IllustrationDURING NORMAL DRIVING OPERATIONS THE AIRBAG WARNING LIGHT WOULD INTERMITTENTLY COME ON. NOW IT COMES ON AT THE START OF THE ENGINE, AND DOES NOT TURN OFF. IT APPEARS THAT THIS IS THE SAME CLOCKSPRING PROBLEM AS WAS RECALLED EARLIER. *NM
2002 Dodge Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Dodge Caravan do not stand out strongly from the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
4025–50K
4350–75K
1975–100K
16100–150K
6150K+
155 reports with mileage · 90 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports11 fire reports6 injury reports
What owners actually said
245 reportsTHE AIR BAG LIGHT ON MY 2002 DODGE CARAVAN WENT ON. THEN STEERING WHEEL STARTED TO MAKE CLICKING NOISE WHEN TURNING CORNERS. THEN DIRECTIONAL INDICATORS WOULD NOT TURN OFF AFTER MAKING A TURN. FINALLY, I ALMOST GOT INTO AN ACCIDENT BECAUSE MY STEERING WHEEL LOCKED AND I COULD NOT TURN A CORNER. I FORCED IT AND IT DID TURN. I WIL…
Read full complaint
THE AIR BAG LIGHT ON MY 2002 DODGE CARAVAN WENT ON. THEN STEERING WHEEL STARTED TO MAKE CLICKING NOISE WHEN TURNING CORNERS. THEN DIRECTIONAL INDICATORS WOULD NOT TURN OFF AFTER MAKING A TURN. FINALLY, I ALMOST GOT INTO AN ACCIDENT BECAUSE MY STEERING WHEEL LOCKED AND I COULD NOT TURN A CORNER. I FORCED IT AND IT DID TURN. I WILL NOT DRIVE THIS VEHICLE AGAIN. I CALLED A CHRYSLER DEALER AND THEY TOLD ME IT SOUNDS LIKE THE CLOCKSPRING. THE MILEAGE ON THIS VEHICLE IS ONLY 33,000 MILES. SINCE IT IS OUT OF WARRANTY I WOULD HAVE TO PAY FOR IT BECAUSE THERE HAVE NOT BEEN ANY RECALLS FOR THIS AS OF YET. THIS IS THE SECOND DODGE CARAVAN THAT I HAVE OWNED. THE FIRST ONE WAS RECALLED FOR THE CLOCKSPRING ALSO. I KNOW THAT CHRYSLER HAS A HISTORY OF BAD CLOCKSPRINGS. ARE THEY WAITING FOR ENOUGH ACCIDENTS TO HAPPEN? I WANT CHRYSLER TO FIX THIS PROBLEM FOR ME, FREE OF CHARGE. THIS IS NOT AN ABUSED VEHICLE. I TAKE CARE OF EVERYTHING I OWN. HOW CAN THEY MAKE SUCH POOR PARTS? *JB
HAD RACK IN PINION AND FRONT END WORK DONE DECEMBER 28, 2005 AND TOOK BACK THE CAR ON JANUARY 2006 TWICE FOR FRONT END NOT BEING ALIGNED. TOOK THE CAR BACK TO DEAL TO HAVE THEM LOOK AT IGNITION AND ALARM BECAUSE CAR WON'T START AND ALARM LIGHT WAS FLASHING. STEVE- FIXED THE ALARM BUT ALSO NOTICE THAT THE STEERING WHEEL WON'T LOC…
Read full complaint
HAD RACK IN PINION AND FRONT END WORK DONE DECEMBER 28, 2005 AND TOOK BACK THE CAR ON JANUARY 2006 TWICE FOR FRONT END NOT BEING ALIGNED. TOOK THE CAR BACK TO DEAL TO HAVE THEM LOOK AT IGNITION AND ALARM BECAUSE CAR WON'T START AND ALARM LIGHT WAS FLASHING. STEVE- FIXED THE ALARM BUT ALSO NOTICE THAT THE STEERING WHEEL WON'T LOCK AND THE IGNITION WAS HAVING ISSUES STARTING CAR. HE SUGGESTED SCHEDULING AN APPOINTMENT TO GET THEM FIXED, GOT THE CAR BACK TODAY