TL* THE CONTACT OWNS A 1997 CHRYSLER CONCORDE. THE CONTACT STATED THE VEHICLE WAS INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 98V184000 (FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM) AND THE VEHICLE WAS REPAIRED. EIGHT YEARS AFTER THE VEHICLE WAS REPAIRED SHE NOTICED FUEL LEAKING FROM THE VEHICLE WHILE IT WAS PARKED. …
Read full complaint
TL* THE CONTACT OWNS A 1997 CHRYSLER CONCORDE. THE CONTACT STATED THE VEHICLE WAS INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 98V184000 (FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM) AND THE VEHICLE WAS REPAIRED. EIGHT YEARS AFTER THE VEHICLE WAS REPAIRED SHE NOTICED FUEL LEAKING FROM THE VEHICLE WHILE IT WAS PARKED. THE CONTACT STATED FUEL WOULD ALSO LEAK WHILE DRIVING. THE VEHICLE WAS TAKEN AN INDEPENDENT MECHANIC WHO STATED THE FUEL INJECTOR SYSTEM WAS LEAKING AND THE O-RING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10410014
71,000 miles · Dec 29, 2004
Fuel System, Gasoline
(1) ALWAYS SMELLED GASOLINE AFTER DRIVING CAR FOR A WHILE. A COUPLE OF REPAIR PLACES COULD NOT FIND A PROBLEM. I FINALLY FIGURED OUT MYSELF WHERE THE LEAK WAS IN THE ENGINE AND POINTED IT OUT TO A REPAIR MAN. (2) THIS REPAIR MAN TOLD ME IT DEFINITELY WAS LEAKING AND IF I LET IT GO ANY LONGER THERE WOULD CERTAINLY BE AN ENGINE…
Read full complaint
(1) ALWAYS SMELLED GASOLINE AFTER DRIVING CAR FOR A WHILE. A COUPLE OF REPAIR PLACES COULD NOT FIND A PROBLEM. I FINALLY FIGURED OUT MYSELF WHERE THE LEAK WAS IN THE ENGINE AND POINTED IT OUT TO A REPAIR MAN. (2) THIS REPAIR MAN TOLD ME IT DEFINITELY WAS LEAKING AND IF I LET IT GO ANY LONGER THERE WOULD CERTAINLY BE AN ENGINE FIRE. WHEN I QUESTIONED HIM ABOUT OTHER OCCURRENCES OF THIS PROBLEM, HE SAID THAT HE HAD SEEN THIS HAPPEN MORE OFTEN ON CHRYSLER'S THAN ANY OTHER CAR. (3) HE REPLACED THE FUEL PRESSURE REGULATOR, AS WELL AS THE FUEL DAMPNER ASSEMBLY WITH FUEL RAIL. I DON'T HAVE THE OLD PARTS. LET ME KNOW IF YOU NEED THEM AND I WILL TRY TO OBTAIN THEM. *NM
NHTSA ODI #10104737
42,000 miles · Dec 17, 2004
Fuel System, Gasoline
WHILE TRAVELING CONSUMER SMELLED FUMES, AND IMMEDIATELY TOOK VEHICLE TO A DEALER SINCE HE FOUND OUT THERE WAS A RECALL FOR A FUEL RAIL. DEALER TOLD CONSUMER THAT THE RECALL WAS NOT ON DRIVER'S SIDE OF THE VEHICLE BUT ON PASSENGER'S SIDE.. NO RECALLS FOUND. *AK THE CUSTOMER WAS TOLD THAT THE VEHICLE HAD A PROBLEM WITH T…
Read full complaint
WHILE TRAVELING CONSUMER SMELLED FUMES, AND IMMEDIATELY TOOK VEHICLE TO A DEALER SINCE HE FOUND OUT THERE WAS A RECALL FOR A FUEL RAIL. DEALER TOLD CONSUMER THAT THE RECALL WAS NOT ON DRIVER'S SIDE OF THE VEHICLE BUT ON PASSENGER'S SIDE.. NO RECALLS FOUND. *AK THE CUSTOMER WAS TOLD THAT THE VEHICLE HAD A PROBLEM WITH THE O RINGS. RECALL FOUND: NHTSA CAMPAIGN ID NUMBER : 98V184000 RECALL DATE : AUG 06, 1998 *TC
NHTSA ODI #10101378
Mileage unknown · Dec 3, 2004
Fuel System, Gasoline
THE CONSUMER STATED THAT WHILE DRIVING HE SMELLED A FUEL SMELL. THE CONSUMER WAS INFORMED THAT THE VEHICLE HAD A PROBLEM WITH THE O RINGS. CAMPAIGN ID NUMBER : 98V184000 *TC THIS PROBLEM MADE THE CONSUMER AND HIS WIFE EXTREMELY SICK. THE LEFT FRONT FUEL RAIL WAS FOUND LEAKING. *SC *JB
NHTSA ODI #10104964
Mileage unknown · Oct 19, 2004
Fuel System, Gasoline
THE CONSUMER RECEIVED A RECALL(NHTSA 98V184000) REGARDING THE FUEL RAIL. THE DEALER REFUSED TO PERFORM THE RECALL. *JB
NHTSA ODI #10097178
Mileage unknown · Oct 12, 2004
Fuel System, GasolineFire
WHILE BACKING OUT OF THE GARAGE, WITHOUT WARNING THE VEHICLE CAUGHT FIRE. THE CONSUMER EXTINGUISHED THE FIRE OUT AND THE VEHICLE WAS PUSHED BACK INTO THE GARAGE. THE DRIVER HAS CONTACTED THE DEALER FOR INSPECTION AND A APPOINTMENT. THE RECALL WAS NOT FOR THIS VEHICLE. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
NHTSA ODI #10096633
Mileage unknown · Oct 10, 2003
Fuel System, Gasoline
FUEL PUMP DETACHED FROM VEHICLE, CAUSING GASOLINE TO LEAK WHILE FUELING. *AK
NHTSA ODI #10042727
Mileage unknown · Feb 26, 2003
Fuel System, Gasoline
THERE WAS A STRONG SMELL OF GAS FUMES IN THE VEHICLE.*JB
NHTSA ODI #10009461
Mileage unknown · Aug 18, 2001
Fuel System, Gasoline
CHRYSLER CONCORD RECALLED LATE 1998-CAR LEFT AT CENTRAL AND ADVISED NEXT MORNING CAR WOULD NOT START. AT THE TIME CAR HAD ABOUT 35,000 MILES. DEALER TALKED WIFE INTO 800 DOLLARS WORTH OF WORK ON ENGINE INCLUDING INJECTION CLEANING---FUNNY THATS WHAT IT WAS IN FOR ON RE-CALL SO WE NOW KNOW 3 YEARS LATER. CA BEGAN LEAKING FUEL JU…
Read full complaint
CHRYSLER CONCORD RECALLED LATE 1998-CAR LEFT AT CENTRAL AND ADVISED NEXT MORNING CAR WOULD NOT START. AT THE TIME CAR HAD ABOUT 35,000 MILES. DEALER TALKED WIFE INTO 800 DOLLARS WORTH OF WORK ON ENGINE INCLUDING INJECTION CLEANING---FUNNY THATS WHAT IT WAS IN FOR ON RE-CALL SO WE NOW KNOW 3 YEARS LATER. CA BEGAN LEAKING FUEL JULY OF 2001 AND TOOK CAR TO PEP BOYS TO SEE WHAT PROBLEM WAS . AFTER REPLACING O RINGS STILL LEAKED , CAR RETURNED TO PEP BOYS . THEY NOW HAD TO REPLACE INJECTORS TO SEE IF THAT MUST BE PROBLEM. CAR STILL LEAKED .THEY CALLED CHRYSLER AND INFORMED BY CHRYSLER THAT THE RAILS MUST OF CRACKED AGAIN. BUT DEALER NOT RESPONSABLE BECAUSE OVER 1 YR WARRENTY AND 12000 MILES ,SO I HAD TO HAVE PEP BOYS ORDER PART S TO DO THE REPAIR. SINCE CAR WAS ALL APART AT THERE STORE AND COST TO MUCH TO TOW TO A DEALED. FOOT /NOTE I TOOK SICK AND WENT TO EMGCY ROOM FOR ..AS DR. STATED COULD OF BEEN FROM THE FUMES. BAD INFECTION IN THROAT PUT ON PEN VK . THIS WAS 1 DAY AFTER PROBLEM TOTAL COST SO FAR 1300.00 NOT INCLUDING LOSS OF WORK FOR WEEK DUE TO WELLNESS. ROBERT F TIERNEY. *AK
NHTSA ODI #750699
Mileage unknown · Nov 1, 2000
Fuel System, Gasoline
TSB # 790 WAS FOR THE LEFT FUEL INJECTION RAIL LEAKING (CRACKED). MY RIGHT RAIL IS LEAKING!!! I CALLED CHRYSLER @ 1-800 992-1997 AND TRIED TO REPORT THIS. THEY INFORMED ME THAT THE RECALL IN JANUARY, 1999 ONLY AFFECTED THE LEFT FUEL INJECTION RAIL. I COULD HAVE HAD A FIRE AS THE GASOLINE WAS LEAKING (IN VOLUME) ON THE TOP …
Read full complaint
TSB # 790 WAS FOR THE LEFT FUEL INJECTION RAIL LEAKING (CRACKED). MY RIGHT RAIL IS LEAKING!!! I CALLED CHRYSLER @ 1-800 992-1997 AND TRIED TO REPORT THIS. THEY INFORMED ME THAT THE RECALL IN JANUARY, 1999 ONLY AFFECTED THE LEFT FUEL INJECTION RAIL. I COULD HAVE HAD A FIRE AS THE GASOLINE WAS LEAKING (IN VOLUME) ON THE TOP OF MY ENGINE AND RUNNING DOWN THE ENGINE BLOCK ONTO THE GROUND. I THINK CHRYSLER NEEDS TO BE AWARE OF THIS POTENTIAL PROBLEM. I ATTEMPTED TO INFORM THEM OF THIS TODAY AND I WAS TOLD ME TO GO TO A DEALER. I DO MY OWN CAR REPAIR WORK AND KNOW A LITTLE ABOUT VEHICLES. I ALSO KNOW SOMETHING ABOUT PRODUCT SAFETY AS I AM THE PRODUCT SAFETY OFFICER WHERE I AM EMPLOYED. I HAVE DETAILED DIGITIAL PHOTOS OF THE RAIL WHILE IT IS LEAKING. THEY ARE GOOD PICTURES. THESE PICTURES ARE WORTH MORE THAN 1000 WORDS!!! IF YOU WANT THE PICTURES, PLEASE ADVISE.*AK
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT WITH 3.5L ENGINES. THE FUEL INJECTION DELIVERY SYSTEM CAN LEAK FUEL FROM SOME OF THE SEALING O-RINGS OR FROM HAIR LINE CRACKS IN THE THERMOSET FUEL INJECTION RAIL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL RAIL O-RINGS AND REINFORCE THE OUTLET (PASSENGER) SIDE FUEL RAIL. VEHICLES SHOWING FUEL LEAKAGE ON THE OUTLET FUEL RAIL MUST HAVE THE OUTLET RAIL REPLACED WHICH INCLUDES CHANGING THE UPPER AND LOWER INJECTOR O-RINGS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS OR FROM A CRACKED FUEL LINE, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP04007 · Fuel Rail, Brake Fluid, Chassis
Opened Oct 13, 2004 · Closed Oct 27, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail; Service Brakes, Hydraulic:fluid; Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Service Brakes, Hydraulic:fluid
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
RQ98018 · Fuel Injection Delivery System Fuel Leak
Opened Oct 7, 1998 · Closed Jul 8, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System
No summary supplied.
1997 Chrysler Concorde Problems, Complaints & Recalls | Skip That Year
Illustration