Electrical SystemEngine And Engine CoolingExterior Lighting
TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHILE LEAVING THE HIGHWAY AT AN UNKNOWN SPEED, THE CONTACT NOTICED THAT THE TURN SIGNALS FAILED. THE FAILURE HAS OCCURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY COULD NOT DETERMINE THE CAUSE OF THE INTERMITTENT FAILURE. THE DEALER REPLACED THE UPPER AND LOWER…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHILE LEAVING THE HIGHWAY AT AN UNKNOWN SPEED, THE CONTACT NOTICED THAT THE TURN SIGNALS FAILED. THE FAILURE HAS OCCURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY COULD NOT DETERMINE THE CAUSE OF THE INTERMITTENT FAILURE. THE DEALER REPLACED THE UPPER AND LOWER HEAD GASKET SEAL, BUT THE FAILURE WAS NOT CORRECTED. THE RACK AND PINION FAILED AND WAS REPLACED IN 2006 AND AGAIN IN OCTOBER OF 2008. THE FAILURE MILEAGE WAS 30,000 AND CURRENT MILEAGE WAS 52,300.
NHTSA ODI #10253988
98,000 miles · May 29, 2006
SteeringSuspension
HEARING POPPING NOISE IN THE FRONT SUSPENSION WHENEVER YOU MAKE A TURN IN THE VEHICLE AND THE REAR STABILIZING BAR IS BAD. BACK END SWINGS. *NM
NHTSA ODI #10158484
Mileage unknown · Aug 7, 2002
Steering
AFTER COMING TO A COMPLETE STOP, APPLIED GAS, VEHICLE WOULD NOT ACCELERATE. CONTACTED DEALER. TIE ROD BOLT HAD FALLEN OFF.*AKCONSUMER WAS ABLE TO MANUEVER THE VEHICLE TO A NEARBY GAS STATION. THE WORKER AT THE SERVICE STATION NOTICED THE LEFT FRONT TIRE WAS TURNED SIDEWAYS. THE VEHICLE WAS TOWED TO THE DEALER. CONSUMER ASKED…
Read full complaint
AFTER COMING TO A COMPLETE STOP, APPLIED GAS, VEHICLE WOULD NOT ACCELERATE. CONTACTED DEALER. TIE ROD BOLT HAD FALLEN OFF.*AKCONSUMER WAS ABLE TO MANUEVER THE VEHICLE TO A NEARBY GAS STATION. THE WORKER AT THE SERVICE STATION NOTICED THE LEFT FRONT TIRE WAS TURNED SIDEWAYS. THE VEHICLE WAS TOWED TO THE DEALER. CONSUMER ASKED FOR A REPLACEMENT BUT WAS TOLD THE ONLY RECOURSE WAS TO REPAIR IT. *JG
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES WERE PRODUCED WITH A LEFT LOW-BEAM HEADLAMP THAT DOES NOT MEET THE PHOTOMETRIC PERFORMANCE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: LIGHT INTENSITIES BELOW THE MINIMUM INTENSITY REQUIREMENTS CAUSE REDUCTION IN VISIBILITY DOWN THE ROAD FOR THE DRIVER OF THE VEHICLE AND INTENSITIES ABOVE THE MAXIMUM INTENSITY REQUIREMENTS CAUSE INCREASE IN GLARE FOR DRIVERS AHEAD OF, OR APPROACHING, THE VEHICLE.
Remedy: DEALERS WILL INSPECT THE LEFT LOW-BEAM HEADLAMP AND REPLACE IT IF IT DOES NOT MEET REQUIREMENTS. OWNER NOTIFICATION BEGAN MAY 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2002 Chevrolet Malibu Problems, Complaints & Recalls | Skip That Year
Illustration