Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
840–25K
4025–50K
4850–75K
4275–100K
42100–150K
11150K+
267 reports with mileage · 49 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports7 fire reports9 injury reports
What owners actually said
316 reports
9,415 miles · Mar 21, 2006
EquipmentStructure
DT*: THE CONTACT STATED THE TONNEAU COVER USED ON THE BED OF THE PICKUP TRUCK DOES NOT CATCH PROPERLY. THE CLIPS HOLDING THE LID IN PLACE ONLY CATCH 1/8" ON THE BED OF THE TRUCK. AT HIGHWAY SPEEDS, THE LID OPENS AND THE CONTENTS OF THE TRUCK BED EJECTS. THE MANUFACTURER OF THE TONNEAU COVER IS STEFFENS ENTERPRISES INC. THE …
Read full complaint
DT*: THE CONTACT STATED THE TONNEAU COVER USED ON THE BED OF THE PICKUP TRUCK DOES NOT CATCH PROPERLY. THE CLIPS HOLDING THE LID IN PLACE ONLY CATCH 1/8" ON THE BED OF THE TRUCK. AT HIGHWAY SPEEDS, THE LID OPENS AND THE CONTENTS OF THE TRUCK BED EJECTS. THE MANUFACTURER OF THE TONNEAU COVER IS STEFFENS ENTERPRISES INC. THE CONTACT HAS BEEN UNSUCCESSFUL IN CONTACTING THE MANUFACTURER. UPDATED 05/04/06
NHTSA ODI #10153300
500 miles · Mar 20, 2006
Suspension
NOTICED VEHICLE VIBRATION AT 45 MPH LIKE TIRE OUT OF ROUND. AT 55 MPH AND GREATER, VIBRATION FELT LIKE TIRE OUT OF BALANCE. GM TELLS ME PROBLEM IS NORMAL, WILL NOT CORRECT. GM CALLS THE PROBLEM "BEAMING", AND SUGGESTS PLACING 500 LBS IN BED OF TRUCK. TRIED THIS AND VIBRATION STILL EXISTS. TRUCK SHAKES SO BAD AT 65 MPH THAT IT IS…
Read full complaint
NOTICED VEHICLE VIBRATION AT 45 MPH LIKE TIRE OUT OF ROUND. AT 55 MPH AND GREATER, VIBRATION FELT LIKE TIRE OUT OF BALANCE. GM TELLS ME PROBLEM IS NORMAL, WILL NOT CORRECT. GM CALLS THE PROBLEM "BEAMING", AND SUGGESTS PLACING 500 LBS IN BED OF TRUCK. TRIED THIS AND VIBRATION STILL EXISTS. TRUCK SHAKES SO BAD AT 65 MPH THAT IT IS UNSTABLE IN CURVES, MAKING IT DIFFICULT TO HANDLE. THE VEHICLE CANNOT CONTINUE TO BE RELIABLE WITH THIS CONTINUOUS VIBRATION EATING AWAY AT THE SUSPENSION SYSTEM. THE VEHICLE NOW HAS DEVELOPED A HARMONIC NOISE AT 45 MPH AND LESS, WHICH THE DEALER TELLS ME IS ALSO NORMAL AND WILL NOT REPAIR. *NM
NHTSA ODI #10153281
15,561 miles · Mar 15, 2006
SteeringWheels
DT*: THE CONTACT STATED THE FRONT DRIVER SIDE WHEEL MAKES A CLUNKING NOISE AND THE STEERING WHEEL IS INOPERABLE. THE DEALER INSPECTED THE VEHICLE SEVERAL TIMES AND WAS UNABLE TO DETERMINE THE PROBLEM; HOWEVER THE STEERING SHAFT WAS LUBRICATED. ADDITIONALLY, AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE AND DETERMINED THE STEE…
Read full complaint
DT*: THE CONTACT STATED THE FRONT DRIVER SIDE WHEEL MAKES A CLUNKING NOISE AND THE STEERING WHEEL IS INOPERABLE. THE DEALER INSPECTED THE VEHICLE SEVERAL TIMES AND WAS UNABLE TO DETERMINE THE PROBLEM; HOWEVER THE STEERING SHAFT WAS LUBRICATED. ADDITIONALLY, AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE AND DETERMINED THE STEERING BOX WAS LOOSE.
NHTSA ODI #10152749
23,000 miles · Mar 1, 2006
Steering
DT*: THE CONTACT STATED THE STEERING COLUMN KNOCKED AT ANY SPEED. THE DEALERSHIP GREASED THE STEERING COLUMN, BUT THIS DID NOT CORRECT THE PROBLEM. THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP, BUT THE SERVICE MANAGER STATED THERE WERE NO REPAIRS AVAILABLE AND THE STEERING COLUMN WOULD BE GREASED AGAIN.
NHTSA ODI #10151545
32 miles · Feb 23, 2006
Service Brakes, HydraulicSuspensionTires
2005 CHEVROLET CREW CAB 1/2 TON TWO WHEEL DRIVE HAS HAD A VIBRATION WHILE DRIVING AND WHILE BRAKING SINCE THE FIRST TEST DRIVE. THE SALESMAN PROMISED IT WAS JUST THE TIRES WITH FLAT SPOTS AND WOULD GO AWAY. JOHN KEATING CHEVY. AS CHANGED THE FRONT ROTORS THE BACK DRUMS, TWO TIRES ALIGNED THE FRONT END PUT IN STEERING KIT. THE T…
Read full complaint
2005 CHEVROLET CREW CAB 1/2 TON TWO WHEEL DRIVE HAS HAD A VIBRATION WHILE DRIVING AND WHILE BRAKING SINCE THE FIRST TEST DRIVE. THE SALESMAN PROMISED IT WAS JUST THE TIRES WITH FLAT SPOTS AND WOULD GO AWAY. JOHN KEATING CHEVY. AS CHANGED THE FRONT ROTORS THE BACK DRUMS, TWO TIRES ALIGNED THE FRONT END PUT IN STEERING KIT. THE TRUCK STILL HAS THE VIBRATION AND NOW THE FRONT LEFT AND THE REAR BRAKES ARE LOCKING UP. IF YOU BRAKE HARD THE BRAKES SKIDS ON THE LEFT SIDE. I HAVE CONTACTED CUSTOMER SERVICE THEY WILL NOT RETURN MY CALLS. I WAS AT THE DEALERSHIP ON 2/21/06 I TRIED TO TALK THE OWNER I LEFT MY NAME AND I WAS THERE FOR 5 HOURS HE NEVER CONTACTED ME. I CALLED HIM THAT NIGHT AROUND 6:15 AND SPOKE WITH HIM, HE WANTS TO RIDE IN THE TRUCK, I CALLED THE NEXT AFTERNOON LEFT MY NUMBER AND ASKED FOR APPOINTMENT. I CALLED AGAIN 2/23/06 AROUND 2:00 AGAIN I LEFT MY NUMBER. *JB
NHTSA ODI #10151039
10,000 miles · Feb 21, 2006
Steering
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING COLUMN MADE A CLUNKING NOISE. THIS WAS MORE FREQUENT WHEN MAKING A LEFT HAND TURN. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THE STEERING COLUMN WAS GREASED. THIS REPAIR WORKED FOR A SHORT TIME. HOWEVER, THE STEERING COLUMN AGAIN MAKES THE CL…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING COLUMN MADE A CLUNKING NOISE. THIS WAS MORE FREQUENT WHEN MAKING A LEFT HAND TURN. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THE STEERING COLUMN WAS GREASED. THIS REPAIR WORKED FOR A SHORT TIME. HOWEVER, THE STEERING COLUMN AGAIN MAKES THE CLUNKING NOISE.
