IllustrationCONSUMER STATES THAT THE BRAKES ON THE VEHICLE ARE NOT WORKING PROPERLY. THE BRAKE PADS HAVE WORNED DOWN TO THE POINT WHERE IT IS METAL AGAINST METAL. CONTACTED DEALER THREE TIMES ALREADY AND THE DEALER HAS TRIED TO REMEDY THE PROBLEM BUT WITHOUT ANY SUCCESS. *MR
2000 Dodge Caravan
Owner reports · Recalls · Investigations
More warning signs than most Caravan years
Owner complaints for the 2000 Dodge Caravan are substantially higher than the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
3825–50K
5350–75K
4375–100K
44100–150K
25150K+
222 reports with mileage · 248 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
65 crash reports5 fire reports44 injury reports
What owners actually said
470 reportsCONSUMER STATES WHILE DRIVING 55MPH HIT A CAR BRODESIDE AND AIR BAG DID NOT DEPLOY. CAUSING SERIOUS INJURIES.
CONSUMER STATES THAT DURING BRAKING THE VEHICLE WOULD VIBRATE AND RUMBLE AND THE STEERING WHEEL WOULD SHAKE. DEALER NOTIFIED AND REPLACE FRONT BRAKE ROTORS AND PADS AND THE CONDITION HAS REOCCUR. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. NLM
THE VEHICLE NEEDED RESHIMING AND BOLT KITS FOR THE FRONT WHEELS AT 20000 MILES. (CONSUMER NO LONGER OWNES VEHICLE) *YH
WHILE DRIVING 65 MPH VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE AND LOST CONTROL.*AK. CONSUMER COULD SMELL THE BRAKES AS THEY BECAME HOT. THE BRAKE LIGHTS ILLUMINATE AND THERE IS POOR BRAKE RESPONSE. CONSUMER STATED THE VEHICLE WAS LEAKING TRANSMISSION FLUID, THE AIR CONDITIONER WAS MAKING A HOWLING NOISE, THE BRAKE BOOSTE…
Read full complaint
WHILE DRIVING 65 MPH VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE AND LOST CONTROL.*AK. CONSUMER COULD SMELL THE BRAKES AS THEY BECAME HOT. THE BRAKE LIGHTS ILLUMINATE AND THERE IS POOR BRAKE RESPONSE. CONSUMER STATED THE VEHICLE WAS LEAKING TRANSMISSION FLUID, THE AIR CONDITIONER WAS MAKING A HOWLING NOISE, THE BRAKE BOOSTER WAS REPLACED. *JG
THE AIR BAG LIGHT CAME ON AND THE HORN AND CRUISE CONTROL STOPPED WORKING ON 18 JULY 2002. REPAIRS WERE DELAYED UNTIL I HAD $224 TO PAY THE DEALER TO REPLACE THE CLOCKSPRING ON 8 AUGUST 2002. TECHNICAL SERVICE BULLETIN NUMBER 0801001, NHTSA NUMBER 620059 AND ENGINEERING ANALYSIS EA01-007 DESCRIBE THIS PROBLEM WITH THIS VEHICLE…
Read full complaint
THE AIR BAG LIGHT CAME ON AND THE HORN AND CRUISE CONTROL STOPPED WORKING ON 18 JULY 2002. REPAIRS WERE DELAYED UNTIL I HAD $224 TO PAY THE DEALER TO REPLACE THE CLOCKSPRING ON 8 AUGUST 2002. TECHNICAL SERVICE BULLETIN NUMBER 0801001, NHTSA NUMBER 620059 AND ENGINEERING ANALYSIS EA01-007 DESCRIBE THIS PROBLEM WITH THIS VEHICLE. RECALL NUMBER 01V153 DESCRIBES THIS PROBLEM WITH ANOTHER DODGE TRUCK. ALL MECHANICS CONTACTED KNEW IMMEDIATELY WHY ALL STEERING WHEEL WIRING STOPPED WORKING AT THE SAME TIME. THIS IS A COMMON PROBLEM THAT SHOULD RESULT IN A RECALL.*AK
AS OF THIS DATE THIS IS THE THIRD TIME IN THIRTEEN MONTHS THAT THIS CAR HAS BEEN IN THE SHOP FOR THE SAME PROBLEM NEED LESS TO SAY THAT IT SEEMS TO HAPPEN ON A FRIDAY NIGHT EVERYTIME AND THEY CAN'T GET TO IT TILL MONDAY.NO SAFETY DEFECT LISTED. *AK
CONSUMER STATED THE TRANSMISSION FAILED.TS *JB
WHILE DRIVING 25 MPH CONSUMER'S VEHICLE WAS HIT FROM BEHIND AND FRONT SEATS WENT IN A RECLINING POSITION ,CAUSING INJURIES.*AK
WE WERE RECENTLY REAR-ENDED BY ANOTHER VEHICLE TWICE, AND BOTH FRONT SEATS COMPLETELY BROKE, AND CAUSES SERIOUS INJURIES TO RIDER (TRAMATIC CONCUSSION, HEAD AND NECK INJURIES), INJURY TO DRIVERS BACK, NECK & HEAD....RIDERSIDE ALSO RECEIVED TERRIBLE TWITCHING IN RIGHT HAND AND ARM, AND LOSS OF USE OF RIGHT LEG...THIS IS A SERIOUS…
Read full complaint
WE WERE RECENTLY REAR-ENDED BY ANOTHER VEHICLE TWICE, AND BOTH FRONT SEATS COMPLETELY BROKE, AND CAUSES SERIOUS INJURIES TO RIDER (TRAMATIC CONCUSSION, HEAD AND NECK INJURIES), INJURY TO DRIVERS BACK, NECK & HEAD....RIDERSIDE ALSO RECEIVED TERRIBLE TWITCHING IN RIGHT HAND AND ARM, AND LOSS OF USE OF RIGHT LEG...THIS IS A SERIOUS DEFECT FOR FRONT SEATS...THEY COMPLETELY BROKE AFTER THROWING US BACKWARDS....THE DRIVERS SEAT COULD NOT BE REMOVED OFF OF SECOND SEAT...IT WAS STUCK IN RECLINGING POSITION! IF OUR CHILDREN HAD BEEN IN THE CAR WITH US, IT WOULD HAVE CAUSED SERIOUS INJURIES TO THEIR LEGS, PROBABLY WOULD HAVE CRUSHED THEM!!! ALSO, OUR INSURANCE COMPANY ONLY WANTS TO GIVE US USED SEATS FROM ANOTHER CRASH AND PUT OUR MATERIAL OVER THEM AND INSTALL THEM INTO OUR VAN!! THIS IS TOITALLY REDICULOUS!!! IFG OURS BROKE, THEN ANOTHER VANS SEATS COULD ALSO BE WEAKEND BY A CRASH, AND THEN WE COULD POSSIBLE BE KILLED IF WE SHOULD EVER BE STRUCK AGAIN!!!! WE WANT TO FILE A FORMAL COMPLAINT TO ALL PARTIES INVOLVED WITH THE DODGE FRONT SEATS!!!*AK
Official recalls
404V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V505000 · Equipment:other:labels
Dec 10, 2003
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available