Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Visibility. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reports
18,400 miles · Jul 23, 2010
Visibility
TL*THE CONTACT OWNS A 2006 DAMON DAYBREAK RV. THE CONTACT STATED THAT WHILE DRIVING SHE HEARD AN EXCESSIVE AMOUNT NOISE IN THE VEHICLE. THE DEALER STATED THAT THE NOISE WAS CAUSED BY THE TELEVISION BECAUSE IT WAS NOT BOLTED DOWN. THE DEALER WAS CONTACTED AGAIN AND DISCOVERED THAT THE FRONT WINDSHIELD WAS LOOSE AND THAT WAS THE …
Read full complaint
TL*THE CONTACT OWNS A 2006 DAMON DAYBREAK RV. THE CONTACT STATED THAT WHILE DRIVING SHE HEARD AN EXCESSIVE AMOUNT NOISE IN THE VEHICLE. THE DEALER STATED THAT THE NOISE WAS CAUSED BY THE TELEVISION BECAUSE IT WAS NOT BOLTED DOWN. THE DEALER WAS CONTACTED AGAIN AND DISCOVERED THAT THE FRONT WINDSHIELD WAS LOOSE AND THAT WAS THE REASON FOR THE NOISE. A WINDSHIELD MECHANIC STATED THAT THE WINDOW HAD MOVED THREE QUARTERS OF AN INCH AND THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS CURRENTLY BEING REPAIRED BY THE DEALER. DAMON WAS NOT NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 18,400.
DAMON IS RECALLING 43 MY 2006-2009 DAYBREAK AND MY 2009 DAYBREAK SPORT MOTOR HOMES BUILT ON WORKHORSE RECREATIONAL VEHICLE CHASSIS. THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM MAY HAVE BEEN IMPROPERLY TORQUED DURING ASSEMBLY. THE IMPROPER TORQUE MAY HAVE DAMAGED THE CASTLE NUT AND COMPROMISED THE INTEGRITY OF THE CONNECTION.
Consequence & remedy
Consequence: IF THE DRAG LINK WERE TO SEPARATE FROM THE PITMAN ARM, THE DRIVER WOULD NOT HAVE DIRECTIONAL CONTROL OF THE VEHICLE POSSIBLY CAUSING A CRASH.
Remedy: DAMON IS WORKING WITH WORKHORSE TO REPLACE AND PROPERLY TIGHTEN THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM (PLEASE SEE 08V442). OWNERS MAY CONTACT WORKHORSE AT 1-877-946-7731 OR DAMON AT 1-800-860-3812.
DAMON IS RECALLING 4,677 MY 2004-2006 CHALLENGER, DAYBREAK, INTRUDER, MY 2004-2005 ESCAPER, ULTRASPORT, AND MY 2005 ASTORIA AND ASTORIA WALDORF MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: DAMON WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR DAMON AT
ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.
Consequence & remedy
Consequence: IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.
Remedy: CHEVROLET AND WORKHORSE ARE HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225 AND 06V289). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, WORKHORSE AT 877-294-6773, OR DAMON AT 1-574-264-5517.
ON CERTAIN CLASS A MOTOR HOMES, SOME HYDRAULIC LINES FOR THE LEVELING JACK SYSTEM MAY BE IMPROPERLY SECURED OR ROUTED TOO CLOSE TO A DRIVE TRAIN HEAT SOURCE.
Consequence & remedy
Consequence: THIS MAY CAUSE MELTING OF THE HYDRAULIC LINE RESULTING IN LEAKAGE OF HYDRAULIC FLUID, WHICH COULD CAUSE A FIRE.
Remedy: DAMON WILL INSPECT AND SECURE THE CLEARANCE OF THE HYDRAULIC LEVELING HOSE THAT MAY BE TOO CLOSE TO HEAT SOURCES. THE RECALL BEGAN ON SEPTEMBER 25, 2006. OWNERS MAY CONTACT DAMON AT 1-800-860-3812.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2006 Damon Daybreak Problems, Complaints & Recalls | Skip That Year
Illustration