NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
53 reports65,000 miles · Aug 27, 2012
Electrical SystemVisibility
THE VENTILATION SYSTEM FAILED AS IS COMMON WITH THESE VEHICLES. DUE TO WEAL PARTS, THE, "DOORS" THAT CONTROL AIR FLOW THROUGH THE VENTILATION DUCTS BROKE. I HAVE SLOWLY REPLACE EACH OF THE FOUR DOORS AS THEY FAILED. AS THEY WENT OUT IT AFFECTED EVERY ASPECT OF VENTILATION, INCLUDING THE DEFROST. AFTER DOING SOME RESEARCH IT IS E…
Read full complaint
THE VENTILATION SYSTEM FAILED AS IS COMMON WITH THESE VEHICLES. DUE TO WEAL PARTS, THE, "DOORS" THAT CONTROL AIR FLOW THROUGH THE VENTILATION DUCTS BROKE. I HAVE SLOWLY REPLACE EACH OF THE FOUR DOORS AS THEY FAILED. AS THEY WENT OUT IT AFFECTED EVERY ASPECT OF VENTILATION, INCLUDING THE DEFROST. AFTER DOING SOME RESEARCH IT IS EVIDENT DODGE WAS FULLY AWARE OF THIS ISSUE BUT MADE NO IMPROVEMENTS TO THE SYSTEM, CONTINUING TO SELL THESE VEHICLES TO AN UNSUSPECTING PUBLIC FOR SEVERAL YEARS. *TR
NHTSA ODI #10472710
168,000 miles · Jul 3, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2003 DODGE RAM. THE CONTACT STATED THAT WHILE DRIVING 55 MPH AND ATTEMPTING TO BRAKE, THE VEHICLE HESITATED TO COME TO A FULL STOP. THE CONTACT RELEASED THE BRAKE PEDAL AND THE VEHICLE ACCELERATED INDEPENDENTLY. THE ELECTRONIC THROTTLE CONTROL WARNING LIGHT WAS ALSO ILLUMINATED. THE VEHICLE WAS INSPECTED B…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE RAM. THE CONTACT STATED THAT WHILE DRIVING 55 MPH AND ATTEMPTING TO BRAKE, THE VEHICLE HESITATED TO COME TO A FULL STOP. THE CONTACT RELEASED THE BRAKE PEDAL AND THE VEHICLE ACCELERATED INDEPENDENTLY. THE ELECTRONIC THROTTLE CONTROL WARNING LIGHT WAS ALSO ILLUMINATED. THE VEHICLE WAS INSPECTED BY A MECHANIC WHO ADVISED THAT THE FAILURE WAS RELATED TO THE ELECTRONIC CONTROL THROTTLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE HOWEVER NO FURTHER ASSISTANCE WAS PROVIDED. THE VIN WAS UNAVAILABLE. THE CURRENT AND THE FAILURE MILEAGE WAS 168,000.
NHTSA ODI #10464043
116,960 miles · May 13, 2012
StructureInjury
PASSENGER SIDE GRAB HANDLE FAILED WHILE ENTERING VEHICLE. PASSENGER LOST BALANCE AND FELL TO THE GROUND. *TR
NHTSA ODI #10458237
70,000 miles · Feb 15, 2012
StructureInjury
TL* THE CONTACT OWNS A 2003 DODGE RAM 1500. THE CONTACT STATED THAT THE DASHBOARD WAS FRACTURED, CAUSING SMALL FRAGMENTS TO FALL INTO THE VENTS. ONCE THE VENTILATION SYSTEM WAS ACTIVATED, THE CONTACT STATED THAT THOSE SMALL FRAGMENTS WOULD FLY OUT OF THE VENTS AND INTO HER EYES. THE DEALER DID NOT OFFER ANY ASSISTANCE. THE MANUF…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE RAM 1500. THE CONTACT STATED THAT THE DASHBOARD WAS FRACTURED, CAUSING SMALL FRAGMENTS TO FALL INTO THE VENTS. ONCE THE VENTILATION SYSTEM WAS ACTIVATED, THE CONTACT STATED THAT THOSE SMALL FRAGMENTS WOULD FLY OUT OF THE VENTS AND INTO HER EYES. THE DEALER DID NOT OFFER ANY ASSISTANCE. THE MANUFACTURER FAILED TO OFFER ANY ASSISTANCE EITHER SINCE THERE WERE NO RECALLS ADDRESSING THE FAILURE. NO REPAIRS WERE PERFORMED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 180,000.