NHTSA ODI #10150763
Mileage unknown · Feb 16, 2006
Latches/locks/linkages
CONSUMER REQUESTING THE AUTOMATIC DOOR LOCKS BE DEACTIVATED FOR THE SAFETY OF PASSENGERS IN CASE OF AN EMERGENCY. *TS ***NO ANSWER REQUIRED****JB
NHTSA ODI #10151884
1,500 miles · Feb 14, 2006
Steering
THE POWER STEERING STOPS WORKING AT LOW SPEED OR PARKED. I HAVE CONTACTED GM SEVERAL TIMES REGARDING THIS AND THEY SAY THERE IS NO FIX AT THIS TIME. DEALERSHIP HAS WITNESSED AND DOCUMENTED THE PROBLEM. I FEEL THIS IS BECOMING A SAFETY ISSUE, AS IT GETS WORSE..IE. MAKE COMMON, EVERY DAY.
NHTSA ODI #10150207
22,000 miles · Jan 31, 2006
Electrical System
DT*: THE CONTACT STATED THAT THE VEHICLE STALLED INTERMITTENTLY WHILE DRIVING 50-60 PH. THIS HAPPENS WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALERSHIP BUT THEY WERE UNABLE UNABLE TO DUPLICATE THE PROBLEM. THE CONTACT BELIEVES THIS IS AN ELECTRICAL OR ENGINE PROBLEM. UPDATED 2/28/2006 - THE CONSUMER SMELLED SOMETHING B…
Read full complaint
DT*: THE CONTACT STATED THAT THE VEHICLE STALLED INTERMITTENTLY WHILE DRIVING 50-60 PH. THIS HAPPENS WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALERSHIP BUT THEY WERE UNABLE UNABLE TO DUPLICATE THE PROBLEM. THE CONTACT BELIEVES THIS IS AN ELECTRICAL OR ENGINE PROBLEM. UPDATED 2/28/2006 - THE CONSUMER SMELLED SOMETHING BURNING AND THE VEHICLE WOULD NOT START. THE VEHICLE CONTINUED TO BLOW FUSES. THE TECHNICIAN FOUND A SHOTED WIRE UNDER THE STEERING COLUMN. *NM
NHTSA ODI #10149139
7,000 miles · Jan 19, 2006
Service Brakes, Hydraulic
DT*: THE CONTACT STATED THE BRAKES ON THE VEHICLE ARE NOT WORKING PROPERLY. WHEN APPLYING THE BRAKES, THE REAR BRAKES DO NOT WORK. THE VEHICLE WAS TAKEN TO THE DEALERSHIP TO DETERMINE WHAT THE PROBLEM. THE DEALERSHIP ADJUSTED THE REAR BRAKES AND EXPLAINED THE VEHICLE WAS REPAIRED. AFTER DRIVING THE VEHICLE FOR A PERIOD OF TIME, …
Read full complaint
DT*: THE CONTACT STATED THE BRAKES ON THE VEHICLE ARE NOT WORKING PROPERLY. WHEN APPLYING THE BRAKES, THE REAR BRAKES DO NOT WORK. THE VEHICLE WAS TAKEN TO THE DEALERSHIP TO DETERMINE WHAT THE PROBLEM. THE DEALERSHIP ADJUSTED THE REAR BRAKES AND EXPLAINED THE VEHICLE WAS REPAIRED. AFTER DRIVING THE VEHICLE FOR A PERIOD OF TIME, IT IS EXPERIENCING THE SAME PROBLEMS WITH THE BRAKES. THE VEHICLE WAS TAKEN IN A SECOND TIME FOR REPAIRS TO BE MADE. AT THAT TIME THE DRUMS WERE TURNED. THE VEHICLE WAS DRIVEN AGAIN FOR A PERIOD OF TIME, WHILE STILL EXPERIENCING THE SAME PROBLEMS WITH THE BRAKES. THE VEHICLE WAS TAKEN BACK A THIRD TIME AND AT THIS TIME THE DEALERSHIP IS UNABLE TO DUPLICATE THE PROBLEM. *NM
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration