TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER EQUIPPED WITH GOODYEAR EAGLE LS TIRES, SIZE P205/55/R16. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE SHOOK VIOLENTLY. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED A BUBBLE HAD DEVELOPED ON THE PASSENGER FRONT TIRE TREAD. THE VEHICLE WAS TAKEN TO A DEALER WHO STAT…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER EQUIPPED WITH GOODYEAR EAGLE LS TIRES, SIZE P205/55/R16. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE SHOOK VIOLENTLY. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED A BUBBLE HAD DEVELOPED ON THE PASSENGER FRONT TIRE TREAD. THE VEHICLE WAS TAKEN TO A DEALER WHO STATED THAT THE FRONT PASSENGER SIDE TIRE TREAD BELT WAS SEPARATING AND NEEDED TO BE REPLACED. THE TWO FRONT TIRES WERE REPLACED. THE FAILURE MILEAGE WAS 30,000 AND THE VEHICLE FAILURE MILEAGE WAS 90,825.
NHTSA ODI #10595888
117,000 miles · May 1, 2012
Tires
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER EQUIPPED WITH GOODYEAR EAGLE LS-2 TIRES. THE CONTACT STATED THAT THE DRIVER WAS TRAVELING 65 MPH WHEN THE FRONT PASSENGER TIRE BLEW. THE CONTACT PURCHASED NEW TIRES AND REPLACED BOTH FRONT TIRES. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED. THE CONTACT STATED THAT THE B…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER EQUIPPED WITH GOODYEAR EAGLE LS-2 TIRES. THE CONTACT STATED THAT THE DRIVER WAS TRAVELING 65 MPH WHEN THE FRONT PASSENGER TIRE BLEW. THE CONTACT PURCHASED NEW TIRES AND REPLACED BOTH FRONT TIRES. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED. THE CONTACT STATED THAT THE BLOW OUT OCCURRED ALONG THE OUTER SIDEWALL. THE MANUFACTURER OF THE TIRES WERE NOT NOTIFIED. THE FAILURE MILEAGE ON THE TIRES WAS 17,000. THE VEHICLE FAILURE MILEAGE WAS 117,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10457058
46,032 miles · May 28, 2010
Tires
BRIDGESTONE, FUZION HRI, TIRES CAN ONLY BE MOUNTED ONE WAY WITH LEFT (DRIVERS SIDE ) BEAD/TREAD POINTING >, BUT PASSENGER ( RIGHT SIDE ) TIRES CAN ONLY BE MOUNTED WITH BEAD/TREAD POINTING <, THIS LEADS TO RIGHT SIDE TIRE FAILURE; AND VEHICLE HANDLING ON WET ROADS PULLS TO RIGHT; WHEN HITTING PUDDLE AT 55 MPH JERKS CAR TO RIGHT …
Read full complaint
BRIDGESTONE, FUZION HRI, TIRES CAN ONLY BE MOUNTED ONE WAY WITH LEFT (DRIVERS SIDE ) BEAD/TREAD POINTING >, BUT PASSENGER ( RIGHT SIDE ) TIRES CAN ONLY BE MOUNTED WITH BEAD/TREAD POINTING <, THIS LEADS TO RIGHT SIDE TIRE FAILURE; AND VEHICLE HANDLING ON WET ROADS PULLS TO RIGHT; WHEN HITTING PUDDLE AT 55 MPH JERKS CAR TO RIGHT CAUSING LOSS OF CONTROL AND ACCIDENT. *TR
NHTSA ODI #10332602
31,291 miles · Jul 23, 2008
Tires
ON DECEMBER 2, 2007 MY RIGHT FRONT TIRE BLEW APART. AFTER GETTING TIRE CHANGED I WENT TO WALMART AND BOUGHT A NEW TIRE. ON JULY 22, 2008 THE SAME KIND OF TIRE AGAIN HAD A PROBLEM WITH A DEFECTIVE BELT AND HAD TO BE REPLACED AGAIN. THE TIRE WAS A GOODYEAR VIVA 2 P195/65R15BW VIVA 2. FORTUNATELY I WAS ABLE TO DRIVE SAFELY TO …
Read full complaint
ON DECEMBER 2, 2007 MY RIGHT FRONT TIRE BLEW APART. AFTER GETTING TIRE CHANGED I WENT TO WALMART AND BOUGHT A NEW TIRE. ON JULY 22, 2008 THE SAME KIND OF TIRE AGAIN HAD A PROBLEM WITH A DEFECTIVE BELT AND HAD TO BE REPLACED AGAIN. THE TIRE WAS A GOODYEAR VIVA 2 P195/65R15BW VIVA 2. FORTUNATELY I WAS ABLE TO DRIVE SAFELY TO A PLACE TO HAVE THE TIRE CHANGED BUT HAD TO BUY A NEW TIRE EACH TIME. *TR UPDATED 08/27/08
NHTSA ODI #10235428
19,925 miles · Aug 29, 2006
Tires
DT*: THE CONTACT STATED THE ORIGINAL TIRES OF THE VEHICLE HAD VERY THIN TREAD BELT AND A VERY SMALL NAIL CAUSED A PUNCTURE. THE TIRES ALSO WOULD NOT GRIPPED ON WET PAVEMENT AT ANY SPEED, CREATING SAFETY RISK DURING RAINY WEATHER. DUE TO THE POOR QUALITY OBSERVED ON THOSE TIRES BY THE CONTACT THE TIRES WERE ROTATED EVERY 3000 …
Read full complaint
DT*: THE CONTACT STATED THE ORIGINAL TIRES OF THE VEHICLE HAD VERY THIN TREAD BELT AND A VERY SMALL NAIL CAUSED A PUNCTURE. THE TIRES ALSO WOULD NOT GRIPPED ON WET PAVEMENT AT ANY SPEED, CREATING SAFETY RISK DURING RAINY WEATHER. DUE TO THE POOR QUALITY OBSERVED ON THOSE TIRES BY THE CONTACT THE TIRES WERE ROTATED EVERY 3000 MILES. THE DEALERSHIP ADVISED THE CONTACT TO REPLACE ALL TIRES AT ONLY 19000 MILES. THE TIRES MANUFACTURER DID NOT WARRANTY IN RELATIONS TO MILEAGE. THE TIRES WARRANTY PROVIDED REFERRED ONLY TO PERFORMANCE AND HANDLING. GOODYEAR MANUFACTURED THE EAGLES SS. *AK
NHTSA ODI #10166994
50 miles · Jul 22, 2006
Power TrainTires
CAR HAD SHAKE IN FRONT THROUGH STEERING WHEEL AND RT. FLOORBOARD. CHANGE TIRES AND WHEELS. CHANGES TIRES TWICE. REPLACED LEFT FRONT AXLE WITH SINGLE AXLE. REPLACED SAME AXLE WITH TWO PIECE AXLE. STILL HAS SHAKE IN IT. FACTORY TECH SAID LIVE WITH IT. *NM
NHTSA ODI #10163164
12,000 miles · Jun 28, 2005
Tires
THE SUBJECT TIRE WERE ON A CHRYSLER 2003 PT CRUSIER . THE FIRST TIME THE CAR HAS APPX 12000 MILES AROUND JAN 2005 ON AND THE TWO FRONT TIRES DEVELOPED BUBBLES AND HAD TO BE REPLACED. THE CAR NOW HAS 20000 MILES (JUN 2005) AND AGAIN THE TWO FROM TIRE HAVE BUBBLE AND NEED TO BE REPLACED. THE FIRST TIME THE DEALER SAID THE BUBB…
Read full complaint
THE SUBJECT TIRE WERE ON A CHRYSLER 2003 PT CRUSIER . THE FIRST TIME THE CAR HAS APPX 12000 MILES AROUND JAN 2005 ON AND THE TWO FRONT TIRES DEVELOPED BUBBLES AND HAD TO BE REPLACED. THE CAR NOW HAS 20000 MILES (JUN 2005) AND AGAIN THE TWO FROM TIRE HAVE BUBBLE AND NEED TO BE REPLACED. THE FIRST TIME THE DEALER SAID THE BUBBLES WERE CAUSED BY GOEING THRU POT HOLES WHICH I THOUGH LOGICA; AT THE TIME. BUT IN LESS THEN SIX MONTHS BOTH FRONT TIRE HAVE BUBBLES AND NEED TO BE REPLACE. IS DOES SEEM ODD THAT IT ALWAY BOTH TIRE. IT SEEM TO ME THAT THE TIRE ARE DEFECTIVE, THE CAR HAS A DESIGN FLAW OR THE TIRES ARE NOT SUITABLE FOR THIS CAR. THE BOTTOM LINE IS THAT THIS IS A SAFETY HAZARD AND A IT IS JUST A MATER OF TIME BEFORE ONE OF THESE TIRE BLOWOUT AT HIGH SPPED AND KILLS SOMEONE.