NHTSA ODI #10448708
Mileage unknown · Feb 1, 2012
Structure
DASH BOARD ON 2003 DODGE RAM 2500 IS CRACKED IN MULTIPLE AREAS. WINDSHIELD DEFROSTER VENT PANELS HAVE CRUMBLED AND FALLEN INTO THE AIR HANDLER SYSTEM CAUSING DEFROSTER TO STOP FUNCTIONING. *TR
NHTSA ODI #10446137
60,000 miles · Jan 10, 2012
Structure
THE DASHBOARD IN MY 2003 HAS ALOT OF CRACKS AND NOW PIECES ARE FALLING INTO THE VENTS. THIS IS A SAFETY HAZARD TO HAVE PIECES OF THE DASHBOARD BREAKING OFF,IT'S JUST A MATTER OF TIME BEFORE THE ENTIRE DASHBOARD CAVES IN. *TR
NHTSA ODI #10443323
Mileage unknown · Aug 23, 2011
EquipmentStructure
MY 2003 DODGE RAM HAS A CRACKED DASHBOARD. *TR
NHTSA ODI #10421153
137,000 miles · Aug 12, 2011
Electrical SystemFire
TL* THE CONTACT OWNS A 2003 DODGE RAM. THE CONTACT STATED THE WIRE CONNECTING THE IGNITION WIRE MELTED CAUSING THE WINDSHIELD DEFROSTER TO MALFUNCTION. THE WIRE MELTED DUE TO THE SIZE OF THE TERMINALS TO THE CONNECTOR. THE LACK OF A DEFROSTER MADE DRIVING VERY DIFFICULT FOR THE CONTACT. THE CONTACT TOOK THE VEHICLE TO THE DEA…
Read full complaint
TL* THE CONTACT OWNS A 2003 DODGE RAM. THE CONTACT STATED THE WIRE CONNECTING THE IGNITION WIRE MELTED CAUSING THE WINDSHIELD DEFROSTER TO MALFUNCTION. THE WIRE MELTED DUE TO THE SIZE OF THE TERMINALS TO THE CONNECTOR. THE LACK OF A DEFROSTER MADE DRIVING VERY DIFFICULT FOR THE CONTACT. THE CONTACT TOOK THE VEHICLE TO THE DEALER STATED THE WIRE THAT CONNECT THE IGNITION TO THE BLOWER MOTOR NEEDS TO BE REPLACED. THE CONTACT STATED THE VEHICLE WAS UNSAFE TO TO DRIVE DUE TO THE IMPAIRED VISION. THE FAILURE MILEAGE WAS 137,000.
NHTSA ODI #10419214
200,000 miles · Oct 20, 2009
Electrical SystemExterior Lighting
POOR RELIABILITY OF ELECTRICAL CONTROL AND DISTRIBUTION SYSTEM CAUSES NUMEROUS AND SOMETIMES INTERMITTENT FAILURES OF EXTERIOR SAFETY-RELATED LIGHTING SUCH AS HEADLAMPS (LOW BEAM AND HIGH BEAM), TAILLAMPS, TURN SIGNALS, BRAKE LAMPS, AND TRAILER LAMPS. PROBLEMS SEEM TO BE EXACERBATED IF VEHICLE IS NOT OPERATED FOR A FEW WEEKS. …
Read full complaint
POOR RELIABILITY OF ELECTRICAL CONTROL AND DISTRIBUTION SYSTEM CAUSES NUMEROUS AND SOMETIMES INTERMITTENT FAILURES OF EXTERIOR SAFETY-RELATED LIGHTING SUCH AS HEADLAMPS (LOW BEAM AND HIGH BEAM), TAILLAMPS, TURN SIGNALS, BRAKE LAMPS, AND TRAILER LAMPS. PROBLEMS SEEM TO BE EXACERBATED IF VEHICLE IS NOT OPERATED FOR A FEW WEEKS. DEALER IS QUOTING REPAIR COST IN EXCESS OF $2000 FOR REPLACEMENT OF THE POWER DISTRIBUTION CENTER, WHICH IS REPORTEDLY NOT A SERVICEABLE UNIT. THIS HIGH REPAIR COST WILL UNDOUBTEDLY CAUSE OWNERS TO "TAKE THEIR CHANCES" AND CONTINUE OPERATING VEHICLES IN AN UNSAFE CONDITION BECAUSE THE REPAIR IS SO COSTLY AND THE PROBLEMS ARE INTERMITTENT. SOME USERS HAVE REPORTED NEEDING TO COMPLETE THIS REPAIR MORE THAN ONCE OVER THE VEHICLE LIFETIME, WHICH FURTHER CONFIRMS THERE IS AN INHERENT RELIABILITY PROBLEM WITH THIS VEHICLE'S ELECTRICAL SYSTEM. OTHER USERS REPORT SIMILAR ISSUES WITH WINDSHIELD WIPERS REPORTEDLY DUE TO THE SAME UNIT FAILURE. BECAUSE DODGE RAM PICKUP TRUCKS HAVE AT LEAST TEN DIFFERENT MODEL CATEGORIES AND MULTIPLE MODEL YEARS FOR REPORTING IN THE NHTSA ONLINE REPORTING STRUCTURE, THE COMPLAINTS ARE SPREAD OUT AND THE CONCENTRATION OF PROBLEMS ENDEMIC TO THIS VEHICLE MAY NOT BE READILY APPARENT TO ODI INVESTIGATORS. COMPLAINTS MAY BE REPORTED UNDER "1500", "2500", "3500", "RAM", "RAM 1500", "RAM 2500", "RAM 3500", "RAM QUAD CAB", "RAM PICKUP", "DODGE TRUCK", ... , ALL DUE TO THE SAME MODULE FAILURE. COMPLAINTS ARE ALSO SPREAD OUT AMONG MANY DIFFERENT COMPLAINT CATEGORIES, FURTHER DILUTING THE RECOGNITION THAT THERE IS ONE FUNDAMENTAL ROOT CAUSE OF A DOZEN OR MORE DIFFERENT FAILURE MODES. *TR
NHTSA ODI #10289147
10,000 miles · Dec 13, 2007
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2003 DODGE RAM. THE CONTACT STATED THAT HIS VEHICLE HAS A JAKE BRAKE MECHANISM THAT LEAKS WHILE IDLING OR DECELERATING. HE HEARD THE LEAK NEAR THE ENGINE COMPARTMENT. THE DEALER INSPECTED THE VEHICLE AND STATED THAT IT WAS AN EXHAUST LEAK CAUSED BY THE JAKE BRAKE SYSTEM, BUT STATED THAT THIS WAS A NORMAL…
Read full complaint
TL*THE CONTACT OWNS A 2003 DODGE RAM. THE CONTACT STATED THAT HIS VEHICLE HAS A JAKE BRAKE MECHANISM THAT LEAKS WHILE IDLING OR DECELERATING. HE HEARD THE LEAK NEAR THE ENGINE COMPARTMENT. THE DEALER INSPECTED THE VEHICLE AND STATED THAT IT WAS AN EXHAUST LEAK CAUSED BY THE JAKE BRAKE SYSTEM, BUT STATED THAT THIS WAS A NORMAL OCCURRENCE FOR THE VEHICLE. CARBON MONOXIDE FUMES ARE ALSO ENTERING THE VEHICLE. THE CONTACT HAS NOT FILED A COMPLAINT WITH THE MANUFACTURER. THE FAILURE MILEAGE WAS 10,000 AND CURRENT MILEAGE WAS 34,000.
NHTSA ODI #10211827
NHTSA investigations
1EA04025 · False Park
Opened Aug 26, 2004 · Closed Dec 22, 2005
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:column Shift
THE SUBJECT VEHICLES ARE HEAVY DUTY PICKUP TRUCKS WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS COMMONLY USED FOR COMMERCIAL AND WORK PURPOSES.A COLUMN MOUNTED SHIFT LEVER IS USED FOR GEAR SELECTION AND AN ELECTRONIC PRNDL ON THE INSTRUMENT PANEL PROVIDES GEAR POSITION INFORMATION TO THE DRIVER.THE SUBJECT VEHICLES ARE ALSO EQUIPPED WITH A BRAKE-TRANSMISSION SHIFT INTERLOCK THAT PREVENTS THE SHIFT LEVER FROM BEING MOVED FROM THE PARK POSITION (WHEN THE ENGINE IS ON) UNLESS THE BRAKE PEDAL IS DEPRESSED AND AN IGNITION-SHIFT INTERLOCK THAT PREVENTS KEY REMOVAL UNLESS THE TRANSMISSION IS IN THE PARK POSITION.COMPLAINANTS GENERALLY REPORT THAT THE VEHICLE WAS BEING OPERATED IN A FORWARD GEAR AND BROUGHT TO A STOP THROUGH BRAKE APPLICATION ON ALEVEL SURFACE, AT WHICH TIME THE OPERATOR MOVED THE SHIFT LEVER TO ENGAGE THE PARK POSITION.THE OPERATOR THEN OPENED THE DRIVER SIDE DOOR AND, WITHOUT VERIFYING PARK ENGAGEMENT (E.G., PRNDL GEAR INDICATION), SECURING THE PARK BRAKE, OR TURNING THE ENGINE OFF, EXITED THE VEHICLE.INITIALLY, NO VEHICLE MOVEMENT WAS APPARENT, HOWEVER, A SHORT TIME LATER, TYPICALLY REPORTED AS 10 TO 30 SECONDS, THE VEHICLE MOVED REARWARD UNDER ENGINE POWER.THE INCIDENT OFTEN ENDED IN A VEHICLE CRASH, AND SOMETIMES INVOLVED SERIOUS INJURY.TWO FATALITIES ARE ALLEGED.ODI?S ANALYSIS OF TEST VEHICLES AND SOME INCIDENT VEHICLES FOUND NO EVIDENCE TO INDICATE THAT A SHIFT LEVER PROPERLY PLACED IN PARK COULD UNINTENTIONALLY (I.E., WITHOUT DRIVER INPUT) DISENGAGE FROM THAT POSITION.HOWEVER, ODI DID FIND THAT THE SHIFT LEVER COULD BE INADVERTENTLY PLACED, AND REMAIN AT REST, WITHIN AN INTERMEDIATE POSITION BETWEEN THE PARK AND REVERSE GEAR POSITIONS.WHEN PLACED IN SUCH AN INTERMEDIATE POSITION, THE VEHICLE CAN EXPERIENCE A DELAYED PRESSURIZATION OF THE REVERSE HYDRAULIC CIRCUIT THAT IS SUFFICIENT TO CAUSE THE VEHICLE TO ROLL REARWARD UNDER POWER.THE DELAY PERIOD ALLOWS SUFFICIENT TIME FOR OPERATORS TO EXIT THE STATIONARY VEHICLE WITHOUT PERCEIVING THAT THE SHIFTER IS NOT IN PARK.THE SUMMARY REPORT DISCUSSES THE TECHNICAL ANALYSIS OF THIS ISSUE IN GREATER DETAIL AND COMPARES THE FREQUENCY OF THESE INCIDENTS IN THE SUBJECT VEHICLES TO OTHER PEER VEHICLES THAT ODI EXAMINED.AS DESCRIBED IN THEIR OCTOBER 4, 2005 LETTER TO NHTSA, DAIMLERCHRYSLER CORPORATION (DCC) WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 05V-462, DCC NO. E17) TO INSTALL AN OUT-OF-PARK ALARM SYSTEM IN THE SUBJECT VEHICLES.THE ALARM WILL PROVIDE AUDIBLE AND VISUAL FEEDBACK TO ALERT THE DRIVER, AND OTHERS, IF THE DRIVER ATTEMPTS TO EXIT THE VEHICLE WHILE THE ENGINE IS RUNNING AND THE SHIFT LEVER IS NOT IN THE PARK POSITION.THE TIMING OF DCC?S ACTION HAS YET TO BE DETERMINED.
Additional source detail variants (3)
Power Train:automatic Transmission
THE SUBJECT VEHICLES ARE HEAVY DUTY PICKUP TRUCKS WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS COMMONLY USED FOR COMMERCIAL AND WORK PURPOSES.A COLUMN MOUNTED SHIFT LEVER IS USED FOR GEAR SELECTION AND AN ELECTRONIC PRNDL ON THE INSTRUMENT PANEL PROVIDES GEAR POSITION INFORMATION TO THE DRIVER.THE SUBJECT VEHICLES ARE ALSO EQUIPPED WITH A BRAKE-TRANSMISSION SHIFT INTERLOCK THAT PREVENTS THE SHIFT LEVER FROM BEING MOVED FROM THE PARK POSITION (WHEN THE ENGINE IS ON) UNLESS THE BRAKE PEDAL IS DEPRESSED AND AN IGNITION-SHIFT INTERLOCK THAT PREVENTS KEY REMOVAL UNLESS THE TRANSMISSION IS IN THE PARK POSITION.COMPLAINANTS GENERALLY REPORT THAT THE VEHICLE WAS BEING OPERATED IN A FORWARD GEAR AND BROUGHT TO A STOP THROUGH BRAKE APPLICATION ON ALEVEL SURFACE, AT WHICH TIME THE OPERATOR MOVED THE SHIFT LEVER TO ENGAGE THE PARK POSITION.THE OPERATOR THEN OPENED THE DRIVER SIDE DOOR AND, WITHOUT VERIFYING PARK ENGAGEMENT (E.G., PRNDL GEAR INDICATION), SECURING THE PARK BRAKE, OR TURNING THE ENGINE OFF, EXITED THE VEHICLE.INITIALLY, NO VEHICLE MOVEMENT WAS APPARENT, HOWEVER, A SHORT TIME LATER, TYPICALLY REPORTED AS 10 TO 30 SECONDS, THE VEHICLE MOVED REARWARD UNDER ENGINE POWER.THE INCIDENT OFTEN ENDED IN A VEHICLE CRASH, AND SOMETIMES INVOLVED SERIOUS INJURY.TWO FATALITIES ARE ALLEGED.ODI?S ANALYSIS OF TEST VEHICLES AND SOME INCIDENT VEHICLES FOUND NO EVIDENCE TO INDICATE THAT A SHIFT LEVER PROPERLY PLACED IN PARK COULD UNINTENTIONALLY (I.E., WITHOUT DRIVER INPUT) DISENGAGE FROM THAT POSITION.HOWEVER, ODI DID FIND THAT THE SHIFT LEVER COULD BE INADVERTENTLY PLACED, AND REMAIN AT REST, WITHIN AN INTERMEDIATE POSITION BETWEEN THE PARK AND REVERSE GEAR POSITIONS.WHEN PLACED IN SUCH AN INTERMEDIATE POSITION, THE VEHICLE CAN EXPERIENCE A DELAYED PRESSURIZATION OF THE REVERSE HYDRAULIC CIRCUIT THAT IS SUFFICIENT TO CAUSE THE VEHICLE TO ROLL REARWARD UNDER POWER.THE DELAY PERIOD ALLOWS SUFFICIENT TIME FOR OPERATORS TO EXIT THE STATIONARY VEHICLE WITHOUT PERCEIVING THAT THE SHIFTER IS NOT IN PARK.THE SUMMARY REPORT DISCUSSES THE TECHNICAL ANALYSIS OF THIS ISSUE IN GREATER DETAIL AND COMPARES THE FREQUENCY OF THESE INCIDENTS IN THE SUBJECT VEHICLES TO OTHER PEER VEHICLES THAT ODI EXAMINED.AS DESCRIBED IN THEIR OCTOBER 4, 2005 LETTER TO NHTSA, DAIMLERCHRYSLER CORPORATION (DCC) WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 05V-462, DCC NO. E17) TO INSTALL AN OUT-OF-PARK ALARM SYSTEM IN THE SUBJECT VEHICLES.THE ALARM WILL PROVIDE AUDIBLE AND VISUAL FEEDBACK TO ALERT THE DRIVER, AND OTHERS, IF THE DRIVER ATTEMPTS TO EXIT THE VEHICLE WHILE THE ENGINE IS RUNNING AND THE SHIFT LEVER IS NOT IN THE PARK POSITION.THE TIMING OF DCC?S ACTION HAS YET TO BE DETERMINED.
