Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
4025–50K
4350–75K
1975–100K
16100–150K
6150K+
155 reports with mileage · 90 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports11 fire reports6 injury reports
What owners actually said
245 reports
50,000 miles · Dec 31, 2005
Air BagsVisibility
AIR BAG LIGHT REMAINED ON ALL THE TIME. BROUGHT VAN TO DEALER KNOWING THAT THEIR HAD BEEN LARGE RECALLS OF VANS WITH AIRBAG PROBLEMS IN THE PAST. THE CLOCKSPRING NEEDED TO BE REPLACED. COMPANY CLAIMED THAT THERE WAS NO RECALL FOR 2002 MODELS. THIS SEEMS TO BE AN ONGOING PROBLEM FOR DODGE AND SHOULD BE COVERED BY THEM. ALSO …
Read full complaint
AIR BAG LIGHT REMAINED ON ALL THE TIME. BROUGHT VAN TO DEALER KNOWING THAT THEIR HAD BEEN LARGE RECALLS OF VANS WITH AIRBAG PROBLEMS IN THE PAST. THE CLOCKSPRING NEEDED TO BE REPLACED. COMPANY CLAIMED THAT THERE WAS NO RECALL FOR 2002 MODELS. THIS SEEMS TO BE AN ONGOING PROBLEM FOR DODGE AND SHOULD BE COVERED BY THEM. ALSO NOT COVERED UNDER THE WARRANTY. ALSO PROBLEMS WITH THE REAR WINDSHIELD WIPER MOTOR BREAKING. *JB
NHTSA ODI #10146622
39,000 miles · Dec 30, 2005
Steering
DT: THE CONTACT STATED THEREWAS A HUMMING NOISE AND TIGHTNESS IN THE STEERING WHEEL WHEN STARTING THE VEHICLE IN COLD OR DAMP WEATHER. THE HUMMING NOISEWAS NOTICEABLE WHEN TURNING THE STEERING WHEEL TO EITHER THE LEFT OR RIGHT. THE DEALER REPLACED SEVERAL SEALS, GASKETS, THE POWER STEERING PUMP, SEVERAL HOSES ,AND WIRING. NONE O…
Read full complaint
DT: THE CONTACT STATED THEREWAS A HUMMING NOISE AND TIGHTNESS IN THE STEERING WHEEL WHEN STARTING THE VEHICLE IN COLD OR DAMP WEATHER. THE HUMMING NOISEWAS NOTICEABLE WHEN TURNING THE STEERING WHEEL TO EITHER THE LEFT OR RIGHT. THE DEALER REPLACED SEVERAL SEALS, GASKETS, THE POWER STEERING PUMP, SEVERAL HOSES ,AND WIRING. NONE OF THESE REPLACEMENT PARTS SOLVED THE PROBLEM. THE MANUFACTURER TOLD THE CONTACT THEY WERE AWARE OF THIS PROBLEM, AND THERE MAY BE A RECALL OR AN EXTENDED WARRANTY WITHIN A YEAR. *AK
NHTSA ODI #10146538
19,000 miles · Dec 29, 2005
Service Brakes, HydraulicSteeringSuspension
I HEARD A "BANGING" NOISE WHILE DRIVING ON THE HIGHWAY AT 50 MPH. SO I CALLED MY DEALER TO SCHEDULE AN APPT FOR MULTIPLE OF REASONS AND THEY FOUND THE FOLLOWING ISSUES AGAIN WITH MY CAR; MY FRONT BRAKES (SHOE PADES, ROTOR'S TURNED) NEEDED TO BE REPLACED AGAIN SINCE I'VE HAD THIS CAR AND THE CAR ONLY HAS 45,000 MILES ON IT AND PR…
Read full complaint
