LET ME START BY SAYING I JUST BOUGHT THIS 2001 LIMITED EDITION PT CRUISER THREE DAYS AGO FROM A PRIVATE DEALER. I WAS ON THE HIGHWAY, HEADING HOME FROM WORK IN THE MIDDLE OF THE NIGHT, AND WANTED TO TRY THE CRUISE CONTROL. I TURNED IT ON AND SET IT FOR 67MPH TO SEE IF IT WORKED FIRST. THEN I WENT TO RESET IT TO MY ACTUAL DESIRED…
Read full complaint
LET ME START BY SAYING I JUST BOUGHT THIS 2001 LIMITED EDITION PT CRUISER THREE DAYS AGO FROM A PRIVATE DEALER. I WAS ON THE HIGHWAY, HEADING HOME FROM WORK IN THE MIDDLE OF THE NIGHT, AND WANTED TO TRY THE CRUISE CONTROL. I TURNED IT ON AND SET IT FOR 67MPH TO SEE IF IT WORKED FIRST. THEN I WENT TO RESET IT TO MY ACTUAL DESIRED SPEED BY TAPPING MY BRAKES, THEN I TRIED THE SWITCH ON THE ARM OF MY STEERING WHEEL BUT THE CRUISE CONTROL WOULDN'T SHUT OFF. I GOT OFF AT THE NEXT EXIT AND WAS ABLE TO SLOW DOWN TO 40MPH BEFORE MY BRAKES LOCKED UP AND I WAS FORCED TO RUN THE STOP SIGN AT THE END OF THE OFF RAMP. (THANK GOD IT WAS AT 3AM AND MY BABY WASN'T WITH ME!). I WAS ABLE TO PULL OVER DOING 20MPH BEFORE THE BRAKES LOCKED UP AGAIN. I QUICKLY SHUT IT OFF, PUT IT IN PARK, AND WAITED A FEW MINUTES TO TURN IT BACK ON. BUT THE ENGINE JUST KEPT REVING, AS IF I WAS HOLDING MY FOOT ON THE GAS BECAUSE THE CRUISE CONTROL WAS STILL ON! I TRIED RESETTING IT BY TURNING THE KEY BACK AND FORTH A FEW TIMES. I TRIED TO SEE IF IT WOULD THROW ME A CODE BUT ONLY "DONE" APPEARED ON MY DASH. EVERY TIME I STARTED THE CAR, THE LED FOR CRUISE CONTROL WOULD COME ON AND THEN SHUT OFF AFTER A FEW SECONDS. I WAS ABLE TO COAST HOME DOING 40MPH WITH ACCESS TO MY BRAKES AGAIN. NOT VERY WELL, BUT ENOUGH TO MAKE IT HOME, (WHEN I'D LET OFF THE BRAKE THE CAR WOULD TAKE OFF AGAIN). I'VE BEEN DOING RESEARCH SINCE I GOT BACK AND FOUND A FEW OTHER REPORTS OF THIS HAPPENING, EXCEPT THEY WERE ALL ABLE TO STOP. FOR EXAMPLE BY SHIFTING INTO NEUTRAL OR SHUTTING THE CAR OFF. EVERY TIME I START THE [XXX] THING, THE CRUISE CONTROL IS STILL ON! HOW DO I SHUT IT OFF? PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #10958583
28,000 miles · Jun 1, 2009
Power TrainSeats
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. WHEN ATTEMPTING TO SHIFT GEARS, THE GEAR SHIFTER BECAME LOOSE AND TEMPORARILY INOPERATIVE. THE CONTACT TOOK THE VEHICLE TO A TRANSMISSION EXPERT AND A TECHNICIAN STATED THAT THE GEAR BOX BUSHINGS AND THRUST WASHERS WERE MISSING. HE TOOK THE VEHICLE TO A DEALER AND THEY REPLACED …
Read full complaint
TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. WHEN ATTEMPTING TO SHIFT GEARS, THE GEAR SHIFTER BECAME LOOSE AND TEMPORARILY INOPERATIVE. THE CONTACT TOOK THE VEHICLE TO A TRANSMISSION EXPERT AND A TECHNICIAN STATED THAT THE GEAR BOX BUSHINGS AND THRUST WASHERS WERE MISSING. HE TOOK THE VEHICLE TO A DEALER AND THEY REPLACED THE CLUTCH CABLES AT THE COST OF $300. IN ADDITION, THE SEAT CABLES TO THE REAR PASSENGER SEAT FAILED. HE CALLED THE MANUFACTURER AND LEFT A MESSAGE. THE FAILURE AND CURRENT MILEAGES WERE 28,000.
NHTSA ODI #10272537
Mileage unknown · Mar 20, 2003
Air BagsEquipmentSeats
THE AIR BAG LIGHT ILLUMINATED ON THE DASH BOARD. THE AIR BAG SWTICH HAS BEEN CHANGED SEVERAL TIMES BUT THE PROBLEM REMAINED. *NLM THE CODE ON THE LEFT SIDE SEAT SQUIB OPEN WAS FOUND, WHICH WAS TAKEN APART AND REINSTALLED. THE STEREO WAS DEFECTIVE. SCC
NHTSA ODI #10012192
Mileage unknown · Feb 12, 2002
Seats
DRIVER'S HEADREST KEEPS MOVING UP WHILE DRIVING VEHICLE. VEHICLE TAKEN TO DEALER, PASSENGER'S SEAT WAS REPLACED BY MISTAKE. CONSUMER IS STILL WAITING TO HAVE DRIVER SEAT REPLACED. PLEASE ADD FURTHER DETAILS.*AK
NHTSA ODI #8003970
Mileage unknown · Oct 31, 2001
Seats
HEAD RESTRAINTS ARE CAUSING POOR VISIBILITY. DEALER WAS NOTIFIED, AND UNWILLING TO ASSIST IN THIS MATTER. *AK CONSUMER BELIEVES THIS TO BE A DESIGN PROBLEM, THE REAR HEAD RESTS ARE VERY DISTRACTING AND CONFUSING WHEN USING THE INSIDE REAR VIEW MIRROR, THE FRONT SEAT HEAD RESTS BLOCK VISIBILITY WHEN CHANGING LANES OR BACKING UP.*…
Read full complaint
HEAD RESTRAINTS ARE CAUSING POOR VISIBILITY. DEALER WAS NOTIFIED, AND UNWILLING TO ASSIST IN THIS MATTER. *AK CONSUMER BELIEVES THIS TO BE A DESIGN PROBLEM, THE REAR HEAD RESTS ARE VERY DISTRACTING AND CONFUSING WHEN USING THE INSIDE REAR VIEW MIRROR, THE FRONT SEAT HEAD RESTS BLOCK VISIBILITY WHEN CHANGING LANES OR BACKING UP.*SLC
NHTSA ODI #898608
Mileage unknown · May 11, 2001
Seats
HEAD RESTRAINT IS OF SUCH DESIGN THAT IT WILL NOT STAY IN POSITION. IT WILL DRIFT UP, AND CONSUMER'S HEAD RESTS AGAINST METAL BARS. CHRYSLER ADMITTED THERE WAS A PROBLEM, AND THEY WERE WORKING ON IT.*AK CHRYSLER STATED TO CONSUMER THAT ALL VEHICLES MADE AFTER NOVEMBER 2000 HAVE THIS PROBLEM. *SLC
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES, THE FUEL SUPPLY LINE COULD CONTACT THE AIR-CONDITIONING TUBE SERVICE PORT. THIS CAN CAUSE CHAFING OF THE LINE RESULTING IN A FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE FOR ABRASION AND INSTALL A CLIP TO ENSURE ISOLATION. IN CASES WITH EVIDENCE OF FUEL LINE ABRASION, THE FUEL LINE WILL BE REPLACED. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE RIGHT REAR "65%" SEAT CENTER LOWER ANCHOR WAS MANUFACTURED WITH A WIRE DIAMETER THAT IS GREATER THAN THE MAXIMUM ALLOWABLE DIMENSION AS SPECIFIED IN THE STANDARD.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT REAR SEAT CENTER ANCHOR AND, IF NECESSARY, RESIZE THE ANCHOR TO MEET THE DIAMETER SPECIFIED WITHIN THE STANDARD. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02058 · Fuel Hose Abrasion
Opened Jul 19, 2002 · Closed Oct 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
2001 Chrysler Pt Cruiser Problems, Complaints & Recalls | Skip That Year
Illustration