Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
840–25K
4025–50K
4850–75K
4275–100K
42100–150K
11150K+
267 reports with mileage · 49 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports7 fire reports9 injury reports
What owners actually said
316 reports
1 miles · May 17, 2006
Suspension
DT*: THE CONTACT STATED THE FRONT SUSPENSION IS INADEQUATE WHILE DRIVING ON CONCRETE POURED ROAD CONDITIONS. THE SPEED OF THE VEHICLE MUST BE DECREASED OR THE VEHICLE WILL GO ABOUT A FOOT AND HALF INTO THE AIR. THE DEALERSHIP HAS BEEN ALERTED AND THE SHOCKS HAVE BEEN REPLACED TWICE HOWEVER, THIS DID NOT CORRECT THE PROBLEM. T…
Read full complaint
DT*: THE CONTACT STATED THE FRONT SUSPENSION IS INADEQUATE WHILE DRIVING ON CONCRETE POURED ROAD CONDITIONS. THE SPEED OF THE VEHICLE MUST BE DECREASED OR THE VEHICLE WILL GO ABOUT A FOOT AND HALF INTO THE AIR. THE DEALERSHIP HAS BEEN ALERTED AND THE SHOCKS HAVE BEEN REPLACED TWICE HOWEVER, THIS DID NOT CORRECT THE PROBLEM. THE MANUFACTURER WAS ALERTED AND A COMPLAINT WAS FILED.
NHTSA ODI #10157704
Mileage unknown · May 1, 2006
Suspension
CONSUMER 2005 SILVERADO MAKES A VERY LOUD WIND BLOWING NOISE WHILE DRIVING. *TS *JB
NHTSA ODI #10157347
Mileage unknown · Apr 18, 2006
Steering
I SPECIAL ORDERED A 2005 CHEVY 4X4 TRUCK BECAUSE I WANTED A SINGLE CAB. WHEN I FIRST GOT IT, SOMETHING DIDN'T SEEM RIGHT ABOUT IT AND ABOUT THE 3RD DAY I REALIZED THE STEERING WHEEL WAS OFF CENTER. I TOOK IT BACK TO GUS PAULOS CHEVROLET IN SLC UTAH AND THEY WERE SEEMINGLY STUNNED ALSO. THE SALESMAN ACTUALLY WENT AROUND T…
Read full complaint
I SPECIAL ORDERED A 2005 CHEVY 4X4 TRUCK BECAUSE I WANTED A SINGLE CAB. WHEN I FIRST GOT IT, SOMETHING DIDN'T SEEM RIGHT ABOUT IT AND ABOUT THE 3RD DAY I REALIZED THE STEERING WHEEL WAS OFF CENTER. I TOOK IT BACK TO GUS PAULOS CHEVROLET IN SLC UTAH AND THEY WERE SEEMINGLY STUNNED ALSO. THE SALESMAN ACTUALLY WENT AROUND THE LOT LOOKING TO SEE IF OTHER TRUCKS WERE OFF CENTER ALSO. THEY WERE. THERE WAS A FACTORY REP THERE , HAVING SOME 30 YRS WITH GMC AND IT TOOK HIM A LONG TIME TO SEE WHAT I WAS TALKING ABOUT ALSO. SALESMAN SAID HE'D CALL BACK TO THE FACTORY AND FIND OUT WHY THEY WERE LIKE THAT. CALLED ME A COUPLE DAYS LATER AND SAID IT WAS A SAFETY FEATURE. WHAT?!?!?! A SAFETY FEATURE FOR HOW MANY YEARS AND YOU DIDN'T KNOW THAT??? AND HOW COME THE TRUCKS ARE OFF CENTER AND THE CARS ARE NOT??? HOW COME FORD AND DODGE AREN'T OFF CENTERING THEIRS!??? IT WAS SCARY DRIVING THIS TRUCK IN THE RAIN AS I FELT I HAD NO CONTROL. LIKE DRIVING ON ICE! I USED IT TO PULL MY HORSE TRAILER (MINI 6 HORSE SLANT) AND MY TRAILER SWAYED ON THIS TRUCK! I HAVE BEEN PULLING HORSE TRAILERS ALL OVER THE US SINCE THE EARLY 70S AND HAVE NEVER HAD A TRAILER SWAY ON ME BEFORE! NOT EVER! ON THE FREEWAY, WHEN A SEMI WOULD PASS , THEY WOULD LITERALLY BLOW ME (WITH THE TRAILER) TO THE OTHER SIDE OF THE LANE!!! WHEN USING CRUISE CONTROL, IT WOULD ACCELERATE ON THE LEVEL/FLAT AND NOT ON HILLS!!! I LIVE AT THE END OF A DIRT ROAD AND WHEN IT GOT WASHBOARDY THAT TRUCK WOULD PRACTICALLY JUMP OFF THE ROAD! MY TOYOTA RIDES IT LIKE IT'S JUST SLIGHTLY BUMPY! THIS TRUCK WAS A LEMON! A DANGER TO DRIVE ON THE ROAD! OTHER PEOPLE THAT RODE IN THE TRUCK WITH ME COULD TELL/FEEL THE INSECURITY OF IT! MY VET (HORSE) TOLD ME HE ONCE (AND NEVER WILL AGAIN) OWNED A CHEVY TRUCK AND WITH THE VET BOX ON THE BACK, HIS TRUCK SWAYED ALSO! HE AGREED IT WAS LIKE DRIVING ON ICE. IF YOU NEED MORE DETAILS, I'D BE MORE THAN HAPPY TO SUPPLY YOU WITH THEM. *NM
