Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
21,000 miles · Jun 22, 2009
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2003 DAMON DAYBREAK RV. WHILE DRIVING 60 MPH, THE BRAKES FAILED WHEN THE PEDAL WAS DEPRESSED. THE CONTACT HAD TO DOWNSHIFT THE RV AND USE THE BRAKES IN THE VEHICLE THAT WAS BEING TOWED. HE HAS NOT DRIVEN THE VEHICLE SINCE THAT TIME. THE DEALER EXPLAINED THAT THE BRAKE LINE WAS TOO CLOSE TO THE FRAME. A…
Read full complaint
TL*THE CONTACT OWNS A 2003 DAMON DAYBREAK RV. WHILE DRIVING 60 MPH, THE BRAKES FAILED WHEN THE PEDAL WAS DEPRESSED. THE CONTACT HAD TO DOWNSHIFT THE RV AND USE THE BRAKES IN THE VEHICLE THAT WAS BEING TOWED. HE HAS NOT DRIVEN THE VEHICLE SINCE THAT TIME. THE DEALER EXPLAINED THAT THE BRAKE LINE WAS TOO CLOSE TO THE FRAME. AS A RESULT, WATER ACCUMULATED AND RUSTED OUT THE BRAKE LINE, WHICH CAUSED A HOLE IN THE LINE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 21,000 AND CURRENT MILEAGE WAS 23,000.
MOTORHOME TAKEN TO REPAIR FACILITY 11/18/02. BRAKES MUSHY & BRAKE PEDAL GOES ALL THE WAY DOWN TO FLOOR WHEN BRAKING. MASTER CYLINDER HAD TO BE REPLACED WITH 3,403 MILES ON NEW VEHICLE. MECHANICS FOUND NUT MISSING FROM SWAY BAR & REPLACED. MECHANICS ALSO FOUND NO GROUND STRAP ON GAS TANK INSTALLED SAME. AFTER REPEATED COMPLA…
Read full complaint
MOTORHOME TAKEN TO REPAIR FACILITY 11/18/02. BRAKES MUSHY & BRAKE PEDAL GOES ALL THE WAY DOWN TO FLOOR WHEN BRAKING. MASTER CYLINDER HAD TO BE REPLACED WITH 3,403 MILES ON NEW VEHICLE. MECHANICS FOUND NUT MISSING FROM SWAY BAR & REPLACED. MECHANICS ALSO FOUND NO GROUND STRAP ON GAS TANK INSTALLED SAME. AFTER REPEATED COMPLAINTS ABOUT UNIT PULLING TO LEFT & SPOKE ON STEERING WHEEL CROOKED, FRONT END ALIGNED 10/8/02 WITH 3,319 MILES ON NEW VEHICLE. DT
CERTAIN TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: DAMON WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR DAMON AT 1-800-860-3812.
CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, "CONTROLS AND DISPLAYS" AND NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELLTALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.
Consequence & remedy
Consequence: AT NIGHT THE INSTRUMENT CLUSTER LIGHTS MAY FAIL AND THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES AND THE BRAKE WARNING LIGHT INDICATOR WHICH COULD INCREASING THE RISK OF A CRASH.
Remedy: DAMON IS WORKING WITH WORKHORSE TO CONTACT THE OWNERS AND REMEDY THIS CAMPAIGN . WORKHORSE WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR DAMON AT 1-800-860-3812.
CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
Consequence & remedy
Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Remedy: DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION IS BEGAN MAY 12, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAMON AT 1-219-272-9212.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 Damon Daybreak Problems, Complaints & Recalls | Skip That Year
Illustration