Engine And Engine CoolingFuel System, OtherService Brakes, Hydraulic
NAR 06/19/2003. *MR SOON AFTER THE CONSUMER PURCHASED THE VEHICLE HE NOTICED THE PARKING BRAKE DID NOT WORK. THE VEHICLEH HAD A FLAT TIRE BEFORE ENTERING THE INTERSTATE. THE CAR WAS TAKEN TO THE SERVICE DEALER TO HAVE THE BRAKES REPAIRED, BUT IT WAS EVIDENT THAT THE PARKING BRAKE WAS DEFECTIVE. ALONG WITH THE PARKING BRAKES…
Read full complaint
NAR 06/19/2003. *MR SOON AFTER THE CONSUMER PURCHASED THE VEHICLE HE NOTICED THE PARKING BRAKE DID NOT WORK. THE VEHICLEH HAD A FLAT TIRE BEFORE ENTERING THE INTERSTATE. THE CAR WAS TAKEN TO THE SERVICE DEALER TO HAVE THE BRAKES REPAIRED, BUT IT WAS EVIDENT THAT THE PARKING BRAKE WAS DEFECTIVE. ALONG WITH THE PARKING BRAKES SEVERAL OTHER PROBLEMS EXISTED WITH THE VEHICLE. A BELT TENSIONER AND TUNE UP WAS NEEDED. THERE WERE TWO RECALLS WERE ISSUED FOR THE FUEL RAILS AND CLOCKS SPRINGS. HOWEVER THE DEALERSHIP FAILED TO RECOGNIZE OTHER MALFUNCTIONS LIKE THE PARKING BRAKES IN WHICH THE CONSUMER FELT A RECALL NEEDED TO BE ISSUED. PLEASE INVESTIGATE AND GIVE PROMPT RESPONSE. *CB THE CONSUMER WAS TOLD THE REASON THE PARKING NRAKE DID NOT WORK WAS BECAUSE THE VEHICLE NEEDED DISC PADS, BRAKE SHOES ROTORS AND DRUMS BECAUSE THEY WERE GLAZED AND COULD NOT BE RESURFACED. THE FUEL INJECTOR AND THROTTLE BODY NEEDED TO CLEANED. *JB
NHTSA ODI #10024448
Mileage unknown · Aug 14, 2002
Tires
FIRESTONE, DAYTONA RADIAL A/S, P225/60R16; WHILE DRIVING 65MPH FRONT LEFT TIRE HAD TREAD SEPARATION, AND RIGHT FRONT HAD TREAD SEPARATION.*AK 2 FRONT TIRES DOT NUMBER VDXO DCB 269, REAR DRIVER SIDE VDXO-DCB269 AND REAR PASSENGER SIDE VDXO_DCB 399
NHTSA ODI #8016364
Mileage unknown · Oct 3, 2001
Tires
FIRESTONE, DOT HJHBCLH209, P21565R16; WHILE TRAVELING AT 65-70 MPH VEHICLE STARTED TO PULL AND VIBRATE, UPON INSPECTION THE CONSUMER NOTICED THAT A TREAD HAD SEPARATED.*AKALL FOUR TIRES WERE INSPECTED BEFORE TRIP AND CHECKED AGAIN THE DAY AFTER THE INCIDENT, THE OTHER THREE TIRES WERE FOUND TO BE THE SAME PRESSURE (38PSI). *N…
Read full complaint
FIRESTONE, DOT HJHBCLH209, P21565R16; WHILE TRAVELING AT 65-70 MPH VEHICLE STARTED TO PULL AND VIBRATE, UPON INSPECTION THE CONSUMER NOTICED THAT A TREAD HAD SEPARATED.*AKALL FOUR TIRES WERE INSPECTED BEFORE TRIP AND CHECKED AGAIN THE DAY AFTER THE INCIDENT, THE OTHER THREE TIRES WERE FOUND TO BE THE SAME PRESSURE (38PSI). *NLM
NHTSA ODI #897280
Mileage unknown · Aug 28, 2000
Tires
CONSUMER WAS TRAVELING ABOUT 70MPH ON HIGHWAY AND HEARD A THUMBING AND BANGING NOISE. BECAUSE IT WAS HITTING UP AGAINST THE UNDERCARRIAGE OF VEHICLE, LEFT REAR TIRE SEPARATED. MICHELIN TIRES, P215-65-R15, AND THERE WERE NO INJURIES.*AK
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
THE MASTER CYLINDER REAR SEAL, BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY ALLOWING HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR.
Consequence & remedy
Consequence: AS THE HYDRAULIC FLUID IN THE MASTER CYLINDER RESERVOIR DECREASES, THE LEVEL SENSOR WILL DETECT THE LOSS OF FLUID AND ILLUMINATE THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED CAN RESULT IN EXTENDED STOPPING DISTANCES.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER ON ALL AFFECTED VEHICLES. ADDENDUM (4-14-97): VEHICLES INSPECTED PER CHRYSLER RECALL NO. 707 AND FOUND TO BE OUTSIDE THE LISTED SUSPECT MASTER CYLINDER DATE CODE RANGE, MUST NOW HAVE THE MASTER CYLINDER PRIMARY PISTON REPLACED (CHRYSLER RECALL NO. 714).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
1997 Chrysler Town And Country Problems, Complaints & Recalls | Skip That Year
Illustration