NHTSA ODI #10155631
19,000 miles · Apr 17, 2006
Steering
VEHICLE STEERING SHAKES WHEN TURNING OR BREAKING. *NM
NHTSA ODI #10155491
Mileage unknown · Apr 17, 2006
Suspension
FRONT END/STEERING UNSTABLE - JUMPS AROUND - WHEN HITTING ROUGH SPOTS IN ROAD SURFACE FROM 5/8/05 TO PRESENT. *NM
NHTSA ODI #10155463
Mileage unknown · Apr 11, 2006
Engine And Engine CoolingPower Train
2005 SILVERADO HYBRID ENGINE TURNS OFF AT STOPS WHEN BRAKE IS APPLIED. *TS THE HYBRID TURNS ENGINE OFF AT STOPS WHEN BRAKE IS APPLIED. THE CONSUMER FEELS THAT IT TAKES TOO LONG FOR THE ENGINE TO PICK UP POWER AFTER TAKING FOOT OFF THE BRAKE AND APPLYING THE ACCELERATOR. THE CONSUMER FEELS THAT THE DELAY IS DANGEROUS WHEN TRY…
Read full complaint
2005 SILVERADO HYBRID ENGINE TURNS OFF AT STOPS WHEN BRAKE IS APPLIED. *TS THE HYBRID TURNS ENGINE OFF AT STOPS WHEN BRAKE IS APPLIED. THE CONSUMER FEELS THAT IT TAKES TOO LONG FOR THE ENGINE TO PICK UP POWER AFTER TAKING FOOT OFF THE BRAKE AND APPLYING THE ACCELERATOR. THE CONSUMER FEELS THAT THE DELAY IS DANGEROUS WHEN TRYING TO ENTER FAST MOVING TRAFFIC FROM A STOP. WHILE STOPPED ON AN INCLINE VEHICLE ROLLS BACKWARDS WHILE THE CONSUMER'S FOOT IS IN TRANSITION FROM THE BRAKE TO THE ACCELERATOR PEDAL. *NM
NHTSA ODI #10156222
Mileage unknown · Apr 3, 2006
Power Train
2005 Z71 SILVERADO PICKUP MAKES A LOUD NOISE AND MOVES IN A FORWARD OR BACKWARD MOTION WHEN STARTING THE VEHICLE AFTER IT HAS SAT OVER NIGHT. *TS *JB
NHTSA ODI #10155176
15,800 miles · Mar 31, 2006
Tires
TIRE BLOW OUT, SIDE WALL FAILURE. THIS OCCURRED AT 70 MPH. NO INDICATION OF TIRE PROBLEM UNTIL FAILURE. *JB
NHTSA ODI #10154269
30,100 miles · Mar 28, 2006
Air BagsCrashInjury
DT*: THE CONTACT STATED THE VEHICLE WAS INVOLVED IN AN ACCIDENT ON DRY ROADS. TWO VEHICLES COLLIDED IN FRONT OF THE CONTACT, CAUSING AN EMERGENCY BRAKING SITUATION. THE CONTACT COLLIDED WITH THE REAR OF THE SECOND VEHICLE, AND THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS INJURED IN THE ACCIDENT. AN INDEPENDENT REPAIR SHOP W…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE WAS INVOLVED IN AN ACCIDENT ON DRY ROADS. TWO VEHICLES COLLIDED IN FRONT OF THE CONTACT, CAUSING AN EMERGENCY BRAKING SITUATION. THE CONTACT COLLIDED WITH THE REAR OF THE SECOND VEHICLE, AND THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS INJURED IN THE ACCIDENT. AN INDEPENDENT REPAIR SHOP WAS CONSULTED AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM.
NHTSA ODI #10153906
18,000 miles · Mar 24, 2006
Vehicle Speed Control
DT*: THE CONTACT STATED THE SPEEDOMETER IS INOPERABLE. THE DEALERSHIP DETERMINED THE SPEEDOMETER NEEDS TO BE REPLACED
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration