WHEN ATTEMPTING TO START MY SON'S 2002 CHEVY MALIBU THE ANTI-THEFT LIGHT CAME ON, AND THE CAR WOULD CRANK BUT NOT START. I LOOKED ONLINE AND FOUND THAT THIS IS A COMMON PASS LOCK SENSOR ISSUE. THE KEY NEEDS TO BE IN THE ON POSITION FOR AT LEAST 10 MINUTES (UNTIL THE ANTI-THEFT LIGHT GOES OFF), THEN TURN THE KEY TO THE OFF POSITI…
Read full complaint
WHEN ATTEMPTING TO START MY SON'S 2002 CHEVY MALIBU THE ANTI-THEFT LIGHT CAME ON, AND THE CAR WOULD CRANK BUT NOT START. I LOOKED ONLINE AND FOUND THAT THIS IS A COMMON PASS LOCK SENSOR ISSUE. THE KEY NEEDS TO BE IN THE ON POSITION FOR AT LEAST 10 MINUTES (UNTIL THE ANTI-THEFT LIGHT GOES OFF), THEN TURN THE KEY TO THE OFF POSITION, TAKE THE KEY OUT, THEN PUT THE KEY BACK IN, AND IT WILL START. THIS IS A KNOWN ISSUE AND CAN BE REFERENCED ON NUMEROUS ONLINE SITES, SO THERE IS NO REASON THIS SHOULD NOT BE A RECALL ISSUE. MECHANICS WILL TELL YOU IT IS THE FUEL PUMP, FUEL LINES, OR THE IGNITION, AND YOU CAN SPEND A GREAT DEAL OF MONEY WITHOUT SOLVING THE ISSUE. AT $300-$450 (ESTIMATES) YOU CAN HAVE THE IGNITION SWITCH REPLACED, BUT THIS IS A KNOWN ISSUE AND SHOULD BE ON THE RECALL LIST. I DO NOT WANT MY TEENAGE SON STRANDED FOR SOMETHING THAT GM KNOWS ABOUT AND SHOULD REPLACE.
NHTSA ODI #10721266
Mileage unknown · Feb 28, 2014
EngineSteeringUnknown Or Other
I WAS DRIVING MY VEHICLE AT 35 MPH WHEN I WENT OVER A SMALL POT HOLE ON FATHER HURLEY BLVD. MY RIGHT KNEE SMASHED AGAINST MY KEY RING ON THE FRONT DASH AREA. THEE CAR LOST IMMEDIATE POWER. I COULD NOT ACCELERATE OR STEER MY VEHICLE. I HAD TO SLOWLY COAST OVER TO THE SIDE OF THE ROAD UNTIL I CAME TO A COMPLETE STOP. VEHICLES ARO…
Read full complaint
I WAS DRIVING MY VEHICLE AT 35 MPH WHEN I WENT OVER A SMALL POT HOLE ON FATHER HURLEY BLVD. MY RIGHT KNEE SMASHED AGAINST MY KEY RING ON THE FRONT DASH AREA. THEE CAR LOST IMMEDIATE POWER. I COULD NOT ACCELERATE OR STEER MY VEHICLE. I HAD TO SLOWLY COAST OVER TO THE SIDE OF THE ROAD UNTIL I CAME TO A COMPLETE STOP. VEHICLES AROUND ME HAD A DIFFICULT TIME AVOIDING ME SINCE THIS EVENT HAPPENED AS I WAS APPROACHING A LANE MERGING WITH MINE AS THEY EXITED A MAJOR FREEWAY. WHEN THE VEHICLE HAD COMPLETELY STOPPED I PUT ON MY HAZARD LIGHTS AND PUT IT IN PARK. I NOTICED THAT THE KEY WAS NOT FULLY ENGAGED IN THE IGNITION SO I PUSHED IT ALL THE WAY BACK INTO THE IGNITION AND TURNED THE KEY OVER. THE CAR IMMEDIATELY STARTED UP AND I WAS ABLE TO DRIVE HOME SAFELY. THIS IS THE 3RD TIME AN EVENT LIKE THIS (WHERE MY KNEE HAS BUMPED UP AGAINST THE KEY RING AND THE CAR LOST POWER) HAS HAPPENED IN MY HISTORY OF OWNING THIS VEHICLE. *TR
NHTSA ODI #10566566
72,000 miles · Aug 6, 2012
Unknown Or Other
SOMETIMES THE CAR STARTS SOMETIMES IT DON'T IT GIVES YOU NO NOTICE THAT IT NOT GOING TO START. *TR
NHTSA ODI #10469361
130,084 miles · Jul 15, 2009
Unknown Or Other
I HAVE HAD SEVERAL PROBLEMS WITH THE PASSLOCK II / THEFTSYSTEM IN MY 2002 CHEVROLET MALIBU. THIS IS A RECURRING ISSUE, THAT SEEMS TO HAPPEN 2 TO 3 TIMES A WEEK, SOMETIMES MORE, IN THE PAST WEEK IT HAS HAPPENED TWICE. WHEN THIS HAPPENS IT RESULTS IN ME HAVING TO TURN MY IGNITION TO ON FOR TEN MINUTES, AND WAIT PATIENTLY IN HOPE…
Read full complaint
I HAVE HAD SEVERAL PROBLEMS WITH THE PASSLOCK II / THEFTSYSTEM IN MY 2002 CHEVROLET MALIBU. THIS IS A RECURRING ISSUE, THAT SEEMS TO HAPPEN 2 TO 3 TIMES A WEEK, SOMETIMES MORE, IN THE PAST WEEK IT HAS HAPPENED TWICE. WHEN THIS HAPPENS IT RESULTS IN ME HAVING TO TURN MY IGNITION TO ON FOR TEN MINUTES, AND WAIT PATIENTLY IN HOPES THIS WILL LET ME START MY OWN CAR. I THINK THIS IS SOMETHING THAT NEEDS A SERIOUS INQUIRY BY SOMEONE. I HAVE CONTACTED THE DEALERSHIP WITH NO AVAIL. I AM HOPING SOMEONE WILL HELP THE PEOPLE WHO ARE BEING STRANDED IN THAT DARK PARKING LOT ALONE AT 3AM. PLEASE DO SOMETHING ABOUT THE 2002 CHEVROLET MALIBU THEFTSYSTEM/ PASSLOCK, PLEASE. *TR
NHTSA ODI #10276912
Mileage unknown · Jun 8, 2007
Unknown Or OtherCrash
2002 CHEVROLET MALIBU CUSTOMER STATES THAT THE FLOOR MAT CURLED ON THE TOP OF THE GAS PEDAL AND AS SHE APPLIED THE BRAKE, THE GAS PEDAL WAS DEPRESSED AND CAUSED THE CAR TO LURCH FORWARD AND HIT THE GARAGE**NAR**CC *JB
NHTSA ODI #10193213
12,000 miles · Aug 23, 2005
Electrical SystemService Brakes, AirUnknown Or Other
NO INCIDENTS, CRASHES OR INJURY'S WHILE IN MY POSSESSION. THE 2002 CHEVY MALIBU I BOUGHT USED IN 2004 ONLY HAD 11,000 MILES ON IT. IT WAS A GOVERNMENT USED CAR. SEVERAL MONTHS AFTER BUYING THE CAR THE BLINKERS STOPPED WORKING AND THEN BEGAN WORKING AGAIN. THEY NOW WORK WHEN THEY WANT TO WORK. NOW, ALMOST A YEAR LATER AT 41,000 M…
Read full complaint
NO INCIDENTS, CRASHES OR INJURY'S WHILE IN MY POSSESSION. THE 2002 CHEVY MALIBU I BOUGHT USED IN 2004 ONLY HAD 11,000 MILES ON IT. IT WAS A GOVERNMENT USED CAR. SEVERAL MONTHS AFTER BUYING THE CAR THE BLINKERS STOPPED WORKING AND THEN BEGAN WORKING AGAIN. THEY NOW WORK WHEN THEY WANT TO WORK. NOW, ALMOST A YEAR LATER AT 41,000 MILES THE HORN BLOWS A SHORT BEEP ANYTIME. THE CAR MAY BE RUNNING OR NOT, THERE MAY NOT BE ANYONE EVEN IN THE CAR. THIS HAS BEEN GOING ON FOR ABOUT A MONTH AND A HALF AND NOW THERE IS A BEEPING TONE INSIDE THAT I HAVE NOT IDENTIFIED. IT DOESN'T DO IT CONSTANTLY BUT I NOTICE IT WHEN I START THE CAR. IT IS A SHORT "ALERT" BEEP, KIND OF LIKE AN ALARM. IT BEEPS ONCE, PAUSE, AND THEN ABOUT THREE TIMES PAUSE AND THEN ONCE MORE. JUST WONDERING IF THERE WERE ANY RECALLS FOR THIS AS THE WARRANTY IS NOT IN AFFECT ANY LONGER. IN ADDITION TO THESE THERE HAS BEEN ABOUT THREE OCCASIONS WHERE MY CAR HESTITATED WHEN STARTING KIND OF LIKE THE BATTERY WAS DRAINED. COULD THIS BE FROM THE HORN BLOWING ALL DAY AND NIGHT? HAVE ALSO REPLACED BRAKES MORE OFTEN THAN I THOUGHT I SHOULD.
NHTSA ODI #10133881
Mileage unknown · Sep 14, 2004
Unknown Or Other
A TRASH BAG HAD WRAPPED AROUND THE AXLE OF A 2002 CHEVROLET MALIBU RESULTING IN THE BRAKE HOSE RIPPING. *MR *SC THE CV BOOT WAS ALSO CRUSHED DUE TO THE CONSUMER RUNNING OVER A LARGE TRASH BAG. *JB
NHTSA ODI #10092745
21,338 miles · Jan 15, 2004
Service Brakes, HydraulicTiresUnknown Or Other
THE ROTORS ON THIS VEHICLE WARPED WITHIN THE FIRST YEAR AND CONTINUE TO WARP EVERY TWO TO FOUR MONTHS. THIS IS CAUSING WEAR ON THE BRAKES WHICH HAD TO BE REPLACED AT 21338 MILES AT MY COST AND AGAIN AT 31474 MILES AT THE DEALERS COST.
NHTSA ODI #10068857
47,000 miles · Jul 25, 2003
Unknown Or Other
PROBLEMS GETTING DEALERSHIP TO PAY FOR RECALL REPAIR. *MR THE DEALER STATED THE VEHICLE MILEAGE NEEDED TO BE BETWEEN 43K-45K MILES. THE CONSUMER REQUESTED HER MONEY BACK. *SCC *JB
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES WERE PRODUCED WITH A LEFT LOW-BEAM HEADLAMP THAT DOES NOT MEET THE PHOTOMETRIC PERFORMANCE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: LIGHT INTENSITIES BELOW THE MINIMUM INTENSITY REQUIREMENTS CAUSE REDUCTION IN VISIBILITY DOWN THE ROAD FOR THE DRIVER OF THE VEHICLE AND INTENSITIES ABOVE THE MAXIMUM INTENSITY REQUIREMENTS CAUSE INCREASE IN GLARE FOR DRIVERS AHEAD OF, OR APPROACHING, THE VEHICLE.
Remedy: DEALERS WILL INSPECT THE LEFT LOW-BEAM HEADLAMP AND REPLACE IT IF IT DOES NOT MEET REQUIREMENTS. OWNER NOTIFICATION BEGAN MAY 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2002 Chevrolet Malibu Problems, Complaints & Recalls | Skip That Year
Illustration