AND THE STEERING WHEEL STILL ISN'T LOCKING. BACK IN DEC-JAN SERVICE DATES, DENSIE-SERVICE ADVISOR STATED THAT THEY REPLACED MY STEERING COLUMN WITH A REBUILT BECAUSE THE HAD ISSUES FIXING MY ORIGINAL ONE. NOW THE IGNITION ISSUES HAS HAPPENED AND THE DEALER AND SERVICE MANAGER STATED THAT THE REBUILT STEERING COLUMN WAS NEVER REPLACED OR IN THE COMPUTER HISTORY. DENISE IS NO LONGER WORKING AT THE DEALERSHIP AND I HAD TO PAY FOR THE REPLACEMENT PARTS FOR THE IGNITION PROBLEMS. *JB
HEADLIGHTS/ INTERIOR DASH BOARD LIGHTING FLICKERING. DURING THE DAY TIME HOURS THE DASH BOARD LIGHTS SEEM TO SURGE. THE POWER FOR THE 12 VOLT OUTLETS IN THE CAR WHEN BRAKING TAKE OFF TIMES. IN THE EVENING HOURS THE HEADLIGHTS WILL FLICKER ON AND OFF WITHOUT CAUSE DURING NORMAL DRIVING TIMES. THE FLICKERING WILL NOT BE STOPPED B…
Read full complaint
HEADLIGHTS/ INTERIOR DASH BOARD LIGHTING FLICKERING. DURING THE DAY TIME HOURS THE DASH BOARD LIGHTS SEEM TO SURGE. THE POWER FOR THE 12 VOLT OUTLETS IN THE CAR WHEN BRAKING TAKE OFF TIMES. IN THE EVENING HOURS THE HEADLIGHTS WILL FLICKER ON AND OFF WITHOUT CAUSE DURING NORMAL DRIVING TIMES. THE FLICKERING WILL NOT BE STOPPED BY TURNING OFF THE HEADLIGHT CONTROL SWITCH AND SOMETIMES THE SWITCH WILL NOT OPERATE THE HEADLIGHTS AT ALL. I HAVE NOT GOTTEN ANY ANSWERS FROM THE DEALERSHIP AND HAVE DECIDED TO WAIT AND SEE IF YOU COME UP WITH A SOLUTION TO THE PROBLEM. THANK YOU FOR READING THIS SUBMISSION. *JB
DT*: THE CONTACT STATED THE VEHICLE STALLED INTERMITTENTLY AND OCCURRED AT NO PARTICULAR SPEED; HOWEVER, THE VEHICLE IMMEDIATELY RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, BUT THE PROBLEM COULD NOT BE DUPLICATED. UPDATE 5/2/2006 - ALL THE DASH LIGHTS FLICKERED AND THE CRUISE CONTROL LIGHT ILLUMINAT…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE STALLED INTERMITTENTLY AND OCCURRED AT NO PARTICULAR SPEED; HOWEVER, THE VEHICLE IMMEDIATELY RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, BUT THE PROBLEM COULD NOT BE DUPLICATED. UPDATE 5/2/2006 - ALL THE DASH LIGHTS FLICKERED AND THE CRUISE CONTROL LIGHT ILLUMINATED. THE DEALER REPLACED THE BATTERY. *NM
I BOUGHT A DODGE CARAVAN 2002. OUT OF NOWHERE THE AIRBAG LIGHT COMES ON WHEN I TURN THE STEERING WHEEL. I TOOK IT TO A DODGE DEALERSHIP TO HAVE IT CHECKED BUT BECAUSE MY CARAVAN DIDN'T FALL INTO THE CATEGORY OF THAT RECALL IT WAS NOT TAKEN CARE OF. THE PERSON AT THE SERVICE DESK DID SAY THAT MANY CARAVANS HAVE HAD THAT PROBLEM…
Read full complaint
I BOUGHT A DODGE CARAVAN 2002. OUT OF NOWHERE THE AIRBAG LIGHT COMES ON WHEN I TURN THE STEERING WHEEL. I TOOK IT TO A DODGE DEALERSHIP TO HAVE IT CHECKED BUT BECAUSE MY CARAVAN DIDN'T FALL INTO THE CATEGORY OF THAT RECALL IT WAS NOT TAKEN CARE OF. THE PERSON AT THE SERVICE DESK DID SAY THAT MANY CARAVANS HAVE HAD THAT PROBLEM. SO I CALLED CHRYSLER CORPORATION AND THEY STATED THAT BECAUSE THE CAR HAS 80,000+ MILES ON IT THEY WILL NOT DO ANYTHING BECAUSE IT IS OUT OF WARRANTY. EVEN THOUGH THE DEFECT WAS THERE BEFORE. THIS ISN'T FAIR AND I THINK THAT IT SHOULD BE TAKEN CARE OF BY CHRYSLER BECAUSE THEY SOLD THE DEFECTIVE VAN TO BEGIN WITH. *JB
DT*: THE CONTACT STATED WHILE DRIVING 65 MPH, ALL OF THE DASHBOARD LIGHTS ILLUMINATED THEN THE VEHICLE WOULD NOT MOVE. THE VEHICLE WAS TOWED TO THE DEALERSHIP ON A FLATBED TRUCK BECAUSE THE TIRES WERE LOCKED UP. THE DEALERSHIPS DIAGNOSTIC TEST DETERMINED THE TRANSMISSION WENT OUT AND NEEDS TO BE REPLACED. ALSO, THE BRAKES WI…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 65 MPH, ALL OF THE DASHBOARD LIGHTS ILLUMINATED THEN THE VEHICLE WOULD NOT MOVE. THE VEHICLE WAS TOWED TO THE DEALERSHIP ON A FLATBED TRUCK BECAUSE THE TIRES WERE LOCKED UP. THE DEALERSHIPS DIAGNOSTIC TEST DETERMINED THE TRANSMISSION WENT OUT AND NEEDS TO BE REPLACED. ALSO, THE BRAKES WILL NOT RELEASE WHILE THE BRAKE PEDAL IS DEPRESSED, THIS OCCURS EVERY TIME, AND CAUSES THE RIMS TO GET HOT, CAUSING THREE BLOWOUTS ON THE FRONT END. THE DEALERSHIP IS UNABLE TO DETERMINE A PROBLEM, BUT THE SHOES HAVE BEEN REPLACED 6 TIMES AND THE ROTORS WERE REPLACED TWICE.
HEADLIGHTS KEPT FLICKERING WHEN TURN SIGNAL WAS TURN ON ALSO HIGH BEAM LIGHT SWITCH WOULD STAY ON AFTER FLASHING THEM. FRONT SUSPENSION SQUEAKS AND MAKES CLUNKING NOISE WHEN HITTING BUMPS. BELTS SQUEAK THEY ARE BRAND NEW LESS THAN 10000 MILE WITH IT ON. *JB
DT*: THE CONTACT STATED THE AIR BAG LIGHT CONTINUED TO ILLUMINATE WITHOUT PREVIOUS PROBLEMS WITH THE AIR BAGS. THE VEHICLE HAS NOT BEEN SEEN BY A DEALER OR REPAIR SHOP. *AK UPDATED 2/16/2006 - *NM
FRONT SWAY BAR BUSHINGS NEED REPLACING AT 28K. *JB
Official recalls
404V531000 · Equipment:electrical:radio/tape Deck/cd Etc.
Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V386000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Aug 5, 2004
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
01V310000 · Child Seat
Oct 4, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03012 · Power Steering Hose Failure
Opened Apr 9, 2003 · Closed May 29, 2003
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid; Steering:hydraulic Power Assist:pump; Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
Additional source detail variants (5)
Steering:hydraulic Power Assist:hose, Piping, And Connections
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:power Steering Fluid
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:pump
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist System
PLEASE SEE ATTACHED REPORT.
Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.