I HAVE EXPERIENCED ALOT OF PLAY IN THE STEERING OF MY CHRYSLER CONCORDE 1997. AFTER INSPECTION IT WAS FOUND THAT THE FRONT CRADLE BUSHINGS WHERE WORN AWAY. I HAVE OWNED THIS CAR FOR 2 YEARS. I LOOKED AT A WEB SITE CONCERNING THIS AND OTHER PROBLEMS WITH THIS AND OTHER CHRSLER MODELS. AND IS CONCERNED ABOUT THE ISSUES RELATED TO …
Read full complaint
I HAVE EXPERIENCED ALOT OF PLAY IN THE STEERING OF MY CHRYSLER CONCORDE 1997. AFTER INSPECTION IT WAS FOUND THAT THE FRONT CRADLE BUSHINGS WHERE WORN AWAY. I HAVE OWNED THIS CAR FOR 2 YEARS. I LOOKED AT A WEB SITE CONCERNING THIS AND OTHER PROBLEMS WITH THIS AND OTHER CHRSLER MODELS. AND IS CONCERNED ABOUT THE ISSUES RELATED TO SEVERE AND CATASTROPHIC FAILURES WITH THESE VEHICLES. *TR
NHTSA ODI #10259198
62,000 miles · Jan 2, 2008
Structure
MY CAR STARTED MAKING A CLUNKING NOISE, AND I CHECKED OUT THE PROBLEM AND FOUND THE ENGINE CRADLE BUSHING WERE JUNK. THE CAR ONLY HAD 62000 MILES ON IT. THIS COULD OF CAUSED A VERY BAD ACCIDENT IF THE CRADLE HAD BROKEN. THE CAR WAS LIFTED OFF THE GROUND AND THERE WAS ABOUT A 2 IINCH GAP BETWEEN THE FRAME AND CRADLE WHERE THE BU…
Read full complaint
MY CAR STARTED MAKING A CLUNKING NOISE, AND I CHECKED OUT THE PROBLEM AND FOUND THE ENGINE CRADLE BUSHING WERE JUNK. THE CAR ONLY HAD 62000 MILES ON IT. THIS COULD OF CAUSED A VERY BAD ACCIDENT IF THE CRADLE HAD BROKEN. THE CAR WAS LIFTED OFF THE GROUND AND THERE WAS ABOUT A 2 IINCH GAP BETWEEN THE FRAME AND CRADLE WHERE THE BUSHING ARE WORN OUT. I CURRENT DON'T DRIVE THIS CAR DO TO THIS ISSUE.*CN
NHTSA ODI #10213519
125,879 miles · Dec 6, 2005
Structure
WHEN I WOULD PLACE THE AUTOMATIC TRANSMISSION IN REVERSE ON MY 1997 CHRYSLER CONCORDE THE GAS PEDAL WOULD STICK AND ACCELERATE AT A RAPID RATE. THE ONLY WAY THAT I COULD STOP THE ACCELERATION WAS BY PLACING BOTH ON THE BRAKE AND TURNING THE KEY OFF. DAVE DENNIS CHRYSLER DEALER IN DAYTON, OH., VERIFIED THIS. THEY FOUND THAT THE C…
Read full complaint
WHEN I WOULD PLACE THE AUTOMATIC TRANSMISSION IN REVERSE ON MY 1997 CHRYSLER CONCORDE THE GAS PEDAL WOULD STICK AND ACCELERATE AT A RAPID RATE. THE ONLY WAY THAT I COULD STOP THE ACCELERATION WAS BY PLACING BOTH ON THE BRAKE AND TURNING THE KEY OFF. DAVE DENNIS CHRYSLER DEALER IN DAYTON, OH., VERIFIED THIS. THEY FOUND THAT THE CRADLE BUSHINGS WERE BAD WHICH CAUSED THE MOTOR TO MOVE AND HIT THE THROTTLE WHICH CAUSED THE MOTOR TO REV. UP IN GEAR. THEY REPLACED THE CRADLE BUSHINGS AND I HAVE HAD NO TROUBLE SINCE. I CONSIDER THIS TO BE A SAFETY ISSUE. THE MECHANIC AT THE CHRYSLER DEALER STATED THAT WORN CRADLE BUSHINGS WERE A COMMON PROBLEM WITH K FRAMES USED ON CHRYSLERS. I CAN'T BE THE ONLY PERSON WHO HAS EXPERIENCED THIS PROBLEM DUE TO CRADLE BUSHINGS WEAR. *NM
NHTSA ODI #10144614
Mileage unknown · Aug 3, 2005
Power TrainStructureSuspension
THE CONSUMER NOTICED THAT CAR SEEMED TO BE PULLING TO THE LEFT/RIGHT. THE CONSUMER HEARD SOMETHING POP AND RATTLE AND THEN PARTS STARTED FALLING FROM THE VEHICLE ON TO THE HIGHWAY. THE CONSUMER PURCHASED MORE PARTS AND THEY FAILED. THE CONSUMER TOOK THE VEHICLE TO MECHANIC WHO DETERMINED THE TRANSMISSION FLUID LINE WAS LEAKING .…
Read full complaint
THE CONSUMER NOTICED THAT CAR SEEMED TO BE PULLING TO THE LEFT/RIGHT. THE CONSUMER HEARD SOMETHING POP AND RATTLE AND THEN PARTS STARTED FALLING FROM THE VEHICLE ON TO THE HIGHWAY. THE CONSUMER PURCHASED MORE PARTS AND THEY FAILED. THE CONSUMER TOOK THE VEHICLE TO MECHANIC WHO DETERMINED THE TRANSMISSION FLUID LINE WAS LEAKING . ANOTHER MECHANIC STATED THAT THE FRONT END WAS COMING PART AND WAS LOOSE. THE FRAME WAS LOOSE AND NOTHING WAS HOLDING IT TOGETHER. AFTER REPLACING ALL THE PARTS, THE CONSUMER RECEIVED A RECALL NOTICE. TOOK IT TO DEALER AND THEY TOLD HER THAT THEY FIXED THE PROBLEM. BUT, DIDN'T TELL HER WHAT THE PROBLEM WAS, BUT NOW PROBLEM IS WORSE. CAR WAS JUMPING LIKE IT DIDN'T SHIFT INTO GEAR. TRANSMISSION FEELS LIKE IT'S SLIPPING. CONTACT CALLED NHTSA LAST WEEK AND TALKED TO A LADY AND WAS TOLD TO REPLACE THE POWER STEERING FLUID LINE. BOUGHT PIECE OF LINE AND WAS TOLD TO BUY A VACUUM PIPE.
NHTSA ODI #10118812
Mileage unknown · Jan 3, 2005
Electrical SystemEquipmentStructure
THERE WERE SERIOUS SAFETY DEFECTS. THE A/C TURNS ON EVEN IF LOCKED OUT, THE DRIVER'S DOOR LEAKED, THE DASH LIGHTS BLINK ON/OFF WITHOUT CONTROL (ALL GAUGES), AND THE AIRBAG LIGHT, LIGHTS UP. BF THE TRUNK WOULD OPEN DUE TO MOISTURE IN THE AIR, AT NIGHT, THE WINDOW WOULD STEAM UP COMPLETELY IN SECONDS, AND THE SPEEDOMETER WOU…
Read full complaint
THERE WERE SERIOUS SAFETY DEFECTS. THE A/C TURNS ON EVEN IF LOCKED OUT, THE DRIVER'S DOOR LEAKED, THE DASH LIGHTS BLINK ON/OFF WITHOUT CONTROL (ALL GAUGES), AND THE AIRBAG LIGHT, LIGHTS UP. BF THE TRUNK WOULD OPEN DUE TO MOISTURE IN THE AIR, AT NIGHT, THE WINDOW WOULD STEAM UP COMPLETELY IN SECONDS, AND THE SPEEDOMETER WOULD QUIT. *SC *JB
NHTSA ODI #10107087
20,015 miles · Jan 15, 2004
Structure
WATER LEAKS UNDER AIR VENTS UNDER WINDOW WIPERS ,BODY SEAMS LET WATER IN CAR AS FAST AS IT WILL RUN.HAVE SEALED 1 LEAK WITH SILICONE ON SEAM ON PASSENGER SIDE. CARPET AND MAT ON DRIVER SIDE NOW GETTING WET AND STINKS. REPLACED WINDSHIELD 6-27-03,SO I KNOW THAT WAS NOT THE PROBLEM. CAR BOUGHT NEW AND HAS NEVER BEEN IN ACCIDENT. D…
Read full complaint
WATER LEAKS UNDER AIR VENTS UNDER WINDOW WIPERS ,BODY SEAMS LET WATER IN CAR AS FAST AS IT WILL RUN.HAVE SEALED 1 LEAK WITH SILICONE ON SEAM ON PASSENGER SIDE. CARPET AND MAT ON DRIVER SIDE NOW GETTING WET AND STINKS. REPLACED WINDSHIELD 6-27-03,SO I KNOW THAT WAS NOT THE PROBLEM. CAR BOUGHT NEW AND HAS NEVER BEEN IN ACCIDENT. DEALERS SERVICE MGR.CLAIMS THERE HAS NOT BEEN ANY PROBLEMS,BUT MY MECHANIC,KNOWS A CHRYSLER MECHANIC THERE,AND HE SAYS THERE ARE PLENTY OF COMPLAINTS. THEY HAVE EVEN SPRAYED RUBBERIZED UNDERCOATING ON SEAMS AND SURROUNDING AREAS TO SEAL WATER LEAKS.
NHTSA ODI #10070503
Mileage unknown · Sep 18, 2001
Structure
WHILE CHECKING THE BATTERY THE HOOD FELL DOWN.
NHTSA ODI #9003917
Mileage unknown · Aug 6, 2001
StructureSuspension
HAD TAKEN VEHICLE TO DEALER FOR REAR ALIGNMENT, BUT COULD NOT BE PERFORMED DUE TO CORROSION ANDDETERIORATION ON SUBFRAME MOUNTS. CONSUMER TALKED TO MANUFACTURER, AND HE WAS UNABLE TO TAKE CARE OF THIS SITUATION. *AK
NHTSA ODI #893589
Mileage unknown · Jul 25, 2001
Structure
BODY SHOP SAID ENTIRE HOOD MUST BE REPLACED BECAUSE IT IS COMING FROM UNDER THE HOOD AND NOT RUSTING FROM THE TOP THROUGH THE HOOD. ESTIMATED COST WAS $950.00. CHRYSLER HAS A 5 YEAR WARRANTY/100,000 MILES ON RUST ON THIS VEHICLE. PLEASE ADVISE AS TO WHAT TO DO IMMEDIATELY. THANK YOU. *AK
NHTSA ODI #749135
Mileage unknown · Feb 1, 1999
Electrical SystemStructure
HORN BUTTON DESIGN IS VERY SMALL AND DIFFICULT TO FIND. MJS
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT WITH 3.5L ENGINES. THE FUEL INJECTION DELIVERY SYSTEM CAN LEAK FUEL FROM SOME OF THE SEALING O-RINGS OR FROM HAIR LINE CRACKS IN THE THERMOSET FUEL INJECTION RAIL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL RAIL O-RINGS AND REINFORCE THE OUTLET (PASSENGER) SIDE FUEL RAIL. VEHICLES SHOWING FUEL LEAKAGE ON THE OUTLET FUEL RAIL MUST HAVE THE OUTLET RAIL REPLACED WHICH INCLUDES CHANGING THE UPPER AND LOWER INJECTOR O-RINGS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS OR FROM A CRACKED FUEL LINE, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP04007 · Fuel Rail, Brake Fluid, Chassis
Opened Oct 13, 2004 · Closed Oct 27, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail; Service Brakes, Hydraulic:fluid; Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Service Brakes, Hydraulic:fluid
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
RQ98018 · Fuel Injection Delivery System Fuel Leak
Opened Oct 7, 1998 · Closed Jul 8, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System
No summary supplied.
1997 Chrysler Concorde Problems, Complaints & Recalls | Skip That Year
Illustration