2002 Chevrolet Malibu

TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHILE DRIVING LESS THAN 70 MPH, THE EXTERIOR BRAKE LIGHTS ON THE VEHICLE CONTINUED TO ILLUMINATE EVEN WHEN THE BRAKE PEDAL WAS NOT DEPRESSED. THE CONTACT WAS CONCERNED THAT THE OTHER DRIVERS WOULD SWERVE AROUND HER AND ASSUME THAT SHE WAS BRAKING, WHEN IN REALITY, SHE WOULD BE IN ACCELERATION OR DRIVE MODE. THE DEALER REPLACED THE ECM AND THE SENSOR APPROXIMATELY THREE TIMES. THE VEHICLE HAS BEEN AT THE DEALER AT LEAST TWICE A MONTH FOR ONE YEAR. THE REPAIRS HAVE NOT CORRECTED THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 40,000.

WHEN THE WEATHER IS WET OR SNOWY, AND THERE IS POSSIBLE SLICK SPOTS ON THE ROAD, THE ABS IS ENGAGED EVEN WHEN YOU ARE PULLING UP SLOWLY TO THE STOP SIGN, OR SLOWING DOWN TO ARRIVE HOME, OR EVEN COMING OUT OF THE DRIVEWAY... WHAT HAPPENS, IS WHEN DOING THOSE THINGS IN WEATHER AS DESCRIBED ABOVE, IF YOU ATTEMPT TO PUT THE BREAKS ON IT MAKES AN AWFUL GRINDING SOUND AND PUSHED BACK ON YOU SO YOU CANT BREAK... THIS HAS HAPPENED TO ME NUMEROUS TIMES JUST BACKING OUT OF MY DRIVEWAY... I PULLED UP TO A STOP SIGN BEHIND SOMEONE THIS IS RIGHT ON MY RESIDENTIAL STREET SO I WAS NOT SPEEDING AT ALL, IT WAS A RAINY DAY BUT THE RAIN WAS LIGHT, I HAVE BRAND NEW TIRES ON MY CAR TOO. AS I PULLED UP BEHIND MY NEIGHBORS CAR TO THE STOP SIGN, I WAS BARELY PUSHING DOWN MY BREAK PEDDLE WHEN IT PUSHED BACK AT ME AND MADE T HIS DEEP SOUND I COULDN'T STOP AND I ALMOST HIT MY NEIGHBOR. I WENT TO MY LONG TIME MECHANIC AND HE TOOK IT FOR A DRIVE ON A CLEAR DAY.... HE TOOK IT ON SOME GRAVEL AND STOPPED HARD WELL THE BREAKS DID THE SAME THING. HE SAID IT WAS THE ABS EVEN THOUGH HE DIDN'T LOOK AT THEM. I THINK IT IS THE WHEEL BEARINGS. I HAVE HAD MANY OTHER VEHICLES IN MY LIFE AND NON OF THEM DID THAT TO ME ON WET OR SNOWY DAYS! I KNOW IT ISN'T NORMAL AND I DO NOT FEEL SAFE DRIVING THE VEHICLE. I HAVE 2 YOUNG CHILDREN AND IF THE ABS ARE GOING TO BE THAT STINGY THEN MY CHANCES OF CRASHING WILL BE 99% HIGHER! *TR

I AM CONTINUALLY HAVING PROBLEMS WITH MY 2002 CHEVY MALIBU. I HAD THE THEFT SYSTEM CONTINUALLY COME ON AND PAID $700 TO FIX THAT. FUEL PUMP WENT BAD...$500. I HAD THE COOLANT SYSTEM LEAK AND PAID $800 TO FIX THAT. EVERY TIME I GET MY BRAKE PADS REPLACED, THE ROTORS NEED REPLACED TOO, UNTIL THE LAST TIME WHEN THE CALIBERS HAD TO BE REPLACED AS WELL $900. NOW I AM HAVING DIFFICULTY STARTING MY PIECE OF JUNK. *TR

THE ANTI-FREEZE HOLDING TANK KEEPS GETTING AN OIL RESIDUE IN IT AND THE ANTI-FREEZE KEEPS DISAPPEARING INTO THE ENGINE AND HAS TO KEEP BEING REFILLED. AFTER SPEAKING WITH A MECHANIC IT IS POSSIBLE THAT THE INTAKE MANIFOLD GASKET IS FAILING. THE A/C SWITCH ALSO TURNS OFF ON ITS OWN. ROTORS AND BRAKES HAVE BEEN REPLACED THREE TIMES. *JB

I HAVE FILED A SAFETY COMPLAINT WITH CHEVROLET ON THE 2002 MALIBU I PURCHASED NEW. I HAVE HAD TO REPLACE THE BRAKES TWICE ONCE AT 33,378 MILES ON 5/5/2005 AND AGAIN AT 51,543 MILE ON 3/27/2007. THE CONSUMER COMPLAINT DEPARTMENT AND THE DEALERSHIP WHERE IT WAS REPAIR HAVE INFORMED ME THE REPLACING THE BRAKES AT 18,165 MILES ARE CONSIDERED ?ROUTINE MAINTENANCE.? FAILURE OF THE BRAKING SYSTEM WAS FOUND WHEN THE CAR DID NOT ADEQUACY STOP PLACING ME AND MY FAMILY IN DANGER. THERE WAS NO AUDIBLE OR VISUAL INDICATOR OF THE BRAKING PROBLEM, INSTEAD I HAD TO RELY ON PERFORMANCE FAILURE WHILE ON THE ROAD. TO DATE THE MANUFACTURER AND DEALERSHIP FAIL TO RECOGNIZE THE PROBLEM. *TR

FOUND CORROSION ON THE BRAKE LINES AND MASTER CYLINDER, AND OTHER LINES THAT ARE LOCATED UNDER THE BATTERY CORROSION PLATE. THE BATTERY CORROSION PLATE WAS A GOOD IDEA. HOWEVER, PUTTING BRAKE LINES & OTHER COMPONENTS UNDER WERE ARE NOT A GOOD DESIGN. IT'S FLAWED, FOR IF THE BATTERY PLATE BECOMES CORRODED, THEN IT LEAKS ONTO THE LINES BELOW AND CAUSES DAMAGE AS IN MY VEHICLE. *AK

FIRST INCIDENT OF LEAKING HAPPENED AFTER DEALERSHIP WORKED ON CAR. ARRIVED HOME COOLANT POURED OUT ON GROUND TOWED BACK. DEALERSHIP SAID RESERVOIR CAP SEAL. 10/2006 OR 11/2006, PICKING UP AT SCHOOL AND SMELLED NOT ENGINE. PARKED SAW COOLANT ON GROUND. NO ENGINE LIGHT ON BUT NEEDLE WAS PAST MIDDLE. FAMILY BROUGHT COOLANT FILLED IT UP AND WENT 5 BLOCKS TO DEALERSHIP. THEY SAID NOTHING WAS WRONG. YESTERDAY, 1/9/2007 CAR OVERHEATED IN THE SCHOOL LINE. ADDED COOLANT. I BROUGHT IT TO A NON DEALERSHIP RADIATOR SHOP OWNER THINKS INTAKE MANIFOLD GASKET LEAKING. CAR AT DEALERSHIP. I REALLY DON'T KNOW WHAT THE REAL PROBLEM IS BUT BECAUSE MY WARRANTY EXPIRED FEEL DEALERSHIP WILL TELL ME IT IS A NEW PROBLEM FROM THE FIRST EVENT SO I WILL BE RESPONSIBLE. AT LEAST TWO ROTORS REPLACED ON THE FRONT DRIVER'S WHEEL & 5 SETS OF PADS. REPORTED TO GM THEY CLAIM IT IS THE WAY I DRIVE! A NON DEALERSHIP TIRE COMPANY HAD THE PADS REPLACED WITH A GOOD BRAND. 1 1/2 YEARS SINCE I HAD TO HAVE PADS. PROBLEM WITH THE RIGHT FRONT PASSENGER DOOR LOCKS. CAR IS RUNNING AND THE DRIVER GETS OUT LEAVING CAR ON AND THEN THE PASSENGER TURNS OFF THE CAR AND GETS OUT, LOCKS CAR, THE RADIO STAYS ON. I WENT INSIDE THE STORE AND CAME OUT AND THE RADIO WAS STILL PLAYING. WHEN YOU UNLOCK THE CAR BUT ENTER ONLY THE PASSENGER FRONT DOOR AND THEN CLOSE IT AND WALK AWAY, THE CAR LOCKS ITSELF. HAPPENED SEVERAL TIMES. I HAD NOT PLACED THE KEYS ON THE SEAT OF THE CAR AND SHUT THE DOOR OR I WOULD HAVE BEEN LOCKED OUT. I REPORTED THIS BUT NO ONE SEEMED TO CARE. RADIO WAS REPLACED FOR LEFT BUTTON PAINT (NOT SURE IF IT IS PAINT OR COVER ON BUTTON) RUBS OFF. IGNITION SWITCH WAS REPLACED. FUEL PUMP REPLACED.. I TRANSPORT GRANDCHILDREN AND I NEED A SAFE CAR. *JB