NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
618 reports69,000 miles · Feb 26, 2014
Wheels
THE CHROME RIMS LEAK AIR BECAUSE THEY HAVE BEEN LEECHING (PEELING) SINCE THE PURCHASE OF THE VEHICLE. I HAVE ONLY OWNED THE VEHICLE FOR 6 YEARS (I BOUGHT THE VEHICLE WITH APPROXIMATELY 68,000 MILES) AND HAVE AVERAGED 8700 MILES PER YEAR. I HAVE HAD THE RIMS SEALED AT LEAST A DOZEN TIMES SINCE I PURCHASED THE VEHICLE BUT THE SEAL…
Read full complaint
THE CHROME RIMS LEAK AIR BECAUSE THEY HAVE BEEN LEECHING (PEELING) SINCE THE PURCHASE OF THE VEHICLE. I HAVE ONLY OWNED THE VEHICLE FOR 6 YEARS (I BOUGHT THE VEHICLE WITH APPROXIMATELY 68,000 MILES) AND HAVE AVERAGED 8700 MILES PER YEAR. I HAVE HAD THE RIMS SEALED AT LEAST A DOZEN TIMES SINCE I PURCHASED THE VEHICLE BUT THE SEALS ONLY LAST FOR SHORT PERIODS DUE TO THE CONSTANT PEELING. CURRENTLY, I HAVE TO FILL THE TIRES WITH AT LEAST 20 POUNDS OF AIR EVERY 2-3 DAYS. MY BIGGEST FEAR IS THAT THEY WILL FAIL WHILE I AM DRIVING ON THE HIGHWAY. *TR
NHTSA ODI #10566127
111,145 miles · Feb 14, 2014
Service BrakesVehicle Speed Control
TL* THE CONTACT OWNS 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE VEHICLE INDEPENDENTLY ACCELERATED WITHOUT WARNING AFTER STARTING THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO BE DIAGNOSIS. THE DEALER STATED THAT THE POWER BRAKE BOOSTER HOSE WAS NOT CONNECTED TO THE ENGINE. THE VEHICLE WAS REPAIRED. THE DE…
Read full complaint
TL* THE CONTACT OWNS 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE VEHICLE INDEPENDENTLY ACCELERATED WITHOUT WARNING AFTER STARTING THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO BE DIAGNOSIS. THE DEALER STATED THAT THE POWER BRAKE BOOSTER HOSE WAS NOT CONNECTED TO THE ENGINE. THE VEHICLE WAS REPAIRED. THE DEALER ALSO STATED THAT THERE WAS NEVER A CLAMP HOLDING THE POWER BRAKE IN PLACE. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 111,145. THE CURRENT MILEAGE WAS 112,416. *TR
NHTSA ODI #10564360
Mileage unknown · Feb 7, 2014
Steering
I HAVE 2001 PT CRUISER, I HAD THE CONTROL BUSHINGS AND TIE ROD REPLACED AFTER I HAD THEM REPLACE IT TOOK ONLY ONE YEAR FOR THEM TO GO OUT AGAIN. I WILL NEVER BUY OR SUGGEST PURCHASING A PT CRUISER. THANK YOU FOR HAVING THIS PAGE/SITE TO LIST COMPLAINTS. *TR
NHTSA ODI #10563420
Mileage unknown · Feb 7, 2014
Child SeatCrashInjury
I OWN A TURBO BOOSTER CHILD CAR SEAT ,MANUFACTURED 5-28-2012 BY GRACO CHILDREN'S PRODUCTS INC.. THE CHILD SAFETY SEAT WILL SNAP OUT FROM THE BASE AND IT CAN RECLINE ALL THE WAY BACK LIKE LAYING POSITION! THERE WAS NOT ENOUGH SAFETY INSTALLATION INSTRUCTIONS WHEN WE BOUGHT IT. ON NOVEMBER 19 8 AM I GET READY DRIVE TO WORK AND MY …
