Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
250–25K
3425–50K
3150–75K
1875–100K
14100–150K
13150K+
135 reports with mileage · 122 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports3 fire reports12 injury reports
What owners actually said
257 reports
64,000 miles · Dec 22, 2008
Air Bags
TL*THE CONTACT OWNS A 2001 DODGE CARAVAN. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED THAT THE AIR BAG INDICATOR WAS ILLUMINATED. THROUGH RESEARCH, HE FOUND INFORMATION STATING THAT THE ILLUMINATION COULD RESULT IN THE DRIVER'S SIDE AIR BAG BECOMING DISABLED DUE TO FAILURE OF THE CLOCKSPRING BAG. THE CLOCKSPRING BA…
Read full complaint
TL*THE CONTACT OWNS A 2001 DODGE CARAVAN. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED THAT THE AIR BAG INDICATOR WAS ILLUMINATED. THROUGH RESEARCH, HE FOUND INFORMATION STATING THAT THE ILLUMINATION COULD RESULT IN THE DRIVER'S SIDE AIR BAG BECOMING DISABLED DUE TO FAILURE OF THE CLOCKSPRING BAG. THE CLOCKSPRING BAG WAS REPAIRED ON APRIL 21, 2003. THE CONTACT IS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER FOR INSPECTION PER THE MANUFACTURER'S ADVICE. THE MANUFACTURER STATED THAT THERE WAS NO RECALL ON THE AIR BAG SYSTEM IN THE VEHICLE. THE CONTACT WAS INFORMED THAT THERE WAS A CURRENT RECALL REGARDING THE CLOCKSPRING BAG; HOWEVER, HIS VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT WOULD NOT RECEIVE REIMBURSEMENT FOR THE REPAIR. THE FAILURE MILEAGE WAS 64,000 AND CURRENT MILEAGE WAS 65,000.
NHTSA ODI #10252513
81,000 miles · Dec 14, 2008
Visibility
IN 2006 THE DRIVERS SIDE WINDOW STOPPED WORKING. REPLACED THE MOTOR. NOVEMBER 2008 THE PASSENGER WINDOW STOPPED WORKING. WILL HAVE TO REPLACE THIS MOTOR AS WELL. *TR
NHTSA ODI #10251723
Mileage unknown · Nov 21, 2008
Electrical System
I HAVE A 2001 DODGE CARAVAN SE. BEGAN TO HAVE MALFUNCTIONS WITH BOTH FRONT WINDOWS IN 2004. I HAD THIS REPAIRED ALONG WITH SOME OTHER MAINTENANCE IN JULY OF THIS YEAR. THIS YEAR IN SEPT THE INSTRUMENT PANEL FLATLINED AS WELL AS THE TURN SIGNALS. THIS RESULTS IN LOSS OF FUEL GAUGE, SPEEDOMETER, RPM, ODOMETER, TEMP GAUGE AND TU…
Read full complaint
I HAVE A 2001 DODGE CARAVAN SE. BEGAN TO HAVE MALFUNCTIONS WITH BOTH FRONT WINDOWS IN 2004. I HAD THIS REPAIRED ALONG WITH SOME OTHER MAINTENANCE IN JULY OF THIS YEAR. THIS YEAR IN SEPT THE INSTRUMENT PANEL FLATLINED AS WELL AS THE TURN SIGNALS. THIS RESULTS IN LOSS OF FUEL GAUGE, SPEEDOMETER, RPM, ODOMETER, TEMP GAUGE AND TURNING SIGNALS. THEY WOULD OCCASIONALLY BEGIN TO FUNCTION AGAIN BUT HAVE ONLY DONE THIS ONCE OR TWICE OVER THE LAST 2 MONTHS. THE DEALER RECOMMENDS REPLACING THE ENTIRE INSTRUMENT CLUSTER AT A COST OF OVER $900. *TR
NHTSA ODI #10249476
Mileage unknown · Oct 22, 2008
Exterior Lighting
2001 DODGE CARAVAN HEADLIGHTS, REPLACED LEFT HEADLIGHT, WEEK LATER TURNED ON VAN AND ONE DAYLIGHT LIGHT CAME ON, TURNED ON HEADLIGHTS AND THE OPPOSITE LOW BEAM CAME ON, SWITCHED TO HIGH BEAM AND THE OPPOSITE HIGH BEAM CAME ON. I HAVE NOTICED FLICKERING LIGHTS IN THE PAST BOTH INSIDE AND OUTSIDE. DOES SOMEONE HAVE TO DIE AND HAVE…
Read full complaint
2001 DODGE CARAVAN HEADLIGHTS, REPLACED LEFT HEADLIGHT, WEEK LATER TURNED ON VAN AND ONE DAYLIGHT LIGHT CAME ON, TURNED ON HEADLIGHTS AND THE OPPOSITE LOW BEAM CAME ON, SWITCHED TO HIGH BEAM AND THE OPPOSITE HIGH BEAM CAME ON. I HAVE NOTICED FLICKERING LIGHTS IN THE PAST BOTH INSIDE AND OUTSIDE. DOES SOMEONE HAVE TO DIE AND HAVE A FAMILY MEMBER SUE BEFORE PROBLEM IS FIXED? *TR
NHTSA ODI #10246315
Mileage unknown · Oct 14, 2008
Exterior Lighting
I OWN A 2001 DODGE CARAVAN EQUIPPED WITH DAYTIME RUNNING LIGHTS. DURING OPERATION ONLY THE DRIVER SIDE DAYTIME RUNNING LIGHT COMES ON. WHEN HEADLIGHTS TURNED ON, ONLY PASSENGER SIDE HEADLIGHT COMES ON. ONLY ONE HEADLIGHT WORKS AT ANY TIME. NOT ENOUGH LIGHT TO SEE WHILE DRIVING. IT IS A CONSTANT. *TR
NHTSA ODI #10245385
105,559 miles · Sep 29, 2008
Exterior Lighting
HEADLAMP/PARKING LIGHT FAILURE - PARKING LIGHT WAS OUT AND CAR NEEDED INSPECTION FOR MASS. BROUGHT CAR IN FOR SERVICE AND ALL THE GARAGES ARE TELLING ME IT'S GOING TO COST BETWEEN $500-$700 FOR FIX A $1.50 PART. THE LIGHT WAS NEW AND THE DIRECTIONAL WORKED. LATER ON AS I WAS SEEKING MORE INFO AND HELP THE HEADLAMP WENT ON THE PA…
Read full complaint
HEADLAMP/PARKING LIGHT FAILURE - PARKING LIGHT WAS OUT AND CAR NEEDED INSPECTION FOR MASS. BROUGHT CAR IN FOR SERVICE AND ALL THE GARAGES ARE TELLING ME IT'S GOING TO COST BETWEEN $500-$700 FOR FIX A $1.50 PART. THE LIGHT WAS NEW AND THE DIRECTIONAL WORKED. LATER ON AS I WAS SEEKING MORE INFO AND HELP THE HEADLAMP WENT ON THE PASSENGER SIDE. THE HIGH BEAM COULD BE PUT ON BUT WOULD TURN OFF THE DRIVERS SIDE HEADLAMP/HIGH BEAM. PARKING LIGHT ON DRIVERS SIDE WOULD REMAIN ON AND DIRECTIONAL WORKED. *TR
NHTSA ODI #10243944
93,000 miles · Aug 4, 2008
Air Bags
2001 DODGE CARAVAN AIRBAG DASHBOARD LIGHT IS ON BAD "CLOCK SPRING" SAFETY ISSUE SAME ISSUE WAS FOUND ON OLDER MODELS OF DODGE CARAVANS THAT WERE PREVIOUSLY RECALLED. *TR
NHTSA ODI #10236890
162,000 miles · Jul 25, 2008
Tires
WARRANTY REFUSED. *TR
NHTSA ODI #10235735
67,000 miles · Mar 18, 2008
Steering
I HAVE A 2001 DODGE CARAVAN. FIRST NOTICED (A FEW MONTHS AGO) THE CRUISE CONTROL DID NOT WORK; THEN THE HORN WOULD WORK INTERMITTENTLY. NOW, THE HORN DOES NOT WORK AT ALL. HAD THE DEALER TROUBLESHOOT AND THEY SAID THE CLOCKSPRING IS FAULTY AND NEEDS TO BE REPLACED. I NOTICED THAT THERE HAD BEEN A RECALL TO REPLACE CLOCKSPRINGS I…
Read full complaint
I HAVE A 2001 DODGE CARAVAN. FIRST NOTICED (A FEW MONTHS AGO) THE CRUISE CONTROL DID NOT WORK; THEN THE HORN WOULD WORK INTERMITTENTLY. NOW, THE HORN DOES NOT WORK AT ALL. HAD THE DEALER TROUBLESHOOT AND THEY SAID THE CLOCKSPRING IS FAULTY AND NEEDS TO BE REPLACED. I NOTICED THAT THERE HAD BEEN A RECALL TO REPLACE CLOCKSPRINGS IN CARAVANS UP TO YEAR 2000. I ORDERED MY CARAVAN IN NOVEMBER, 2000 AND RECEIVED IT JANUARY, 2001. *TR
NHTSA ODI #10221603
160,000 miles · Mar 13, 2008
Fuel System, Other
HAD HAVE GAS TUBE REPLACED BECAUSE OF CORROSION. *TR
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
Consequence & remedy
Consequence: IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
2001 Dodge Caravan Problems, Complaints & Recalls | Skip That Year
Illustration