Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
840–25K
4025–50K
4850–75K
4275–100K
42100–150K
11150K+
267 reports with mileage · 49 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports7 fire reports9 injury reports
What owners actually said
316 reports
281,000 miles · Jul 20, 2021
Air BagsSeat BeltsCrashInjury
The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving approximately 50 mph, he lost control of the vehicle due to losing consciousness. The vehicle left the roadway and went airborne and crashed with a road sign landing in a field. None of the airbags deployed and only the seatbelt lap belt tensioned…
Read full complaint
The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving approximately 50 mph, he lost control of the vehicle due to losing consciousness. The vehicle left the roadway and went airborne and crashed with a road sign landing in a field. None of the airbags deployed and only the seatbelt lap belt tensioned not the shoulder strap. The contact sustained injuries such as several lacerations across the face and inside the mouth, and broken L1 vertebrae. The contact mentioned he fractured the steering wheel with his face during the impact. A police report was filed and the vehicle was towed to a local lot then towed again to the contacts insurance lot where it was awaiting a diagnosis. The manufacturer was not informed of the failure. The failure mileage was approximately 281,000.
NHTSA ODI #11425653
105,000 miles · Feb 9, 2016
Service Brakes
THE VEHICLES BRAKES ARE CORRODING AND FAILED ALMOST CAUSING AN ACCIDENT ON 2/09/2016 WHEN THE VEHICLE WAS IN MOTION (AT THE INTERSECTION OF IL ROUTE 34 AND WOLFS CROSSING)
NHTSA ODI #10825082
Mileage unknown · Dec 27, 2015
Service Brakes
PEDAL GOES ON DOWN WHEN PRESSED -- SEEMS LIKE ABS ISN'T WORKING PROPERLY
NHTSA ODI #10816342
160,000 miles · Nov 30, 2015
Service Brakes
BREAK LINES CORRODED THROUGH TO FAILURE. THE FAILURE OCCURRED JUST AFTER EXITING A HIGHWAY. ABS ENGAGED DUE TO ICY CONDITIONS THE NEXT TIME I DEPRESSED THE BREAK PEDDLE IT WENT TO THE FLOOR WITHOUT THE BREAKS ENGAGING. TO THE BEST OF MY KNOWLEDGE NO WARNING LIGHT WAS PRESENT ON THE DASHBOARD. THE BREAKS FAILED WHILE DRIVING …
Read full complaint
BREAK LINES CORRODED THROUGH TO FAILURE. THE FAILURE OCCURRED JUST AFTER EXITING A HIGHWAY. ABS ENGAGED DUE TO ICY CONDITIONS THE NEXT TIME I DEPRESSED THE BREAK PEDDLE IT WENT TO THE FLOOR WITHOUT THE BREAKS ENGAGING. TO THE BEST OF MY KNOWLEDGE NO WARNING LIGHT WAS PRESENT ON THE DASHBOARD. THE BREAKS FAILED WHILE DRIVING AND RESULTED IN ME RUNNING A RED LIGHT. LUCKILY IT WAS EARLY IN THE MORNING AND NO ACCIDENT OCCURRED.
NHTSA ODI #10807596
97,000 miles · Nov 16, 2015
Electrical SystemFire
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS PARKED WITH THE AIR CONDITIONER SET ON LEVEL FIVE, THE BLOWER INTERMITTENTLY CLICKED OFF AND ON. THE CONTACT ALSO STATED THAT A BURNING SMELL EMITTED THROUGH THE VENTS OF THE VEHICLE. THE FAILURE RECURRED ON SEVERAL OCCASIONS UNTIL LEVEL FIVE AND FOUR SETTING…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS PARKED WITH THE AIR CONDITIONER SET ON LEVEL FIVE, THE BLOWER INTERMITTENTLY CLICKED OFF AND ON. THE CONTACT ALSO STATED THAT A BURNING SMELL EMITTED THROUGH THE VENTS OF THE VEHICLE. THE FAILURE RECURRED ON SEVERAL OCCASIONS UNTIL LEVEL FIVE AND FOUR SETTINGS NO LONGER WORKED. THE CONTACT INSPECTED THE CONNECTOR SW/POWER ST ADJUSTER AND DISCOVERED THAT THE WIRES WERE MELTED. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS NOT DIAGNOSED OR REPAIRED. THE DEALER INFORMED THE CONTACT THAT THE CONNECTOR AND RESISTOR FOR THE AIR CONDITIONER AND HEATER AND THE RESISTOR FOR THE HEATER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.
NHTSA ODI #10790722
130,000 miles · Nov 13, 2015
Service Brakes
SITTING AT BURGER KING DRIVE THRU WHEN BRAKE PEDAL WENT TO THE FLOOR. BRAKE LINES HAD RUPTURED DUE TO CORROSION. VEHICLE ONLY 10 YEARS OLD AND 130,000 MILES. HAD BRAKES CHECKED OFTEN AT SERVICE CENTERS, NO MENTION OF PROBLEM. GLAD THIS DIDN'T HAPPEN LAST MONTH WHEN I WAS BARRELING DOWN THE TENNESSEE HIGHWAY WITH A FULL LOAD …
Read full complaint
SITTING AT BURGER KING DRIVE THRU WHEN BRAKE PEDAL WENT TO THE FLOOR. BRAKE LINES HAD RUPTURED DUE TO CORROSION. VEHICLE ONLY 10 YEARS OLD AND 130,000 MILES. HAD BRAKES CHECKED OFTEN AT SERVICE CENTERS, NO MENTION OF PROBLEM. GLAD THIS DIDN'T HAPPEN LAST MONTH WHEN I WAS BARRELING DOWN THE TENNESSEE HIGHWAY WITH A FULL LOAD IN THE BACK OF MY TRUCK. NHTSA AND GM SHOULD BE ASHAMED FOR ALLOWING THIS TO CONTINUE. I AM SURE PEOPLE ARE DYING DUE TO THIS NEGLIGENCE AND FAULTY MATERIALS BEING USED.
NHTSA ODI #10790118
79,500 miles · Oct 23, 2015
Service Brakes
SUDDEN LOSS OF BRAKING POWER DUE TO BRAKE LINE RUPTURE WHILE ON THE EXIT RAMP OF THE FREEWAY. FOUND BRAKE LINES COMPLETELY RUSTED AND THEY WERE PAPER THIN IN MULTIPLE SPOTS. WILL HAVE TO REPLACE ALL BRAKE LINES ON THE VEHICLE. ALMOST LOST CONTROL OF THE VEHICLE. NOTE THAT VEHICLE HAS ALWAYS BEEN MAINTAINED BY DEALERSHIP.
NHTSA ODI #10785511
89,000 miles · Oct 16, 2015
Service Brakes
THE BRAKE PEDAL WENT COMPLETELY TO THE FLOOR WHEN OUR FRIEND TRIED TO STOP THE VEHICLE. A BRAKE LINE RUNNING ON TOP OF THE FRAME BEHIND THE RADIATOR HAD COMPLETELY RUSTED THRU, ALLOWING ALL OF THE BRAKE FLUID TO PUMP OUT OF THE SYSTEM. ALL OF THE STEEL BRAKE LINES ARE EXTREMELY RUSTY AND PROBABLY NEAR FAILURE.
NHTSA ODI #10782875
160,000 miles · Aug 9, 2015
Service Brakes
THESE PAST COUPLE OF WEEKS THE BRAKES ARE SHAKING WHEN I GO TO STOP. I HAVE C HANGED THE FRONT CALIPERS SINCE THIS IS WHERE IT IS HAPPENING SINCE THE CALIPERS WENT BAD SO DID THE ROTERS AN PADS SO THOSE NEEDED TO BE CHANGED ALSO...WHICH IS MONEY I DON'T HAVE .....IT WORKED FOR A TOTAL OF 4 DAYS THEN PROBLEM BEGAN AGAIN. PLEASE…
Read full complaint
THESE PAST COUPLE OF WEEKS THE BRAKES ARE SHAKING WHEN I GO TO STOP. I HAVE C HANGED THE FRONT CALIPERS SINCE THIS IS WHERE IT IS HAPPENING SINCE THE CALIPERS WENT BAD SO DID THE ROTERS AN PADS SO THOSE NEEDED TO BE CHANGED ALSO...WHICH IS MONEY I DON'T HAVE .....IT WORKED FOR A TOTAL OF 4 DAYS THEN PROBLEM BEGAN AGAIN. PLEASE INFORM ME OF OTHER ISSUES AND WHAT CAN BE DONE TO RESOLVE THIS PROBLEM ESPECIALLY SINCE I DRIVE THIS TRUCK TO EARN A LIVING FOR MY FAMILY EVERYDAY.. THANK YOU FOR YOUR ATTENTION TO THIS MATTER.
NHTSA ODI #10747254
135,000 miles · Aug 7, 2015
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT NOTICED THERE WAS A ENGINE LEAK AND NOTICED THAT A FEW BOLTS THAT HOLD THE EXHAUST PIPE WERE MISSING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT NOTICED THERE WAS A ENGINE LEAK AND NOTICED THAT A FEW BOLTS THAT HOLD THE EXHAUST PIPE WERE MISSING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration