TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THE SPARE TIRE CABLE FRACTURED CAUSING THE SPARE TIRE TO DETACH FROM THE VEHICLE. THE STRANDS WHERE THE CABLE FRACTURED WERE UNEVEN AND CONTAINED RUST. THE CONTACT WAS UNAWARE UNSURE WHAT THE APPROXIMATE SPEED WAS WHEN THE FAILURE …
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THE SPARE TIRE CABLE FRACTURED CAUSING THE SPARE TIRE TO DETACH FROM THE VEHICLE. THE STRANDS WHERE THE CABLE FRACTURED WERE UNEVEN AND CONTAINED RUST. THE CONTACT WAS UNAWARE UNSURE WHAT THE APPROXIMATE SPEED WAS WHEN THE FAILURE OCCURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 01/13/12*LJ
NHTSA ODI #10435137
55,000 miles · Jul 1, 2010
Equipment
TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 70 MPH WITH THE AIR CONDITIONER ON, THE DRIVERS SIDE VENT WAS RELEASING HOT AIR WHILE THE PASSENGER SIDE VENT CONTINUED TO RELEASE COLD AIR. THE CONTACT SHUT THE VEHICLE OFF AND AFTER RESTARTING IT THE AIR CONDITIONER BEGAN TO FUNCTION PROPERLY. THE VE…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 70 MPH WITH THE AIR CONDITIONER ON, THE DRIVERS SIDE VENT WAS RELEASING HOT AIR WHILE THE PASSENGER SIDE VENT CONTINUED TO RELEASE COLD AIR. THE CONTACT SHUT THE VEHICLE OFF AND AFTER RESTARTING IT THE AIR CONDITIONER BEGAN TO FUNCTION PROPERLY. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY. THE CONTACT STATED THAT OVER TIME THE FAILURE BECAME PROGRESSIVELY WORSE. THE FAILURE WAS NOT DIAGNOSED BY AN AUTHORIZED DEALER. THE CONTACT WAS INFORMED THAT THERE WAS A TECHNICAL SERVICE BULLETIN RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS 55,000 AND THE CURRENT MILEAGE WAS 71,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10340908
Mileage unknown · Mar 23, 2009
Electrical SystemEquipment
RE:CHEVY 2005 INSTRUMENT CLUSTER FAILURE ABOUT 6 MONTHS AGO, MY 2005 CHEVY SILVERADO 200 TRUCK STARTED EXPERIENCING THE SPEEDOMETER FAILURE ISSUE. AT THAT TIME I CALLED IN THE DEALERSHIP TOM JUMPER WHERE I PURCHASED THIS VEHICLE AND THEY TOLD ME THAT THEY KNOW ABOUT THIS ISSUE AND IT WOULD COST ABOUT $600 TO GET THIS FIXED. THE…
Read full complaint
RE:CHEVY 2005 INSTRUMENT CLUSTER FAILURE ABOUT 6 MONTHS AGO, MY 2005 CHEVY SILVERADO 200 TRUCK STARTED EXPERIENCING THE SPEEDOMETER FAILURE ISSUE. AT THAT TIME I CALLED IN THE DEALERSHIP TOM JUMPER WHERE I PURCHASED THIS VEHICLE AND THEY TOLD ME THAT THEY KNOW ABOUT THIS ISSUE AND IT WOULD COST ABOUT $600 TO GET THIS FIXED. THEY ALSO INFORMED ME THAT THERE WAS A LITIGATION AGAINST GM FOR THE SPEEDOMETER ISSUE AND HAD ME CALL GM DIRECTLY TO GET THIS ISSUE FIXED TO AVOID OUT OF POCKET EXPENSES. THIS DEALERSHIP HAS CLOSED AND OUT OF BUSINESS. I DID CALL