Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 5 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
5 reports
46,400 miles · May 17, 2010
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2000 DAMON DAYBREAK MOTOR HOME. THE CONTACT STATED THAT THE BRAKE CALIPER WAS OVERHEATING WHICH CAUSED THE BRAKE PADS TO BECOME SPONGY AND THE BRAKE FLUID TO OVERHEAT. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED AT THE TIME OF THE COMPLAINT. THE CONTACT STATED THAT THERE WAS A RECALL FOR THE NEXT YEAR MO…
Read full complaint
TL*THE CONTACT OWNS A 2000 DAMON DAYBREAK MOTOR HOME. THE CONTACT STATED THAT THE BRAKE CALIPER WAS OVERHEATING WHICH CAUSED THE BRAKE PADS TO BECOME SPONGY AND THE BRAKE FLUID TO OVERHEAT. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED AT THE TIME OF THE COMPLAINT. THE CONTACT STATED THAT THERE WAS A RECALL FOR THE NEXT YEAR MODEL RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 46,400. UPDATED 7/16/10 *CN UPDATED 07/22/10*JB
NHTSA ODI #10330868
33,000 miles · Nov 23, 2009
Service Brakes, Hydraulic
BRAKES OVERHEAT IN HEAVY TRAFFIC AND LOSE STOPPING POWER. THEY WEAR PREMATURELY. I REPLACED THEM AT 30000 MILES. 3000 MILES LATER PROBLEM HAS RETURNED. MOST RECENTLY OCCURRED LAST WEEK WHEN I TOTALLY LOST BRAKING ABILITY AFTER ABOUT AN HOUR OF RUSH HOUR TRAFFIC. *TR
NHTSA ODI #10293324
21,900 miles · Aug 18, 2009
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2000 DAMON DAYBREAK MOTOR HOME WITH A WORKHORSE P32 BRAKING SYSTEM. WHILE DRIVING 45 MPH HE APPROACHED A RED LIGHT AND ATTEMPTED TO ENGAGE THE BRAKE PEDAL WHICH EXTENDED TO THE FLOOR AND FAILED TO STOP THE VEHICLE. IF THE TRAFFIC LIGHT DID NOT CHANGE TO GREEN IT COULD HAVE CAUSED A CRASH. THE VEHICLE BEGAN …
Read full complaint
TL*THE CONTACT OWNS A 2000 DAMON DAYBREAK MOTOR HOME WITH A WORKHORSE P32 BRAKING SYSTEM. WHILE DRIVING 45 MPH HE APPROACHED A RED LIGHT AND ATTEMPTED TO ENGAGE THE BRAKE PEDAL WHICH EXTENDED TO THE FLOOR AND FAILED TO STOP THE VEHICLE. IF THE TRAFFIC LIGHT DID NOT CHANGE TO GREEN IT COULD HAVE CAUSED A CRASH. THE VEHICLE BEGAN TO LOSE SPEED EVEN AFTER HE ATTEMPTED TO ENGAGE THE BRAKE PEDAL. AFTER APPLYING EXTREME FORCE TO THE BRAKE PEDAL, THE CONTACT WAS ABLE TO STOP THE VEHICLE AND DRIVE TO A LOCAL REPAIR FACILITY. THE MECHANIC STATED THAT THE RIGHT FRONT AND RIGHT REAR CALIPER WERE FROZEN WHICH CAUSED THE BREAKS TO OVER HEAT, THE BRAKE FLUIDS TO BOIL AND CAUSED HIM TO LOSE THE ABILITY TO STOP THE VEHICLE. THE TWO RIGHT FRONT AND REAR BRAKE CALIPERS, ROTORS AND HOSES WERE REPLACED. THE CONTACT WAS ADVISED THAT THE FAILURE IS COMMON ON WORK HORSE TRAILERS. NHTSA CAMPAIGN ID NUMBER: 09V110000 EA07016 NHTSA ACTION NUMBER: EA07016 COMPONENT: SERVICE BRAKES, HYDRAULIC) IS RELATED TO THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 21,900. UPDATED 09/18/09. *LJ UPDATED 09/21/09. *JB
NHTSA ODI #10280808
17,000 miles · Feb 12, 2008
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2000 DAMON DAYBREAK. WHILE DRIVING APPROXIMATELY 35 MPH IN DRY WEATHER, THE BRAKES FAILED. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE LESS 17,000. UPDATED 03-04-08 *BF
NHTSA ODI #10217835
20,000 miles · May 9, 2006
Service Brakes, Hydraulic
DT*: THE CONTACT STATED WHILE DRIVING 25MPH ON LEVEL ROADS THE BRAKES WERE APPLIED SEVERAL TIMES BEFORE THE VEHICLE STOPPED. THE PARKING BRAKE LIGHT ILLUMINATED AFTER THE FAILURE. THE BRAKES RESUMED NORMAL OPERATION ONCE THE VEHICLE WAS PARKED FOR AN HOUR. THE BRAKES FAILED PREVIOUSLY IN OCTOBER 2005. THE MANUFACTURER AND D…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 25MPH ON LEVEL ROADS THE BRAKES WERE APPLIED SEVERAL TIMES BEFORE THE VEHICLE STOPPED. THE PARKING BRAKE LIGHT ILLUMINATED AFTER THE FAILURE. THE BRAKES RESUMED NORMAL OPERATION ONCE THE VEHICLE WAS PARKED FOR AN HOUR. THE BRAKES FAILED PREVIOUSLY IN OCTOBER 2005. THE MANUFACTURER AND DEALER WERE NOT ALERTED FOLLOWING EITHER INCIDENT. UPDATED 05/23/06. *JB
CERTAIN TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: DAMON WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR DAMON AT 1-800-860-3812.
VEHICLE DESCRIPTION: CERTAIN MOTOR HOMES BUILT ON DODGE VAN CHASSIS AND EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE BETWEEN JANUARY 28 AND AUGUST 15, 2000. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
Consequence & remedy
Consequence: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.
Remedy: AM-SAFE NOTIFIED DAMON'S CUSTOMERS TO RETURN THEIR VEHICLE TO AN AUTHORIZED DEALER TO HAVE THE SEAT BELTS REPAIRED FREE OF CHARGE.
VEHICLE DESCRIPTION: MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS N841, N821, N641, AND N621. THESE REFRIGERATORS CAN EXPERIENCE A COOLING SYSTEM LEAK CAUSED BY OPERATION IN THE AC ELECTRIC MODE. IF A LEAK OCCURS, THE COOLING PERFORMANCE OF THE REFRIGERATOR WILL DETERIORATE, REQUIRING IMMEDIATE REPLACEMENT OF THE COOLING UNIT.
Consequence & remedy
Consequence: EXTENDED OPERATION OF A LEAKING COOLING UNIT IN THE AC ELECTRIC MODE CAN RESULT IN A FIRE.
Remedy: NORCOLD WILL INSPECT AND REPLACE THE REFRIGERATOR COOLING UNITS. NORCOLD WILL CONDUCT THE OWNER NOTIFICATION. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NORCOLD SERVICE CENTER AT 1-800-767-9101 OR DAMON AT 1-937-497-3080.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2000 Damon Daybreak Problems, Complaints & Recalls | Skip That Year
Illustration