NHTSA ODI #10126960
1,000 miles · Apr 6, 2005
TiresVehicle Speed Control
VEHICLE EXPERIENCED EXTREME VIBRATION DURING ACCELERATION. THIS CAUSED THE VEHICLE TO PULL TO THE RIGHT WHILE ON THE ROAD. MANUFACTURER WILL BE CONTACTED BY CONSUMER.*AK BOTH THE MANUFACTURER AND GOODYEAR DEALER WERE CONTACTED HOWEVER WAS NOT ABLE TO HELP. *TT
NHTSA ODI #10115202
Mileage unknown · Jan 27, 2005
TiresCrash
WHILE DRIVING IN THE RAIN VEHICLE HYDRO PLANED, CRASHING INTO A BUS. WHEN EXPLAINING TO MANUFACTURER WHAT HAPPENED, SHE WAS TOLD THAT THE VEHICLE HAD INCORRECT TIRES FOR THE RAIN.*AK
ON CERTAIN PASSENGER VEHICLES, THE REAR QUARTER GLASS ATTACHING FASTENERS MAY PULL THROUGH THEIR MOUNTS AND ALLOW THE GLASS TO SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: IF THE GLASS SEPARATES WHILE DRIVING, IT COULD STRIKE ANOTHER VEHICLE OR INJURE A PEDESTRIAN.
Remedy: DEALERS WILL REPLACE THE REAR QUARTER GLASS. THE RECALL BEGAN ON APRIL 30, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKING SYSTEM (ABS), 2.4L HIGH OUTPUT TURBOCHARGED ENGINE, AND 5-SPEED MANUAL TRANSAXLE, MAY EXHIBIT INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE TRANSAXLE HOUSING.
Consequence & remedy
Consequence: CONTACT BETWEEN THE BRAKE TUBE AND THE TRANSAXLE HOUSING OVER AN EXTENDED PERIOD OF TIME MAY EVENTUALLY LEAD TO PERFORATION OF THE BRAKE TUBE, WHICH COULD LEAD TO A LOSS OF BRAKING FORCE IN THE LEFT FRONT/RIGHT REAR CIRCUIT OF VEHICLE.
Remedy: DEALERS WILL INSTALL REVISED BRAKE TUBES. THE RECALL BEGAN OCTOBER 25, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA07004 · Rear Quarter Panel Glass Separation
Opened Feb 16, 2007 · Closed Apr 5, 2007
Status: closed (inferred from source dates) · Visibility:glass, Side/rear
DAIMLERCHRYSLER CORPORATION (DCC) WILL RECALL MODEL YEAR 2005 AND 2006 PT CRUISER VEHICLES PRODUCED FROM 5/17/05 THROUGH 9/1/05 TO CORRECT A POTENTIAL DEFECT IN THE REAR QUARTER PANEL GLASS THAT MAY SEPARATE FROM THE VEHICLE.DCC WILL INSPECT THE REAR QUARTER PANEL GLASS AND REPLACE IF NECESSARY.DCC WILL BEGIN NOTIFYING OWNERS IN MAY 2007. VEHICLES PRODUCED PRIOR TO AND AFTER THE ABOVE BUILD DATES ARE NOT AFFECTED.A CHANGE MADE BY THE ASSEMBLY PLANT IN MAY 2005 THAT MODIFIED THE GLASS ATTACHMENT LED TO THE POTENTIAL FOR GLASS SEPARATION.IN SEPTEMBER 2005, SUBSEQUENT CHANGES TO THE PROCESS WERE MADE TO CORRECT THIS.THIS ENGINEERING ANALYSIS IS CLOSED.SEE RECALL 07V149 FOR ADDITIONAL DETAILS.
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
2005 Chrysler Pt Cruiser Problems, Complaints & Recalls | Skip That Year
Illustration