GM ACCORDING TO THEM THERE HAS BEEN LITIGATION GOING ON AND THEY DIRECTED TO ME TO THIS WEBSITE TO FIND OUT THE STATUS PERIODICALLY. THE WEBSITE NOW INFORMS THAT THERE WAS A SETTLEMENT NOTICE ISSUED AND FOR PEOPLE WHO HAVE PAID FOR THIS REPAIR WORK SHOULD CLAIM THEIR REIMBURSEMENTS. I REFUSE TO PAY OUT OF POCKET AND ASKED THEM TO GET MY VEHICLE FIXED AS ITS A MANUFACTURER PROBLEM ON SUPPLYING DEFECTIVE PARTS. THEY ARE ASKING ME TO GO TO CHEVY DEALER AND GET IT DIAGNOSED PAID BY ME AND THEN THEY WILL DETERMINE IF THEY I AM ELIGIBLE FOR THIS REPAIR WORK. I FOUND THIS ABSOLUTELY UNACCEPTABLE AND FRAUDULENT AS PER KEEPING THEIR CLIENT AS A HOSTAGE TO THEIR DEMANDS. I WANT SOME ACTION DONE TO HELP PROTECT CONSUMERS LIKE ME WHO ARE ESSENTIALLY PAYING FOR THE BAILOUT OF THESE COMPANIES IN THE CURRENT ECONOMIC CONDITION. PLEASE HELP IN THIS MATTER. THANKS . (WWW.SPEEDOMETERSETTLEMENT.COM). *TR
NHTSA ODI #10262776
9,415 miles · Mar 21, 2006
EquipmentStructure
DT*: THE CONTACT STATED THE TONNEAU COVER USED ON THE BED OF THE PICKUP TRUCK DOES NOT CATCH PROPERLY. THE CLIPS HOLDING THE LID IN PLACE ONLY CATCH 1/8" ON THE BED OF THE TRUCK. AT HIGHWAY SPEEDS, THE LID OPENS AND THE CONTENTS OF THE TRUCK BED EJECTS. THE MANUFACTURER OF THE TONNEAU COVER IS STEFFENS ENTERPRISES INC. THE …
Read full complaint
DT*: THE CONTACT STATED THE TONNEAU COVER USED ON THE BED OF THE PICKUP TRUCK DOES NOT CATCH PROPERLY. THE CLIPS HOLDING THE LID IN PLACE ONLY CATCH 1/8" ON THE BED OF THE TRUCK. AT HIGHWAY SPEEDS, THE LID OPENS AND THE CONTENTS OF THE TRUCK BED EJECTS. THE MANUFACTURER OF THE TONNEAU COVER IS STEFFENS ENTERPRISES INC. THE CONTACT HAS BEEN UNSUCCESSFUL IN CONTACTING THE MANUFACTURER. UPDATED 05/04/06
NHTSA ODI #10153300
Mileage unknown · Aug 10, 2005
Equipment
DT: THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. HE WAS USING THE JACK, AND HAD THE JACK SHAFT PLACED ON THE JACK MOUNT. THE JACK SHAFT BENT, CAUSING IT TO SLIP OFF OF THE MOUNT AND DAMAGE THE TRUCK. ALMOST CAUSED THE CONSUMER TO BE STUCK UNDER THE TRUCK. THE CONTACT DID NOT FEEL THAT THE JACK WEIGHT WAS INTENDED FOR THIS TR…
Read full complaint
DT: THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. HE WAS USING THE JACK, AND HAD THE JACK SHAFT PLACED ON THE JACK MOUNT. THE JACK SHAFT BENT, CAUSING IT TO SLIP OFF OF THE MOUNT AND DAMAGE THE TRUCK. ALMOST CAUSED THE CONSUMER TO BE STUCK UNDER THE TRUCK. THE CONTACT DID NOT FEEL THAT THE JACK WEIGHT WAS INTENDED FOR THIS TRUCK. THE DEALERSHIP RECOMMENDED THAT HE CALL THE MANUFACTURER. *AK
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence & remedy
Consequence: IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration