1) ELECTRICAL PROBLEMS. LIGHTS KEPT GOING IN AND OUT 2) DASH CRACKING AND CRUMBLING. PIECES FALLING INTO AIR VENTS AND PREVENTING WINDSHIELD FROM DEFROSTING! DANGEROUS! COULD CAUSE AN ACCIDENT. DASH IS IN SUCH BAD SHAPE THAT IF PASSENGER AIR BAG WERE TO BE DEPLOYED IT COULD KILL SOMEONE DUE TO FLYING PIECES OF HARD PLASTIC ALL …
Read full complaint
1) ELECTRICAL PROBLEMS. LIGHTS KEPT GOING IN AND OUT 2) DASH CRACKING AND CRUMBLING. PIECES FALLING INTO AIR VENTS AND PREVENTING WINDSHIELD FROM DEFROSTING! DANGEROUS! COULD CAUSE AN ACCIDENT. DASH IS IN SUCH BAD SHAPE THAT IF PASSENGER AIR BAG WERE TO BE DEPLOYED IT COULD KILL SOMEONE DUE TO FLYING PIECES OF HARD PLASTIC ALL OVER THE VEHICLE. MAKE DODGE RECALL THIS PRODUCT! WHAT ARE YOU WAITING FOR? YOU ALREADY HAVE THOUSANDS OF COMPLAINTS FOR THIS PROBLEM! *TT
NHTSA ODI #10444610
Mileage unknown · Jan 16, 2008
Electrical SystemEquipment
1. REPLACED FUSE (ORIGINAL EQUIPMENT) ON MY 2002 DODGE RAM PICKUP FOR THE LEFT REAR TRAILER LIGHTS WITH STOREHOUSE FUSE BOUGHT AT HARBOR FREIGHT STORE. 2. FUSE DID NOT "BLOW" AS IT SHOULD AND "WELDED" ITSELF INTO FUSE BLOCK. I CANNOT REMOVE THE REMNANTS OF THE FUSE. 3. THIS MAY NECESSITATE COMPLETE REPLACEMENT OF THE FUSE B…
Read full complaint
1. REPLACED FUSE (ORIGINAL EQUIPMENT) ON MY 2002 DODGE RAM PICKUP FOR THE LEFT REAR TRAILER LIGHTS WITH STOREHOUSE FUSE BOUGHT AT HARBOR FREIGHT STORE. 2. FUSE DID NOT "BLOW" AS IT SHOULD AND "WELDED" ITSELF INTO FUSE BLOCK. I CANNOT REMOVE THE REMNANTS OF THE FUSE. 3. THIS MAY NECESSITATE COMPLETE REPLACEMENT OF THE FUSE BLOCK AT CONSIDERABLE COST. POSSIBLE HUNDREDS OF DOLLARS. *TR
NHTSA ODI #10215125
Mileage unknown · May 8, 2007
Electrical System
TL*THE CONTACT OWNS A 2002 DODGE RAM 3500. THE CONTACT STATED THAT THERE IS A CRACK ON THE VEHICLE'S DASHBOARD WHICH CAUSED THE LIGHTS TO MALFUNCTION. THE DEALER HAS NOT INSPECTED THE VEHICLE. THERE HAVE BEEN NO FAILURES TO DATE. THE CURRENT MILEAGE IS 98,700 AND THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10190161
Mileage unknown · Nov 20, 2003
Electrical SystemEngine And Engine CoolingExterior Lighting
COMPLAINT INVOLVING 2002 DODGE RAM TRUCK.*MR (NAR) THE CONSUMER HAS EXPERIENCED ONGOING PROBLEMS WITH VEHICLE AND REQUESTED THAT THE DEALERSHIP REPURCHASE THE VEHICLE. *CB
NHTSA ODI #10048469
Mileage unknown · May 30, 2002
Electrical System
CONSUMER STATES THAT WHILE DRIVING ALL THE DIGITAL READINGS ON THE DASH CAME ON. THE TURN SIGNAL, HEADLIGHTS, BRAKES ETC. A RED LIGHT SENSOR ON THE DASH CAME ON AND THE HEADLIGHTS CAME BACK ON. PLEASE PROVIDE ANY FURTHER INFORMATION.*JB
ON CERTAIN VAN AND WAGON VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKE SYSTEMS (ABS), AFTERMARKET BATTERIES MAY LEAK ELECTROLYTE ONTO THE ABS CONTROL MODULE CONNECTOR, WHICH CAN COMPROMISE SEALING INTEGRITY OF THE CONNECTOR.
Consequence & remedy
Consequence: THIS MAY ALLOW DEVELOPMENT OF A SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE ABS CONTROL MODULE CONNECTOR FOR ELECTROLYTE DAMAGE AND REPLACE THE CONNECTOR AS NECESSARY. THE RECALL WILL BEGIN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN 4X4 PICKUP TRUCKS, THE REAR AXLE FLANGE WELD TO THE AXLE TUBE COULD FATIGUE AND ALLOW THE BRAKE CALIPER ASSEMBLY TO ROTATE.
Consequence & remedy
Consequence: DURING ROTATION, THE BRAKE LINE COULD SEPARATE FROM THE CALIPER RESULTING IN A BRAKE FLUID LOSS IN THE REAR BRAKE HYDRAULIC SYSTEM.
Remedy: DEALERS WILL INSTALL REAR BRAKE CALIPER REINFORCEMENTS ON THE REAR AXLE ASSEMBLIES. OWNER NOTIFICATION BEGAN DECEMBER 9, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE02096 · Rear Axle Failure
Opened Dec 26, 2002 · Closed May 15, 2003
Status: closed (inferred from source dates) · Power Train:axle Assembly; Power Train:driveline:differential Unit
SEE ATTACHED REPORT.
Additional source detail variants (2)
Power Train:axle Assembly
SEE ATTACHED REPORT.
Power Train:driveline:differential Unit
SEE ATTACHED REPORT.
2002 Dodge RAM Problems, Complaints & Recalls | Skip That Year
Illustration