Read full complaint
I OWN A TURBO BOOSTER CHILD CAR SEAT ,MANUFACTURED 5-28-2012 BY GRACO CHILDREN'S PRODUCTS INC.. THE CHILD SAFETY SEAT WILL SNAP OUT FROM THE BASE AND IT CAN RECLINE ALL THE WAY BACK LIKE LAYING POSITION! THERE WAS NOT ENOUGH SAFETY INSTALLATION INSTRUCTIONS WHEN WE BOUGHT IT. ON NOVEMBER 19 8 AM I GET READY DRIVE TO WORK AND MY 3 YEAR OLD WAS BUCKLED IN HER CAR SEAT BEHIND THE DRIVERS SIDE OF MY 2001 CHRYSLER PT CRUISER SHE WAS BELTED OVER HER SHOULDER CORRECTLY, SHE WAS NOT RESTRAINED SAFE ENOUGH BECAUSE WE ARE LUCKY TO BE ALIVE. WE WERE TBONED BY A KENWORTH SEMI LOGGING TRUCK COMING OUT OF OUR DRIVEWAY, SHE WAS THROWN OUT OF THE CARSEAT ON THE FLOOR BEHIND MY DRIVERS SEAT. SHE CAUGHT HER FINGER ON THE BELT IT WAS DISLODGED BEFORE THROWN TO THE FLOOR AND SHE RECEIVED STITCHES ON HER INDEX FINGER LACERATION SHE ALSO WAS HURT ON THE HEAD BACK AND BELLY SHE WAS TAKEN TO THE HOSPITAL BY AMBULANCE (RELATED VEHICLE INFORMATION: MODEL YEAR=2001, MAKE=CHRYSLER, MODEL=PT CRUISER) *TR
NHTSA ODI #10563407
100,000 miles · Dec 5, 2013
Vehicle Speed Control
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE ACCELERATED TO 70 MPH INDEPENDENTLY AND WITHOUT WARNING. THE CONTACT ALSO MENTIONED THAT THE PARKING BRAKE HAD TO BE ENGAGED IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFAC…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE ACCELERATED TO 70 MPH INDEPENDENTLY AND WITHOUT WARNING. THE CONTACT ALSO MENTIONED THAT THE PARKING BRAKE HAD TO BE ENGAGED IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 100,000. ..UPDATED 12-30-13 *BF
NHTSA ODI #10554927
97,000 miles · Nov 20, 2013
Seat BeltsCrashInjury
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT ANOTHER VEHICLE CRASHED INTO THE REAR OF HER VEHICLE WHILE SITTING AT A COMPLETE STOP. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT TENSIONER FAILED TO RESTRAIN THE CONTACT. THE CONTACT SUSTAINED INJURIES WHEN SHE WAS THROWN INTO THE STEERING WHEEL. THE…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT ANOTHER VEHICLE CRASHED INTO THE REAR OF HER VEHICLE WHILE SITTING AT A COMPLETE STOP. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT TENSIONER FAILED TO RESTRAIN THE CONTACT. THE CONTACT SUSTAINED INJURIES WHEN SHE WAS THROWN INTO THE STEERING WHEEL. THERE WERE A TOTAL OF FOUR VEHICLES INVOLVED IN THE CRASH. THE VEHICLE WAS ABLE TO BE DRIVEN FROM THE CRASH SITE BUT WAS NOT INSPECTED TO DETERMINE THE CAUSE OF THE AIR BAG OR SEATBELT FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.
NHTSA ODI #10553029
62,000 miles · Nov 12, 2013
Suspension
WHILE DRIVING AT 30 MILES AN HOUR, THE FRONT SUSPENSION CROSS-MEMBER BROKE AS A RESULT OF SEVERE RUST. THIS CAUSED THE RIGHT FRONT WHEEL TO STEER TOWARDS THE DITCH CREATING A SIGNIFICANT SAFETY HAZARD. THE RUST WAS CAUSED BY WATER DRAINING FROM THE AIR CONDITIONER ONTO THE PASSENGER'S SIDE OF THE CROSS-MEMBER. I HAVE ATTEMPTED T…
Read full complaint
WHILE DRIVING AT 30 MILES AN HOUR, THE FRONT SUSPENSION CROSS-MEMBER BROKE AS A RESULT OF SEVERE RUST. THIS CAUSED THE RIGHT FRONT WHEEL TO STEER TOWARDS THE DITCH CREATING A SIGNIFICANT SAFETY HAZARD. THE RUST WAS CAUSED BY WATER DRAINING FROM THE AIR CONDITIONER ONTO THE PASSENGER'S SIDE OF THE CROSS-MEMBER. I HAVE ATTEMPTED TO ORDER A REPLACEMENT PART FROM CHRYSLER BUT SO FAR THE OUTLOOK FOR DELIVERY HAS CHANGED FOUR TIMES AND IS CURRENTLY ESTIMATED FOR 12/25/2013 (2.5 MONTHS AFTER THE CAR BECAME INOPERABLE). NOT ONLY DOES CHRYSLER IGNORE THE NUMEROUS REPORTS OF THIS COMMONLY REPORTED DESIGN FLAW, THEY ARE PROVING TO BE INCAPABLE AT PROVIDING REPLACEMENT PARTS. THIS IS EVIDENT AS I AM ONE OF 28 CAR OWNERS WHO ARE WAITING FOR THIS PART FROM CHRYSLER, AND THERE IS HIGH DEMAND FOR THIS PART FROM JUNKYARDS. *TR
NHTSA ODI #10552013
75,000 miles · Oct 19, 2013
Power TrainStructureSuspension
UPON INSPECTION DURING A REPAIR FOR ANOTHER PROBLEM IT WAS DISCOVERED THAT THE FRONT SUSPENSION CROSSMEMBER KNOWN AS THE K-FRAME IS SEVERELY CORRODED AND WILL LIKELY NOT PASS ANOTHER SAFETY INSPECTION. THE REST OF THE UNDERNEATH OF THIS CAR IS RELATIVELY RUST-FREE AND THIS IS A LOW MILEAGE VEHICLE FOR ITS AGE. IF THIS PART FA…
Read full complaint
UPON INSPECTION DURING A REPAIR FOR ANOTHER PROBLEM IT WAS DISCOVERED THAT THE FRONT SUSPENSION CROSSMEMBER KNOWN AS THE K-FRAME IS SEVERELY CORRODED AND WILL LIKELY NOT PASS ANOTHER SAFETY INSPECTION. THE REST OF THE UNDERNEATH OF THIS CAR IS RELATIVELY RUST-FREE AND THIS IS A LOW MILEAGE VEHICLE FOR ITS AGE. IF THIS PART FAILS GOING DOWN THE HIGHWAY THE ENGINE, TRANSMISSION, ETC. WILL ALL DROP AND CAUSE THE VEHICLE TO LOSE CONTROL. *TR
NHTSA ODI #10548509
59,700 miles · Sep 3, 2013
EngineStructureSuspensionCrash
I WAS MAKING A RIGHT HAND TURN FROM A MAIN ROAD ONTO A SIDE STREET. WHILE THE CAR WAS TURNING, I HEARD A CLUNK AND THE STEERING WHEEL WAS JERKED FROM MY HANDS. THE CAR PULLED HARD TO THE RIGHT AND CRASHED INTO THE CURB. THE CAR WAS TOWED TO THE REPAIR SHOP AND THE SERVICE TECH SHOWED ME THE ENGINE CRADLE WAS COMPLETELY RUSTED OU…
Read full complaint
