Illustration2005 CHRYSLER PT CRUISER. CONSUMER WRITES IN REGARDS TO THE FUEL LEAK LOCATION ON THE INLET NOZZLE FUEL TANK. *SMD THE DEALER STATED CHECK ENGINE LIGHT ON, CRACKED TRIM AROUND A/C UNIT, TRUNK WILL NOT STAY OPEN, FRONT BRAKES NEED REPLACING, AND REAR SHOCK NEED TO BE REPLACED. *TR
2005 Chrysler Pt Cruiser
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Chrysler Pt Cruiser do not stand out strongly from the model-year median of 202.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pt Cruiser years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
400–25K
2425–50K
4250–75K
2075–100K
24100–150K
9150K+
159 reports with mileage · 28 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports12 fire reports12 injury reports
Structure complaints
8 reportsDRIVERS SIDE REAR QUARTER WINDOW CAME OFF WHILE TRAVELING ON HIGHWAY.
I WAS ON THE FREEWAY, AND THE ROAD HAD A NATURAL "BUMP" IN IT, CAUSING A SLIGHT BIT OF LIFT WITH THE VEHICLE, AND THE VEHICLE SWAYED FROM SIDE TO SIDE, AND I HAD TO IMMEDIATELY SLOW DOWN, AND COUNTER STEER IN ORDER TO KEEP IT IN MY LANE. I TOOK IT TO MY MECHANIC TODAY, AND THE RIGHT LOWER MOTOR MOUNT IS BROKEN. I JUST REPLACE…
Read full complaint
I WAS ON THE FREEWAY, AND THE ROAD HAD A NATURAL "BUMP" IN IT, CAUSING A SLIGHT BIT OF LIFT WITH THE VEHICLE, AND THE VEHICLE SWAYED FROM SIDE TO SIDE, AND I HAD TO IMMEDIATELY SLOW DOWN, AND COUNTER STEER IN ORDER TO KEEP IT IN MY LANE. I TOOK IT TO MY MECHANIC TODAY, AND THE RIGHT LOWER MOTOR MOUNT IS BROKEN. I JUST REPLACED THAT SAME MOUNT LESS THEN 6 MONTHS AGO. MY MECHANIC SAID THEY KNOW OF A CRUISER THAT HAD 8 FRONT RIGHT MOTOR MOUNTS REPLACED. THERE IS AN ENTIRE SITE ON THE INTERNET DEDICATED TO PEOPLE WHO HAVE HAD MAJOR ISSUES WITH MOTOR MOUNTS GOING OUT OVER AND OVER AGAIN ON THEIR CRUISERS. *TR
I WAS DRIVING ON THE HIGHWAY 75 MPH, AT SOME POINT THE SIDE REAR WINDOW BLEW OUT , I HEARD THE SOUND OF A OPEN WINDOW BUT COULD NOT FIGURE OUT WHERE IT WAS COMING FROM, I PULLED OVER AND NOTICED THE WINDOW WAS GONE. IF THERE HAD BEEN A MOTOR CYCLE OR ANOTHER VEHICLE IT COULD HAVE CAUSED AN ACCIDENT. *TR
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER CONVERTIBLE. THE CONTACT STATED THE FIRE WALL RIPPED CAUSING THE CLUTCH PEDAL TO PUSH THROUGH THE FIRE WALL. THE CONTACT STATED THE VEHICLE COULD NOT BE DRIVEN DUE TO THE HOLE IN THE FIRE WALL THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR MECHANIC. THE CONTACT DID NOT NOTIFY…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER CONVERTIBLE. THE CONTACT STATED THE FIRE WALL RIPPED CAUSING THE CLUTCH PEDAL TO PUSH THROUGH THE FIRE WALL. THE CONTACT STATED THE VEHICLE COULD NOT BE DRIVEN DUE TO THE HOLE IN THE FIRE WALL THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR MECHANIC. THE CONTACT DID NOT NOTIFY THE MANUFACTURER OF THE FAILURE. THE FAILURE MILEAGE WAS 145,000.
