SystemFuel System, Gasoline

Read full complaint

WE WERE BEGINNING TO EXPERIENCE LOSS OF POWER. THE FUEL PUMP AND FILTER WAS CHANGED. WE ARE STILL GETTING INTERMITTENT LOSS OF POWER, BUT WHAT MY CONCERN IS THAT I SAW A RECALL ON NHTSA: 99V028000. I WAS MADE AWARE OF THIS RECALL WHEN I VIEWED AN EPISODE OF COPS WHERE AN AEROSTAR'S ELECTRICAL SYSTEM CAUSED A FIRE IN THE ENGINE COMPARTMENT. I CALLED FORD IN TEMECULA CALIF AND NOW THEY HAVE NO RECORD OF ANY RECALLS FOR THIS YEAR OF AEROSTAR 1994 I DO HAVE KIDS AND I WOULD LIKE TO KNOW WHAT SAFETY MATTERS REMAIN ON THIS VAN. *TR

NHTSA ODI #10276149

120,000 miles · Jul 5, 2008

Air BagsElectrical SystemVehicle Speed Control

ALL ELECTRONICS ON STEERING COLUMN DON'T WORK. AIR BAG SYSTEM FLASHES 3-2. NO AIRBAG (PRESUMABLY), CRUISE CONTROL OR HORN FUNCTION. *TR

NHTSA ODI #10233257

120,000 miles · Feb 12, 2008

Electrical SystemExterior LightingPower Train

FRONT COIL SPRINGS SNAPPED, HAD TO REPLACED WITH READING SPRING WORKS, THEY HAD TO SEND THE SPECKS TO CHICAGO. MY FORD AERO STAR 4 WHEEL DRIVE & 4.0 V6 IS NOT AVAILABLE FROM AFTER MARKET. THE ONLY OPTION IS TO BUY NEW OR USED FORD SPRINGS WHICH ARE MADE IN CHINA. THE LOCAL FORD DEALER ADMITS REPLACING COIL & LEAF SPRINGS ON SEVE…

Read full complaint

NHTSA ODI #10217895

110,000 miles · Feb 6, 2008

Electrical SystemFire

CAR WAS PARKED IN DRIVEWAY, UNTOUCHED, FOR AT LEAST 24 HOURS. FIRE ERUPTED ABOUT 7:00 AM. FLAMES WERE COMING THROUGH THE DRIVERS SIDE WINDSHIELD. SEEMED TO BE ELECTRICAL IN NATURE. CAR IS A TOTAL LOSS. CAR IS COMPLETELY ORIGINAL (NO ELECTRIC ALTERATIONS). CAR HAD BEEN TO THE DEALER WITHIN THE LAST 2 YEARS SO ANY RECALL WORK SHOU…

Read full complaint

NHTSA ODI #10217101

200,000 miles · Sep 17, 2006

Steering

THE SEAMS IN THE STEERING WHEEL OOZE BLACK GOO AND FORM DIME SIZED POOLS AROUND THE INSIDE CENTER WHERE THE AIRBAG IS PACKED ...THE DEALER SAID JUST BUY A COVER BUT IT CONTINUES TO LEAK AS A NEW STEERING WHEEL WOULD BE VERY COSTLY DUE TO AIRBAG, I WORRY IF AIRBAG WILL DEPLOY CORRECTLY IN A CRASH. *JB

NHTSA ODI #10168462

100,000 miles · Feb 1, 2006

Electrical SystemEngine And Engine CoolingFire

Read full complaint

DT: THE CONTACT STATED 1994, FORD VAN CAUGHT ON FIRE ON THE FREEWAY ON 8-8-05. SHE WAS NOT HAVING PROBLEMS PRIOR TO THE FIRE. THE FIRE SEEMED TO BE ELECTRICAL AND ORIGINATED UNDER THE HOOD. *AK *JB UPDATED 2/7/2006 - THE CONSUMER RECEIVED RECALL 97V204000 ON NOV 13, 1997 FOR THE TRANSFER CASE/DRIVESHAFT BUT THE DEALER REFUSED TO MAKE THE REPAIRS. THIS FAILURE OF THIS COMPONENT COULD RESULT IN A FIRE. THE CONSUMER RECEIVED INFORMATION FROM NHTSA ON TWO RECALLS FOR THE VEHICLE. ONE WAS 99V028000 FOR THE ELECTRICAL WIRING UNDER THE HOOD AND THE OTHER ONE WAS 99V029000 FOR THE IGNITION SWITCH. *NM

NHTSA ODI #10132510

Mileage unknown · Nov 23, 2005

Tires

1994 FORD AEROSTAR TIRE BLEW (FIRESTONE DAYTON QUADRA SE). *TS THE TREAD SEPARATED FROM THE TIRE. *NM

NHTSA ODI #10145392

Official recalls

99V028000 · Electrical System:wiring:front Underhood

Feb 9, 1999

VEHICLE DESCRIPTION: MINI VANS. HEAT GENERATION IN THE WIRING HARNESS TO THE FUEL PUMP/SENDER ASSEMBLY CAN CAUSE AN ELECTRICAL SHORT. THE VEHICLE COULD EXPERIENCE A LOSS OF POWER AND BECOME IMMOBILIZED AND THE FUEL GAUGE MAY BE ERRATIC.

Consequence & remedy

Consequence: HEAT DAMAGE, INCLUDING MELTING OR CHARRING OF THE FUEL PUMP AND SENDER ASSEMBLY WIRE HARNESS AND ASSOCIATED WIRING HARNESSES CAN ALSO RESULT. THE SHORT CIRCUIT COULD ALSO HAVE THE POTENTIAL FOR A VEHICLE FIRE.

Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS IN THE FUEL PUMP GROUND CIRCUIT THAT WILL BE INSTALLED AT THE FUEL PUMP INERTIA SHUT-OFF SWITCH.

99V029000 · Electrical System:ignition:switch

Feb 9, 1999

VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.

Consequence & remedy

Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.

Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.

97V204000 · Power Train:transfer Case (4-WHEEL Drive)

Nov 13, 1997

VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.

Consequence & remedy

Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.

Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE02076 · Luggage Compartment Door Drops Abruptly

Opened Oct 10, 2002 · Closed Mar 10, 2003

Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut

ODI HAS IDENTIFIED 30 INCIDENTS RESULTING IN MINOR TO MODERATE PERSONAL INJURIES THAT HAVE BEEN CAUSED BY ABRUPT DOOR DROPS OVER THE APPROXIMATELY EIGHT - TWELVE YEAR PERIOD OF PRODUCT USAGE AND EXPOSURE (1991-1995 TO 2003).MOST OF THE INJURY INCIDENTS APPEAR TO HAVE BEEN CAUSED BY A FRACTURE OF THE GAS FILLED LIFT ASSIST CYLINDER MOUNTING STUD.STUD FRACTURES HAVE OCCURRED RANDOMLY OVER TIME AND DO NOT EXHIBIT ANY APPARENT TREND RELATING TO DATE OF VEHICLE PRODUCTION OR TIME-IN-SERVICE (EXPOSURE).THE ODI CLOSING REPORT SUMMARIZES THE DETAILS OF THIS INVESTIGATION.