Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
TL-THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. STARTED THE VEHICLE AND THE VEHICLE STALLED. FUEL ODOR, VEHICLE WOULD NOT START FOR AN ADDITIONAL HOUR VEHICLE RESTARTED AND CAUGHT ON FIRE, FIRE DEPARTMENT STATED THAT THE FIRE STARTED ALONG THE FIREWALL MANUFACTURER NOT CONTACTED, FIRE REPORT FILED, FIRE EXTINGUISHED BY…
Read full complaint
TL-THE CONTACT OWNED A 2005 CHRYSLER PT CRUISER. STARTED THE VEHICLE AND THE VEHICLE STALLED. FUEL ODOR, VEHICLE WOULD NOT START FOR AN ADDITIONAL HOUR VEHICLE RESTARTED AND CAUGHT ON FIRE, FIRE DEPARTMENT STATED THAT THE FIRE STARTED ALONG THE FIREWALL MANUFACTURER NOT CONTACTED, FIRE REPORT FILED, FIRE EXTINGUISHED BY FIRE DEPARTMENT STATED THAT UPON START UP THE VEHICLE STALLED. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR. THE VEHICLE WAS THEN RESTARTED ALMOST AN HOUR LATER. THE CONTACT THEN NOTICED FIRE COMING FROM UNDER THE HOOD OF THE VEHICLE ON THE PASSENGER'S SIDE OF THE VEHICLE. THE FIRE DEPARTMENT WAS CONTACTED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THE FIRE MARSHALL STATED THAT THE FIRE SEEMED TO HAVE ORIGINATED IN A WIRING HARNESS INSTALLED BEHIND THE FUEL LINES FOR THE FUEL INJECTORS. THERE WAS NO INJURIES SUSTAINED IN THE FIRE. THE VEHICLE REMAINED AT THE RESIDENCE. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. THE VIN WAS NOT AVAILABLE. PIIR = Y. AH *DT*JB
NHTSA ODI #11207986
70,000 miles · Aug 23, 2017
Fuel/propulsion System
PURGE CONTROL VALVE IS FAULTY, CAUSING VEHICLE TO STALL AFTER FUELING. EVERY. SINGLE. TIME. THIS OCCURS BOTH AT THE PUMP IMMEDIATELY AFTER FUELING AS WELL AS WHEN THE CAR IS IN MOTION, PULLING INTO TRAFFIC FROM THE FUEL STATION. THE LATTER HAS CAUSED SAFETY HAZARDS & NEAR-ACCIDENTS COUNTLESS TIMES.
NHTSA ODI #11019155
133,000 miles · Jun 1, 2017
Fuel/propulsion System
STALLS OUT WHILE DRIVING, CAR COMPLETELY STOPS AND YOU CAN'T GO FORWARD, HAVE TO PUT THE CAR IN PARK AND BACK IN DRIVE MULTIPLE TIMES IN ORDER TO EVEN BE ABLE TO DRIVE... CAR COMPLETELY SHUT OFF IN THE MIDDLE OF A BUSY ROAD...
NHTSA ODI #10992738
101,000 miles · Jan 2, 2015
Fuel/propulsion System
FUEL LINE HAS BEGUN LEAKING FUEL EVERY TIME YOU START THE CAR. HAVE REPLACED FUEL LINE AND CONTINUES TO LEEK. SEARCHED ON THE INTERNET AND THERE IS NO REAL FIX AND CHRYSLER PLASTIC CONNECTION WAS A POOR BUILD MAKING THIS AN ISSUE FOR ALMOST EVERY PT CRUISER OUT THERE. *TR
NHTSA ODI #10669778
96,086 miles · Nov 30, 2012
EquipmentFuel/propulsion System
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. THE CONTACT STATED THAT AFTER INSPECTING THE VEHICLE HE NOTICED THE AIR CONDITIONER ACCUMULATOR LEAKS WATER ONTO THE FUEL LINES. THE FUEL LINE HAD RUSTED THROUGH AND WAS LEAKING FUEL. THE CONTACT STATED THE FUEL LINE NEEDED TO BE REPLACED AND A SHIELD WOULD HAVE TO BE INSTALLED BE…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHRYSLER PT CRUISER. THE CONTACT STATED THAT AFTER INSPECTING THE VEHICLE HE NOTICED THE AIR CONDITIONER ACCUMULATOR LEAKS WATER ONTO THE FUEL LINES. THE FUEL LINE HAD RUSTED THROUGH AND WAS LEAKING FUEL. THE CONTACT STATED THE FUEL LINE NEEDED TO BE REPLACED AND A SHIELD WOULD HAVE TO BE INSTALLED BETWEEN THE AIR CONDITIONER ACCUMULATOR AND THE FUEL LINE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 96,086.
ON CERTAIN PASSENGER VEHICLES, THE REAR QUARTER GLASS ATTACHING FASTENERS MAY PULL THROUGH THEIR MOUNTS AND ALLOW THE GLASS TO SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: IF THE GLASS SEPARATES WHILE DRIVING, IT COULD STRIKE ANOTHER VEHICLE OR INJURE A PEDESTRIAN.
Remedy: DEALERS WILL REPLACE THE REAR QUARTER GLASS. THE RECALL BEGAN ON APRIL 30, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKING SYSTEM (ABS), 2.4L HIGH OUTPUT TURBOCHARGED ENGINE, AND 5-SPEED MANUAL TRANSAXLE, MAY EXHIBIT INADEQUATE CLEARANCE BETWEEN THE LEFT FRONT BRAKE TUBE AND THE TRANSAXLE HOUSING.
Consequence & remedy
Consequence: CONTACT BETWEEN THE BRAKE TUBE AND THE TRANSAXLE HOUSING OVER AN EXTENDED PERIOD OF TIME MAY EVENTUALLY LEAD TO PERFORATION OF THE BRAKE TUBE, WHICH COULD LEAD TO A LOSS OF BRAKING FORCE IN THE LEFT FRONT/RIGHT REAR CIRCUIT OF VEHICLE.
Remedy: DEALERS WILL INSTALL REVISED BRAKE TUBES. THE RECALL BEGAN OCTOBER 25, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Defect investigations
2
EA07004 · Rear Quarter Panel Glass Separation
Opened Feb 16, 2007 · Closed Apr 5, 2007
Status: closed (inferred from source dates) · Visibility:glass, Side/rear
DAIMLERCHRYSLER CORPORATION (DCC) WILL RECALL MODEL YEAR 2005 AND 2006 PT CRUISER VEHICLES PRODUCED FROM 5/17/05 THROUGH 9/1/05 TO CORRECT A POTENTIAL DEFECT IN THE REAR QUARTER PANEL GLASS THAT MAY SEPARATE FROM THE VEHICLE.DCC WILL INSPECT THE REAR QUARTER PANEL GLASS AND REPLACE IF NECESSARY.DCC WILL BEGIN NOTIFYING OWNERS IN MAY 2007. VEHICLES PRODUCED PRIOR TO AND AFTER THE ABOVE BUILD DATES ARE NOT AFFECTED.A CHANGE MADE BY THE ASSEMBLY PLANT IN MAY 2005 THAT MODIFIED THE GLASS ATTACHMENT LED TO THE POTENTIAL FOR GLASS SEPARATION.IN SEPTEMBER 2005, SUBSEQUENT CHANGES TO THE PROCESS WERE MADE TO CORRECT THIS.THIS ENGINEERING ANALYSIS IS CLOSED.SEE RECALL 07V149 FOR ADDITIONAL DETAILS.
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration