NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
187 reports71,000 miles · Feb 20, 2026
Steering
The contact owns a 2005 Chrysler PT Cruiser. The contact stated that while the vehicle was at the dealer for a service appointment, the contact was informed that the power steering fluid hose was leaking. The contact stated that at that time, it was a small leak; however, the power steering fluid hose then developed a severe lea…
Read full complaint
The contact owns a 2005 Chrysler PT Cruiser. The contact stated that while the vehicle was at the dealer for a service appointment, the contact was informed that the power steering fluid hose was leaking. The contact stated that at that time, it was a small leak; however, the power steering fluid hose then developed a severe leak. The vehicle was taken to the dealer; however, the vehicle was not inspected. The contact was informed that a diagnostic test needed to be performed. The contact declined to pay for a diagnostic test. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The contact referenced an unknown recall with a similar failure however, the VIN was not under recall. The failure mileage was approximately 71,000.
NHTSA ODI #11719373
Mileage unknown · Jul 19, 2025
Unknown Or Other
Unknown went to get an inspection and I got a paper with information for how to search up if there was any recalls with my car and it has 5 recalls it said
NHTSA ODI #11674679
194,000 miles · Oct 18, 2024
Visibility
The contact owns a 2005 Chrysler PT Cruiser. The contact stated that while the A/C defroster was activated, there was no air blowing through the vents. The vehicle was taken to an independent mechanic where it was diagnosed that the blower motor needed to be replaced. The vehicle was repaired. The manufacturer was not notified o…
Read full complaint
The contact owns a 2005 Chrysler PT Cruiser. The contact stated that while the A/C defroster was activated, there was no air blowing through the vents. The vehicle was taken to an independent mechanic where it was diagnosed that the blower motor needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 194,000.
NHTSA ODI #11620681
Mileage unknown · Oct 18, 2024
Steering
The contact owns a 2005 Chrysler PT Cruiser. The contact stated while driving 30 MPH, the vehicle started shaking with and an abnormal odor emanating through the vents. Additionally, the steering wheel became firm. The vehicle was steered to the side of the road. The vehicle was towed to an independent mechanic where it was diag…
Read full complaint
The contact owns a 2005 Chrysler PT Cruiser. The contact stated while driving 30 MPH, the vehicle started shaking with and an abnormal odor emanating through the vents. Additionally, the steering wheel became firm. The vehicle was steered to the side of the road. The vehicle was towed to an independent mechanic where it was diagnosed that the power steering system needed to be repaired because the hose was disconnected. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage unknown.
NHTSA ODI #11620679
Mileage unknown · Jul 30, 2022
Unknown Or Other
The car (manual 5-speed) has issues going into reverse and hits hard shifting into other gears. I see where online it shows this issue happened quite a bit with the 2002 PT Cruiser. I don't drive my care every day and I keep it maintained very well. I have not had any accidents in it so I believe this may also be a recall iss…
Read full complaint
The car (manual 5-speed) has issues going into reverse and hits hard shifting into other gears. I see where online it shows this issue happened quite a bit with the 2002 PT Cruiser. I don't drive my care every day and I keep it maintained very well. I have not had any accidents in it so I believe this may also be a recall issue.
NHTSA ODI #11476715
Mileage unknown · Jun 30, 2021
Steering
I bought this car and seen online there was a safety recall for the power steering/hoses malfunctioning. This cars power steering is non-existent and WILL NOT HOLD any power steering fluid. I'd like to file for the recall. This makes my car dangerous to drive. It's my only transportation. Thanks! [XXX] [XXX] [XXX] PARTS OF T…
Read full complaint
I bought this car and seen online there was a safety recall for the power steering/hoses malfunctioning. This cars power steering is non-existent and WILL NOT HOLD any power steering fluid. I'd like to file for the recall. This makes my car dangerous to drive. It's my only transportation. Thanks! [XXX] [XXX] [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11422896
78,000 miles · Oct 24, 2019
Air BagsCrashInjury
RECENTLY IN A ACCIDENT, TRAVELING AT SPEED THAT IMPACTED FOUR OTHER VEHICLES. THE AIRBAG S DID NOT GO OFF.*DT*JB
NHTSA ODI #11270843
100,000 miles · Oct 8, 2019
Air BagsElectrical SystemSteering
WHETHER IN MOTION OR STANDING STILL, TILT STEERING WHEEL CLAMPING MECHANISM HAS WORN THROUGH WIRES CONNECTED TO THE AIR BAG AND ITS WARNING SYSTEM, CREATING INTERMITTENT (SHORT?) FAILURE OF AIR BAG WARNING LIGHT, PRESENTING POSSIBILITY OF SUDDEN AIRBAG DEPLOYMENT WITHOUT WARNING. WHEN AIR BAG WARNING LIGHT IS OFF, HORN WILL NOT…
Read full complaint
WHETHER IN MOTION OR STANDING STILL, TILT STEERING WHEEL CLAMPING MECHANISM HAS WORN THROUGH WIRES CONNECTED TO THE AIR BAG AND ITS WARNING SYSTEM, CREATING INTERMITTENT (SHORT?) FAILURE OF AIR BAG WARNING LIGHT, PRESENTING POSSIBILITY OF SUDDEN AIRBAG DEPLOYMENT WITHOUT WARNING. WHEN AIR BAG WARNING LIGHT IS OFF, HORN WILL NOT SOUND BUT VENTILATION FAN RUNS. WITH AIRBAG LIGHT ON, HORN WILL SOUND, BUT IF ACTIVATED, VENTILATION FAN STOPS RUNNING. MUST CONSTANTLY ADJUST STEERING WHEEEL TILT TO MAKE FAN RUN OR HONK HORN - CREATING A DISTRACTED DRIVING HAZARD.