I WAS DRIVING DOWN THE HIGHWAY AND MY REAR RIGHT WINDOW FLEW OFF WHILE GOING 55 MPH. THIS IS EXTREMELY UNSAFE! I HAD NO IDEA THE WINDOW WAS ONLY GLUED ON! I AM CURIOUS IF THERE ARE OTHER PEOPLE WHO HAVE HAD THIS ISSUE AND WHAT CAN BE DONE. *TR
2005 CHRYSLER PT CRUISER WITH SPEEDOMETER PROBLEMS**CC THE CONSUMER WAS NOT ABLE TO READ THE SPEEDOMETER DURING DAYLIGHT HOURS. THE CONSUMER BELIEVED THAT THE PROBLEM WAS DUE TO THE DEEP INSET OF THE INSTRUMENT. *JB
THE 2005 CHRYSLER PT CRUISER HAS METALLIC-SILVER DASH INSERTS AROUND THE INSTRUMENT CLUSTER AND COVERING THE PASSENGER AIR BAG COMPARTMENT. WHEN THE SUN IS HIGH IN THE SKY THE GLARE FROM THE METALLIC-SILVER INSTRUMENT PANEL IS BLINDING. THE GLARE IS SO BRIGHT IT LEAVES SPOTS IN YOUR EYES. THE MOLDED CURVES ABOVE THE INSTRUMEN…
Read full complaint
THE 2005 CHRYSLER PT CRUISER HAS METALLIC-SILVER DASH INSERTS AROUND THE INSTRUMENT CLUSTER AND COVERING THE PASSENGER AIR BAG COMPARTMENT. WHEN THE SUN IS HIGH IN THE SKY THE GLARE FROM THE METALLIC-SILVER INSTRUMENT PANEL IS BLINDING. THE GLARE IS SO BRIGHT IT LEAVES SPOTS IN YOUR EYES. THE MOLDED CURVES ABOVE THE INSTRUMENTS SEEM TO CONCENTRATE THE SUN??S ENERGY. MY WIFE IS SHORTER AND IS ABLE TO ADJUST THE TOP OF THE STEERING WHEEL TO BLOCK THE REFLECTION. I AM UNABLE TO DO THIS AND STILL HANDLE THE STEERING WHEEL COMFORTABLY. I PLACED ELECTRICAL TAPE ON THE PANEL JUST ABOVE THE CENTER INSTRUMENT TO BLOCK THE GLARE. *NM
Official recalls
307V149000 · Visibility:glass, Side/rear
Apr 4, 2007
ON CERTAIN PASSENGER VEHICLES, THE REAR QUARTER GLASS ATTACHING FASTENERS MAY PULL THROUGH THEIR MOUNTS AND ALLOW THE GLASS TO SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: IF THE GLASS SEPARATES WHILE DRIVING, IT COULD STRIKE ANOTHER VEHICLE OR INJURE A PEDESTRIAN.
Remedy: DEALERS WILL REPLACE THE REAR QUARTER GLASS. THE RECALL BEGAN ON APRIL 30, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V481000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Oct 8, 2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKING SYSTEM (ABS), 2.4L HIGH OUTPUT TURBOCHARGED ENGINE, AND 5-SPEED MANUAL TRANSAXLE, MAY EXHIBIT INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE TRANSAXLE HOUSING.
Consequence & remedy
Consequence: CONTACT BETWEEN THE BRAKE TUBE AND THE TRANSAXLE HOUSING OVER AN EXTENDED PERIOD OF TIME MAY EVENTUALLY LEAD TO PERFORATION OF THE BRAKE TUBE, WHICH COULD LEAD TO A LOSS OF BRAKING FORCE IN THE LEFT FRONT/RIGHT REAR CIRCUIT OF VEHICLE.
Remedy: DEALERS WILL INSTALL REVISED BRAKE TUBES. THE RECALL BEGAN OCTOBER 25, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V268000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07004 · Rear Quarter Panel Glass Separation
Opened Feb 16, 2007 · Closed Apr 5, 2007
Status: closed (inferred from source dates) · Visibility:glass, Side/rear
DAIMLERCHRYSLER CORPORATION (DCC) WILL RECALL MODEL YEAR 2005 AND 2006 PT CRUISER VEHICLES PRODUCED FROM 5/17/05 THROUGH 9/1/05 TO CORRECT A POTENTIAL DEFECT IN THE REAR QUARTER PANEL GLASS THAT MAY SEPARATE FROM THE VEHICLE.DCC WILL INSPECT THE REAR QUARTER PANEL GLASS AND REPLACE IF NECESSARY.DCC WILL BEGIN NOTIFYING OWNERS IN MAY 2007. VEHICLES PRODUCED PRIOR TO AND AFTER THE ABOVE BUILD DATES ARE NOT AFFECTED.A CHANGE MADE BY THE ASSEMBLY PLANT IN MAY 2005 THAT MODIFIED THE GLASS ATTACHMENT LED TO THE POTENTIAL FOR GLASS SEPARATION.IN SEPTEMBER 2005, SUBSEQUENT CHANGES TO THE PROCESS WERE MADE TO CORRECT THIS.THIS ENGINEERING ANALYSIS IS CLOSED.SEE RECALL 07V149 FOR ADDITIONAL DETAILS.
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.