I HEARD A "BANGING" NOISE WHILE DRIVING ON THE HIGHWAY AT 50 MPH. SO I CALLED MY DEALER TO SCHEDULE AN APPT FOR MULTIPLE OF REASONS AND THEY FOUND THE FOLLOWING ISSUES AGAIN WITH MY CAR; MY FRONT BRAKES (SHOE PADES, ROTOR'S TURNED) NEEDED TO BE REPLACED AGAIN SINCE I'VE HAD THIS CAR AND THE CAR ONLY HAS 45,000 MILES ON IT AND PREVIOUS TO THAT, THE DEALER REPLACED THE SHOE PADES AGAIN AT 19,000 MILES?? ALSO AT 19,000 MILES, THE DEALER HAD TO REPLACE THE "BUSHINGS AND LINKS" FOR THE FRONT END AND AGAIN AT 45,000 MILES TWO DAYS AGO. I AM STRATING TO WONDER IF THERE IS A DIRECT LINK BETWEEN THE TWO PARTS GOING PREMATURELY. I ALSO HAD TO REPLACE ALL FOUR TIRES BECAUSE DUE TO THE WEAR/TEAR ON THEM BECASUE THEY WERE UNSAFE. THE DEALER WON'T WARRENTY THEM, SO I HAD TO BUY NEW SET OF TIRES AT 19,000 MILES. I THINK THE TIRES WORN OUT PREMATURELY DUE TO ALL THE FRONT END PROBLEMS THAT I AM HAVING. THERE ALSO HAVE BEEN A NUMBER OF "POWER STEERING" ISSUES WITH MY VEHICHLE SINCE I PURCHASED IT. I BELIEVE THERE HAS BEEN TWO RECALLS ON THE POWER STEERING UNIT AND HAD THE DEALER TAKE CARE OF THEM.(HAD THE CAR TOWED BECAUSE THE POWER STEERING WON'T WORK AND IT LEAKED ALL OVER MY NEW DRIVEWAY) I 'VE HAD THE CAR BACK TO THE DEALER 3 TIMES FOR "POWER STEERING" LEAKING. THE LATEST NEW WAS THE A "BOOT" OF SOME SORT IN THE "RACK-AND-PINION STEERING" WAS THE CAUSE OF THE POWER STEERING LEAK AND THEY ALSO FOUND AN OIL LEAK ON THE HEADCASK COVER TOO. AFTER EVERYTHING WAS FINALLY FINIHSED (AFTER 2 DAYS) I PICKED UP THE CAR AND DROVE IT HOME BUT I AM GOING TO BRING IT BACK TO THE DEALSHIP BECAUSE NOW THE CAR IS SWAYING LEFT/RIGHT AND THE DEALERSHIP SAID THEY DID A FRONT END ALIGNEMENT BECAUSE OF ALL THE WORK THEY HAD TO DUE TO THE VEHICLE. *JB
NHTSA ODI #10146342
17,000 miles · Dec 27, 2005
Air Bags
AIRBAG MALFUNCTION WARNING LIGHT ILLUMINATED. *JB
NHTSA ODI #10146105
Mileage unknown · Dec 22, 2005
Structure
2002 DODGE CARAVAN HAS RUSTED IN FOUR DIFFERENT AREAS. *TS *NM
NHTSA ODI #10147510
26,000 miles · Dec 5, 2005
Steering
DT: THE CONTACT TOOK VEHICLE TO A DEALERSHIP TO HAVE IT INSPECTED .THE MECHANIC DETERMINED THE RIGHT FRONT TIE ROD END BROKE. THE VEHICLE IS AT THE DEALERSHIP AT THIS TIME. REPAIRS WILL BE MADE AT THE CONTACT'S EXPENSE. *AK UPDATED 1/11/2006. *NM
NHTSA ODI #10144486
26,000 miles · Dec 5, 2005
Steering
DT: THE CONTACT STATED DURING STATE SAFETY INSPECTION, IT WAS DISCOVERED THAT RIGHT FRONT TIE ROD ASSEMBLY WORE OUT. THE DEALER WAS CONTACTED. THIS WAS NOT COVERED UNDER A WARRANTY. NO REPAIRS HAVE BEEN MADE. *AK
NHTSA ODI #10144482
Mileage unknown · Dec 4, 2005
Parking Brake
BRAKES ON 2002 DODGE CARAVAN LOCK WHEN PARKING BRAKE IS USED OVERNIGHT. WHEN RELEASING PARKING BRAKE IN MORNING, UNABLE TO MOVE VEHICLE FORWARD OR BACKWARD. IN ATTEMPTING TO DO SO TO GET MOVING, AFTER NUMEROUS ATTEMPTS, CUSTOMER WILL HEAR A LOUD POP NOISE AND BRAKES FREE UP. THIS IS A CONTINUING PROBLEM, NOT JUST ONE TIME. TOOK …
Read full complaint
BRAKES ON 2002 DODGE CARAVAN LOCK WHEN PARKING BRAKE IS USED OVERNIGHT. WHEN RELEASING PARKING BRAKE IN MORNING, UNABLE TO MOVE VEHICLE FORWARD OR BACKWARD. IN ATTEMPTING TO DO SO TO GET MOVING, AFTER NUMEROUS ATTEMPTS, CUSTOMER WILL HEAR A LOUD POP NOISE AND BRAKES FREE UP. THIS IS A CONTINUING PROBLEM, NOT JUST ONE TIME. TOOK TO THE DEALER AND WAS TOLD THAT THE BRAKES WERE DIRTY. WAS CHARGED $168 WHEN WE DID NOT PROCEED WITH "REPAIRS" TO BE TOLD THAT A HEADLIGHT WAS OUT AND THAT THE BRAKES WERE DIRTY. WE KNEW THE HEADLIGHT WAS OUT! AND THE BRAKES WERE NOT DIRTY. HAVE NOT RETURNED TO THIS DEALER SINCE (KENDALL IN COTTAGE GROVE, OREGON). *NM
NHTSA ODI #10144400
46,000 miles · Dec 1, 2005
Steering
STEERING FAILURE. WHEN TURNING THE STEERING TO THE FAR LEFT OR RIGHT, THE STEERING WHEEL STICKS IN THAT POSITION AND RELEASES ONLY AFTER SEVERAL ATTEMPTS. IN NORMAL STRAIGHT AHEAD OPERATION THERE IS A VERY NOTICEABLE NOISE AND COMING FROM THE STEERING APPARATUS. I BELIEVE THIS TO BE A DANGEROUS SITUATION. I HAVE CONTACTED C…
Read full complaint
STEERING FAILURE. WHEN TURNING THE STEERING TO THE FAR LEFT OR RIGHT, THE STEERING WHEEL STICKS IN THAT POSITION AND RELEASES ONLY AFTER SEVERAL ATTEMPTS. IN NORMAL STRAIGHT AHEAD OPERATION THERE IS A VERY NOTICEABLE NOISE AND COMING FROM THE STEERING APPARATUS. I BELIEVE THIS TO BE A DANGEROUS SITUATION. I HAVE CONTACTED CHRYSLER, THEY OPTED TO DO NOTHING--SUGGESTED THAT I GET IT REPAIRED. *NM
NHTSA ODI #10144112
Mileage unknown · Nov 22, 2005
StructureInjury
CHILD HAD THUMB SLAMMED IN VAN DOOR AND FAMILY WAS UNABLE TO OPEN THE DOOR FOR THREE MINUTES. CHILD FRACTURED BONE. A YOUNGER CHILD COULD HAVE LOST A LIMB. PARENT HAD TO GO INSIDE THE CAR AND PULL THE JAMMED LOCK TO FREE CHILD. IF PARENT WAS HOLDING A CHILD AND THEY GOT A LIMB STUCK THE PARENT COULD NOT LET GO OF THE CHILD TO G…
Read full complaint
CHILD HAD THUMB SLAMMED IN VAN DOOR AND FAMILY WAS UNABLE TO OPEN THE DOOR FOR THREE MINUTES. CHILD FRACTURED BONE. A YOUNGER CHILD COULD HAVE LOST A LIMB. PARENT HAD TO GO INSIDE THE CAR AND PULL THE JAMMED LOCK TO FREE CHILD. IF PARENT WAS HOLDING A CHILD AND THEY GOT A LIMB STUCK THE PARENT COULD NOT LET GO OF THE CHILD TO GO INSIDE AND FREE THE DOOR. *NM
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03012 · Power Steering Hose Failure
Opened Apr 9, 2003 · Closed May 29, 2003
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid; Steering:hydraulic Power Assist:pump; Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
Additional source detail variants (5)
Steering:hydraulic Power Assist:hose, Piping, And Connections
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:power Steering Fluid
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:pump
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist System
PLEASE SEE ATTACHED REPORT.
Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
2002 Dodge Caravan Problems, Complaints & Recalls | Skip That Year
Illustration