Power Train:automatic Transmission:gear Position Indication (prndl)
THE SUBJECT VEHICLES ARE HEAVY DUTY PICKUP TRUCKS WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS COMMONLY USED FOR COMMERCIAL AND WORK PURPOSES.A COLUMN MOUNTED SHIFT LEVER IS USED FOR GEAR SELECTION AND AN ELECTRONIC PRNDL ON THE INSTRUMENT PANEL PROVIDES GEAR POSITION INFORMATION TO THE DRIVER.THE SUBJECT VEHICLES ARE ALSO EQUIPPED WITH A BRAKE-TRANSMISSION SHIFT INTERLOCK THAT PREVENTS THE SHIFT LEVER FROM BEING MOVED FROM THE PARK POSITION (WHEN THE ENGINE IS ON) UNLESS THE BRAKE PEDAL IS DEPRESSED AND AN IGNITION-SHIFT INTERLOCK THAT PREVENTS KEY REMOVAL UNLESS THE TRANSMISSION IS IN THE PARK POSITION.COMPLAINANTS GENERALLY REPORT THAT THE VEHICLE WAS BEING OPERATED IN A FORWARD GEAR AND BROUGHT TO A STOP THROUGH BRAKE APPLICATION ON ALEVEL SURFACE, AT WHICH TIME THE OPERATOR MOVED THE SHIFT LEVER TO ENGAGE THE PARK POSITION.THE OPERATOR THEN OPENED THE DRIVER SIDE DOOR AND, WITHOUT VERIFYING PARK ENGAGEMENT (E.G., PRNDL GEAR INDICATION), SECURING THE PARK BRAKE, OR TURNING THE ENGINE OFF, EXITED THE VEHICLE.INITIALLY, NO VEHICLE MOVEMENT WAS APPARENT, HOWEVER, A SHORT TIME LATER, TYPICALLY REPORTED AS 10 TO 30 SECONDS, THE VEHICLE MOVED REARWARD UNDER ENGINE POWER.THE INCIDENT OFTEN ENDED IN A VEHICLE CRASH, AND SOMETIMES INVOLVED SERIOUS INJURY.TWO FATALITIES ARE ALLEGED.ODI?S ANALYSIS OF TEST VEHICLES AND SOME INCIDENT VEHICLES FOUND NO EVIDENCE TO INDICATE THAT A SHIFT LEVER PROPERLY PLACED IN PARK COULD UNINTENTIONALLY (I.E., WITHOUT DRIVER INPUT) DISENGAGE FROM THAT POSITION.HOWEVER, ODI DID FIND THAT THE SHIFT LEVER COULD BE INADVERTENTLY PLACED, AND REMAIN AT REST, WITHIN AN INTERMEDIATE POSITION BETWEEN THE PARK AND REVERSE GEAR POSITIONS.WHEN PLACED IN SUCH AN INTERMEDIATE POSITION, THE VEHICLE CAN EXPERIENCE A DELAYED PRESSURIZATION OF THE REVERSE HYDRAULIC CIRCUIT THAT IS SUFFICIENT TO CAUSE THE VEHICLE TO ROLL REARWARD UNDER POWER.THE DELAY PERIOD ALLOWS SUFFICIENT TIME FOR OPERATORS TO EXIT THE STATIONARY VEHICLE WITHOUT PERCEIVING THAT THE SHIFTER IS NOT IN PARK.THE SUMMARY REPORT DISCUSSES THE TECHNICAL ANALYSIS OF THIS ISSUE IN GREATER DETAIL AND COMPARES THE FREQUENCY OF THESE INCIDENTS IN THE SUBJECT VEHICLES TO OTHER PEER VEHICLES THAT ODI EXAMINED.AS DESCRIBED IN THEIR OCTOBER 4, 2005 LETTER TO NHTSA, DAIMLERCHRYSLER CORPORATION (DCC) WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 05V-462, DCC NO. E17) TO INSTALL AN OUT-OF-PARK ALARM SYSTEM IN THE SUBJECT VEHICLES.THE ALARM WILL PROVIDE AUDIBLE AND VISUAL FEEDBACK TO ALERT THE DRIVER, AND OTHERS, IF THE DRIVER ATTEMPTS TO EXIT THE VEHICLE WHILE THE ENGINE IS RUNNING AND THE SHIFT LEVER IS NOT IN THE PARK POSITION.THE TIMING OF DCC?S ACTION HAS YET TO BE DETERMINED.
