Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
3825–50K
5350–75K
4375–100K
44100–150K
25150K+
222 reports with mileage · 248 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
65 crash reports5 fire reports44 injury reports
What owners actually said
470 reports
Mileage unknown · Mar 5, 2002
Seat Belts
THE DRIVER OF THIS VEHICLE LOST CONTROL, CAUSING A ROLLOVER, ONE OF THE PASSENGERS WAS SITTING IN THE RIGHT HALF OF THE MIDDLE SEAT, THIS IS A DOUBLE SEAT WHICH DOES NOT EXTEND ALL THE WAY TO THE DOOR, THE SEATBELT FOR THE MIDDLE SEAT IS ANCHORED TO THE SIDE OF THE VEHICLE, NOT THE SEAT ITSELF, IN THIS CASE WHEN THE VEHICLE ROLL…
Read full complaint
THE DRIVER OF THIS VEHICLE LOST CONTROL, CAUSING A ROLLOVER, ONE OF THE PASSENGERS WAS SITTING IN THE RIGHT HALF OF THE MIDDLE SEAT, THIS IS A DOUBLE SEAT WHICH DOES NOT EXTEND ALL THE WAY TO THE DOOR, THE SEATBELT FOR THE MIDDLE SEAT IS ANCHORED TO THE SIDE OF THE VEHICLE, NOT THE SEAT ITSELF, IN THIS CASE WHEN THE VEHICLE ROLLED OVER, THE DOOR OPENED AND THE VICTIM WAS EJECTED FROM THE VEHICLE AND WAS KILLED, THIS LETTER IS FROM THE CHAIRMAN OF THE PIMA COUNTY CHILD FATALITY REVIEW TEAM, THE OWNER OF THE VEHICLE IS CARTEMPS/ALAMO RENT A CAR, THE DRIVER AT THE TIME OF THE ACCIDENT IS UNKNOWN. *SLC
NHTSA ODI #564588
Mileage unknown · Mar 4, 2002
Power Train
UPON PLACING VEHICLE IN DRIVE AND WITHOUT WARNING VEHICLE WILL STALL, THEN JERK INTO FORWARD MOTION. ALL OTHER GEAR FUNCTION CORRECTLY, EXCLUDING DRIVE GEAR.*AK
NHTSA ODI #8004885
Mileage unknown · Feb 13, 2002
Air BagsEngine And Engine CoolingEquipment
CONSUMER STATED THERE IS A KNOCKING NOISE IN THE STEERING WHEN TURNING HARD AND WHEN TURNING AND NOT MOVING, CONSUMER ALSO COMPLAINED THAT THERE IS VIBRATION IN THE STEEING, DEALER BALANCED FRONT TIRES FROM A PREVIOUS COMPLAINT ABOUT THE STEERING.*JB
NHTSA ODI #564273
Mileage unknown · Feb 11, 2002
Power Train
WHILE DRIVING, CONSUMER HEARD A LOUD NOISE AND VEHICLE WOULD NOT PULL. TOOK TO DEALER, AND DEALER INDICATED DIFFERENTIAL PIN BROKE IN TRANSMISSION.*AK CHRYSLER PAID FOR HALF OF THE BILL. *JB
NHTSA ODI #8003897
Mileage unknown · Feb 7, 2002
Power Train
THE TRANSMISSION HAD TO BE REPLACED WHICH DOES NOT SEEM RIGHT WHEN IT IS ONLY 2 YRS OLD WITH ONLY 47000. *AK
NHTSA ODI #757930
Mileage unknown · Feb 5, 2002
Engine And Engine CoolingEquipment
WHILE PARKING VEHICLE HEARD A BANGING NOISE FROM ENGINE. THEN, FELT THAT ENGINE DID NOT WORK, TOWED VEHICLE TO A MECHANIC, WHO FOUND OUT THAT RETAINER BOLT OF PULLEY, TENSIONER AND SERPENTINE BELT WERE BROKEN. *AK
NHTSA ODI #8003614
Mileage unknown · Jan 22, 2002
Power Train
WHILE DRIVING,THE TRANSMISSION INDICATOR LIGHT BEGAN FLASHING, SOON AFTER THE VEHICLE WOULD NOT SHIFT TO HIGHER GEARS. DEALER HAS BEEN NOTIFIED.*AK *SLC
NHTSA ODI #8002561
Mileage unknown · Jan 20, 2002
SeatsCrashInjury
IN A RECENT REAR-END ACCIDENT, THE BACK OF THE DRIVER AND PASSENGER SEATS COLLAPSED ALLOWING ME TO BE THROWN BACKWARD FROM MY SEAT ALTHOUGH I WAS WEARING MY SEAT BELT. I RECEIVED MANY CUTS, BRUISES AND ABRASIONS TO MY LEFT HAND THAT REQUIRED 64 STITCHES, AND THE REPAIR OF 2 LACERATED TENDONS. I ALSO RECEIVED SEVERAL SCRATCHES …
Read full complaint
IN A RECENT REAR-END ACCIDENT, THE BACK OF THE DRIVER AND PASSENGER SEATS COLLAPSED ALLOWING ME TO BE THROWN BACKWARD FROM MY SEAT ALTHOUGH I WAS WEARING MY SEAT BELT. I RECEIVED MANY CUTS, BRUISES AND ABRASIONS TO MY LEFT HAND THAT REQUIRED 64 STITCHES, AND THE REPAIR OF 2 LACERATED TENDONS. I ALSO RECEIVED SEVERAL SCRATCHES ON AND NEAR MY LEFT ELBOW. MY SON RECEIVED A SPRAINED RIGHT WRIST, BRUISED STOMACH, SORE NECK AND BACK. I HAVE HAD TROUBLE SLEEPING AND CONTINUE TO HAVE VIVID MEMORIES OF THE ACCIDENT. I HAVE HAD NO USE OF MY LEFT HAND AND AM IN CONTINUOUS PAIN, UNLESS I'M HEAVILY MEDICATED. I HAVE BEEN UNABLE TO BATHE, DRESS, WASH MY HAIR, OR PREPARE MEALS AND PERFORM OTHER HOUSEHOLD DUTIES WITHOUT HELP. I AM CURRENTLY USING MY FATHER'S CAR BECAUSE MY CARAVAN WAS MY ONLY MEANS OF TRANSPORTATION.*AK
NHTSA ODI #757105
Mileage unknown · Jan 14, 2002
Power Train
VEHICLE DOES NOT HAVE SAFETY TRANSMISSION LOCK IN PARK, PULLS OUT OF PARK WITHOUT PUTTING THE BRAKE ON. *JG
NHTSA ODI #785843
Mileage unknown · Jan 11, 2002
Service Brakes, Hydraulic
WHILE APPLYING BRAKES TO SLOW DOWN, CONSUMER COULD SMELL RUBBER BURNING. HAD CONTACTED DEALERSHIP ABOUT PROBLEM. *AK *JB
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2000 Dodge Caravan Problems, Complaints & Recalls | Skip That Year
Illustration