NHTSA ODI #11267038
145,000 miles · May 16, 2019
Electrical SystemEngineFuel/propulsion SystemFire
TL-THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. STARTED THE VEHICLE AND THE VEHICLE STALLED. FUEL ODOR, VEHICLE WOULD NOT START FOR AN ADDITIONAL HOUR VEHICLE RESTARTED AND CAUGHT ON FIRE, FIRE DEPARTMENT STATED THAT THE FIRE STARTED ALONG THE FIREWALL MANUFACTURER NOT CONTACTED, FIRE REPORT FILED, FIRE EXTINGUISHED BY…
Read full complaint
TL-THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. STARTED THE VEHICLE AND THE VEHICLE STALLED. FUEL ODOR, VEHICLE WOULD NOT START FOR AN ADDITIONAL HOUR VEHICLE RESTARTED AND CAUGHT ON FIRE, FIRE DEPARTMENT STATED THAT THE FIRE STARTED ALONG THE FIREWALL MANUFACTURER NOT CONTACTED, FIRE REPORT FILED, FIRE EXTINGUISHED BY FIRE DEPARTMENT STATED THAT UPON START UP THE VEHICLE STALLED. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR. THE VEHICLE WAS THEN RESTARTED ALMOST AN HOUR LATER. THE CONTACT THEN NOTICED FIRE COMING FROM UNDER THE HOOD OF THE VEHICLE ON THE PASSENGER'S SIDE OF THE VEHICLE. THE FIRE DEPARTMENT WAS CONTACTED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THE FIRE MARSHALL STATED THAT THE FIRE SEEMED TO HAVE ORIGINATED IN A WIRING HARNESS INSTALLED BEHIND THE FUEL LINES FOR THE FUEL INJECTORS. THERE WAS NO INJURIES SUSTAINED IN THE FIRE. THE VEHICLE REMAINED AT THE RESIDENCE. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. THE VIN WAS NOT AVAILABLE. PIIR = Y. AH *DT*JB
NHTSA ODI #11207986
Mileage unknown · Sep 4, 2018
EngineFire
TL* THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. APPROXIMATELY TEN MINUTES AFTER PARKING AND TURNING OFF THE VEHICLE, IT CAUGHT ON FIRE. THE CONTACT NOTICED SMOKE AND FLAMES UNDER THE FRONT DRIVER'S SIDE OF THE VEHICLE WHERE THE ENGINE WAS LOCATED. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FIRE. A FIRE RE…
Read full complaint
TL* THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. APPROXIMATELY TEN MINUTES AFTER PARKING AND TURNING OFF THE VEHICLE, IT CAUGHT ON FIRE. THE CONTACT NOTICED SMOKE AND FLAMES UNDER THE FRONT DRIVER'S SIDE OF THE VEHICLE WHERE THE ENGINE WAS LOCATED. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED AT THE SCENE. THE VEHICLE WAS DESTROYED AND TOWED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS INVALID.
NHTSA ODI #11124347
Official recalls
3Apr 4, 2007
ON CERTAIN PASSENGER VEHICLES, THE REAR QUARTER GLASS ATTACHING FASTENERS MAY PULL THROUGH THEIR MOUNTS AND ALLOW THE GLASS TO SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: IF THE GLASS SEPARATES WHILE DRIVING, IT COULD STRIKE ANOTHER VEHICLE OR INJURE A PEDESTRIAN.
Remedy: DEALERS WILL REPLACE THE REAR QUARTER GLASS. THE RECALL BEGAN ON APRIL 30, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Oct 8, 2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKING SYSTEM (ABS), 2.4L HIGH OUTPUT TURBOCHARGED ENGINE, AND 5-SPEED MANUAL TRANSAXLE, MAY EXHIBIT INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE TRANSAXLE HOUSING.
Consequence & remedy
Consequence: CONTACT BETWEEN THE BRAKE TUBE AND THE TRANSAXLE HOUSING OVER AN EXTENDED PERIOD OF TIME MAY EVENTUALLY LEAD TO PERFORATION OF THE BRAKE TUBE, WHICH COULD LEAD TO A LOSS OF BRAKING FORCE IN THE LEFT FRONT/RIGHT REAR CIRCUIT OF VEHICLE.
Remedy: DEALERS WILL INSTALL REVISED BRAKE TUBES. THE RECALL BEGAN OCTOBER 25, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07004 · Rear Quarter Panel Glass Separation
Opened Feb 16, 2007 · Closed Apr 5, 2007
Status: closed (inferred from source dates) · Visibility:glass, Side/rear
DAIMLERCHRYSLER CORPORATION (DCC) WILL RECALL MODEL YEAR 2005 AND 2006 PT CRUISER VEHICLES PRODUCED FROM 5/17/05 THROUGH 9/1/05 TO CORRECT A POTENTIAL DEFECT IN THE REAR QUARTER PANEL GLASS THAT MAY SEPARATE FROM THE VEHICLE.DCC WILL INSPECT THE REAR QUARTER PANEL GLASS AND REPLACE IF NECESSARY.DCC WILL BEGIN NOTIFYING OWNERS IN MAY 2007. VEHICLES PRODUCED PRIOR TO AND AFTER THE ABOVE BUILD DATES ARE NOT AFFECTED.A CHANGE MADE BY THE ASSEMBLY PLANT IN MAY 2005 THAT MODIFIED THE GLASS ATTACHMENT LED TO THE POTENTIAL FOR GLASS SEPARATION.IN SEPTEMBER 2005, SUBSEQUENT CHANGES TO THE PROCESS WERE MADE TO CORRECT THIS.THIS ENGINEERING ANALYSIS IS CLOSED.SEE RECALL 07V149 FOR ADDITIONAL DETAILS.
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Illustration