Power Train:automatic Transmission:lever And Linkage:column Shift
THE SUBJECT VEHICLES ARE HEAVY DUTY PICKUP TRUCKS WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS COMMONLY USED FOR COMMERCIAL AND WORK PURPOSES.A COLUMN MOUNTED SHIFT LEVER IS USED FOR GEAR SELECTION AND AN ELECTRONIC PRNDL ON THE INSTRUMENT PANEL PROVIDES GEAR POSITION INFORMATION TO THE DRIVER.THE SUBJECT VEHICLES ARE ALSO EQUIPPED WITH A BRAKE-TRANSMISSION SHIFT INTERLOCK THAT PREVENTS THE SHIFT LEVER FROM BEING MOVED FROM THE PARK POSITION (WHEN THE ENGINE IS ON) UNLESS THE BRAKE PEDAL IS DEPRESSED AND AN IGNITION-SHIFT INTERLOCK THAT PREVENTS KEY REMOVAL UNLESS THE TRANSMISSION IS IN THE PARK POSITION.COMPLAINANTS GENERALLY REPORT THAT THE VEHICLE WAS BEING OPERATED IN A FORWARD GEAR AND BROUGHT TO A STOP THROUGH BRAKE APPLICATION ON ALEVEL SURFACE, AT WHICH TIME THE OPERATOR MOVED THE SHIFT LEVER TO ENGAGE THE PARK POSITION.THE OPERATOR THEN OPENED THE DRIVER SIDE DOOR AND, WITHOUT VERIFYING PARK ENGAGEMENT (E.G., PRNDL GEAR INDICATION), SECURING THE PARK BRAKE, OR TURNING THE ENGINE OFF, EXITED THE VEHICLE.INITIALLY, NO VEHICLE MOVEMENT WAS APPARENT, HOWEVER, A SHORT TIME LATER, TYPICALLY REPORTED AS 10 TO 30 SECONDS, THE VEHICLE MOVED REARWARD UNDER ENGINE POWER.THE INCIDENT OFTEN ENDED IN A VEHICLE CRASH, AND SOMETIMES INVOLVED SERIOUS INJURY.TWO FATALITIES ARE ALLEGED.ODI?S ANALYSIS OF TEST VEHICLES AND SOME INCIDENT VEHICLES FOUND NO EVIDENCE TO INDICATE THAT A SHIFT LEVER PROPERLY PLACED IN PARK COULD UNINTENTIONALLY (I.E., WITHOUT DRIVER INPUT) DISENGAGE FROM THAT POSITION.HOWEVER, ODI DID FIND THAT THE SHIFT LEVER COULD BE INADVERTENTLY PLACED, AND REMAIN AT REST, WITHIN AN INTERMEDIATE POSITION BETWEEN THE PARK AND REVERSE GEAR POSITIONS.WHEN PLACED IN SUCH AN INTERMEDIATE POSITION, THE VEHICLE CAN EXPERIENCE A DELAYED PRESSURIZATION OF THE REVERSE HYDRAULIC CIRCUIT THAT IS SUFFICIENT TO CAUSE THE VEHICLE TO ROLL REARWARD UNDER POWER.THE DELAY PERIOD ALLOWS SUFFICIENT TIME FOR OPERATORS TO EXIT THE STATIONARY VEHICLE WITHOUT PERCEIVING THAT THE SHIFTER IS NOT IN PARK.THE SUMMARY REPORT DISCUSSES THE TECHNICAL ANALYSIS OF THIS ISSUE IN GREATER DETAIL AND COMPARES THE FREQUENCY OF THESE INCIDENTS IN THE SUBJECT VEHICLES TO OTHER PEER VEHICLES THAT ODI EXAMINED.AS DESCRIBED IN THEIR OCTOBER 4, 2005 LETTER TO NHTSA, DAIMLERCHRYSLER CORPORATION (DCC) WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 05V-462, DCC NO. E17) TO INSTALL AN OUT-OF-PARK ALARM SYSTEM IN THE SUBJECT VEHICLES.THE ALARM WILL PROVIDE AUDIBLE AND VISUAL FEEDBACK TO ALERT THE DRIVER, AND OTHERS, IF THE DRIVER ATTEMPTS TO EXIT THE VEHICLE WHILE THE ENGINE IS RUNNING AND THE SHIFT LEVER IS NOT IN THE PARK POSITION.THE TIMING OF DCC?S ACTION HAS YET TO BE DETERMINED.
Illustration