I WAS MAKING A RIGHT HAND TURN FROM A MAIN ROAD ONTO A SIDE STREET. WHILE THE CAR WAS TURNING, I HEARD A CLUNK AND THE STEERING WHEEL WAS JERKED FROM MY HANDS. THE CAR PULLED HARD TO THE RIGHT AND CRASHED INTO THE CURB. THE CAR WAS TOWED TO THE REPAIR SHOP AND THE SERVICE TECH SHOWED ME THE ENGINE CRADLE WAS COMPLETELY RUSTED OUT AND THE K FRAME WAS CRACKED ALL THE WAY THRU. IT'S TO RUSTED TO BE WELDED AND I WAS TOLD THIS IS A COMMON PROBLEM WITH THE CRUISER AND DODGE NEON, SINCE THEY USE THE SAME FRAME. THE TECH ALSO TOLD ME I WAS LUCKY THAT I WASN'T MOVING AT HIGH SPEED OR THE RESULTS COULD HAVE BEEN FATAL. HE ALSO TOLD ME THAT CHRYSLER IS AWARE OF THIS PROBLEM, THEY ARE COMPLETELY OUT OF REPLACEMENT PARTS, AND THEY BASICALLY IGNORE ANY COMPLAINTS. *JB
NHTSA ODI #10541698
98,000 miles · Aug 23, 2013
Structure
I WAS NOT INITIALLY GOING TO FILE A COMPLAINT UNTIL I SEEN OTHERS WITH THE SAME PROBLEM. THE DASH CRACKED INTO MANY PIECES. I ORIGINALLY THOUGHT THAT MY WIFE HAD DONE SOMETHING TO CRACK THE DASH, AND SHE THOUGHT THAT I HAD. THE PART REMAINED BASICALLY INTACT UNTIL THE SERVICE DEPARTMENT AT THE LOCAL CHRYSLER DEALER HAD TO REM…
Read full complaint
I WAS NOT INITIALLY GOING TO FILE A COMPLAINT UNTIL I SEEN OTHERS WITH THE SAME PROBLEM. THE DASH CRACKED INTO MANY PIECES. I ORIGINALLY THOUGHT THAT MY WIFE HAD DONE SOMETHING TO CRACK THE DASH, AND SHE THOUGHT THAT I HAD. THE PART REMAINED BASICALLY INTACT UNTIL THE SERVICE DEPARTMENT AT THE LOCAL CHRYSLER DEALER HAD TO REMOVE THE DASH FOR OTHER REPAIRS. AT THAT TIME WE HAD TO PAY FOR ANOTHER DASH BECAUSE IT FELL COMPLETELY APART AND COULD NOT BE RE-ASSEMBLED. I AM NOT SURE IF THIS IS EXACTLY A HIGHWAY TRAFFIC SAFETY CONCERN, BUT ONLY BECAUSE THERE WAS NOT AN ACCIDENT, NOR AN INCIDENT. *TR
NHTSA ODI #10536997
Official recalls
5Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL SUPPLY LINE COULD CONTACT THE AIR-CONDITIONING TUBE SERVICE PORT. THIS CAN CAUSE CHAFING OF THE LINE RESULTING IN A FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE FOR ABRASION AND INSTALL A CLIP TO ENSURE ISOLATION. IN CASES WITH EVIDENCE OF FUEL LINE ABRASION, THE FUEL LINE WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jun 14, 2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE RIGHT REAR "65%" SEAT CENTER LOWER ANCHOR WAS MANUFACTURED WITH A WIRE DIAMETER THAT IS GREATER THAN THE MAXIMUM ALLOWABLE DIMENSION AS SPECIFIED IN THE STANDARD.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT REAR SEAT CENTER ANCHOR AND, IF NECESSARY, RESIZE THE ANCHOR TO MEET THE DIAMETER SPECIFIED WITHIN THE STANDARD. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02058 · Fuel Hose Abrasion
Opened Jul 19, 2002 · Closed Oct 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
Illustration