IllustrationTHE SAME PROBLEM THAT IS OCCURRING/OCCURRED IN THE 2000 AND 2001 CHEVROLET MALIBU'S (OF WHICH THERE IS A RECALL) IS OCCURRING IN MY 2002 MALIBU. *NM
2002 Chevrolet Malibu
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Chevrolet Malibu do not stand out strongly from the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
380–25K
8225–50K
10250–75K
7175–100K
73100–150K
25150K+
391 reports with mileage · 176 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 259 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 143 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports1 fire reports13 injury reports
Exterior Lighting complaints
143 reportsMY 2002 CHEVY MALIBU HAS INTERMITTENT FAILURES OF THE TURN SIGNALS AND HAZARD FLASHERS. THE PROBLEM TENDS TO EXHIBIT ITSELF MORE OFTEN IN WARM AND/OR HUMID CONDITIONS. *NM
INTERMITTENT TURN SIGNAL FAILURE. AFTER BRIEFLY TURNING ON THE HAZARD LIGHTS, THE TURN SIGNALS WILL SOMETIMES WORK FOR A SHORT PERIOD OF TIME, BUT INEVITABLY THEY FAIL AGAIN SOON AFTERWARD.
DT*: THE CONTACT STATES THE TURN SIGNAL LIGHTS AND WARNING LIGHTS WORK INTERMITTENTLY. THIS OCCURS WHILE THE VEHICLE IS IN USE, AND IT HAS BEEN GOING ON FOR OVER A YEAR. THE VEHICLE WAS NEVER TAKEN TO A MECHANIC. THERE IS A RECALL, #03V327000 CONCERNING THE HAZARD FLASHING WARNING LIGHT SWITCH. THE VEHICLE IS EXPERIENCING THE …
Read full complaint
DT*: THE CONTACT STATES THE TURN SIGNAL LIGHTS AND WARNING LIGHTS WORK INTERMITTENTLY. THIS OCCURS WHILE THE VEHICLE IS IN USE, AND IT HAS BEEN GOING ON FOR OVER A YEAR. THE VEHICLE WAS NEVER TAKEN TO A MECHANIC. THERE IS A RECALL, #03V327000 CONCERNING THE HAZARD FLASHING WARNING LIGHT SWITCH. THE VEHICLE IS EXPERIENCING THE SAME PROBLEMS AS THE RECALL, HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE YEAR OF THE VEHICLE.
HAZARD SWITCH HAS STOPPED WORKING OR WORKS ONLY SOMETIMES. CAUSES THE BLINKERS AND THE HAZARD LIGHTS NOT TO WORK, CAUSING A POSSIBLE ACCIDENT. *NM
I PURCHASED 2002 MALIBU NEW NOV 2001. TURN SIGNALS QUIT WORKING ONCE IN 2002. REOCCURRED 3-4 TIMES IN 2003. 2004 OCCURRED 6-8 TIMES. 2005 OCCURRED AT LEAST ONCE A MONTH UNTIL OCT-DEC WHEN SIGNALS MALFUNCTION WEEKLY. JAN 2006, SIGNALS MALFUNCTION 1-3 TIME A DAY SOMETIMES. VEHICLE HAS APPROX 32,000 MILES. CYCLING THE HAZARD S…
Read full complaint
I PURCHASED 2002 MALIBU NEW NOV 2001. TURN SIGNALS QUIT WORKING ONCE IN 2002. REOCCURRED 3-4 TIMES IN 2003. 2004 OCCURRED 6-8 TIMES. 2005 OCCURRED AT LEAST ONCE A MONTH UNTIL OCT-DEC WHEN SIGNALS MALFUNCTION WEEKLY. JAN 2006, SIGNALS MALFUNCTION 1-3 TIME A DAY SOMETIMES. VEHICLE HAS APPROX 32,000 MILES. CYCLING THE HAZARD SWITCH USUALLY ONCE OR TWICE CURES THE PROBLEM. CALLED DEALER NOV 2005, BUT NO RECALL ON 2002 MALIBU FOR THIS PROBLEM. *NM
DT*:THE CONTACT STATED BOTH TURN SIGNALS INTERMITTENTLY TURN ON WITHOUT ASSISTANCE. IF THE ENGINE IS TURNED OFF FOR AN EXTENDED AMOUNT OF TIME THE LIGHTS SOMETIMES TURN ON. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY ALERTED THE CONTACT THAT THEY WERE UNAWARE OF ANY PROBLEMS. *AK
I FIRST PURCHASED THIS MALIBU 2002 IN FEB 2002. NOV 02 ( 9 MOS LATER) I HAD TO HAVE MY IGNITION SWITCH REPLACED WHICH WAS UNDER WARRANTY. AROUND THE SAME TIME MY TURN/HAZARD SIGNAL WENT OUT AND I HAVEN'T HAD IT REPLACED YET AFTER 4YRS OF HAVING THIS CAR. IF I WANT TO USE IT I HAVE TO KEEP PRESSING THE HAZARD BUTTON TO MAKE IT…
Read full complaint
I FIRST PURCHASED THIS MALIBU 2002 IN FEB 2002. NOV 02 ( 9 MOS LATER) I HAD TO HAVE MY IGNITION SWITCH REPLACED WHICH WAS UNDER WARRANTY. AROUND THE SAME TIME MY TURN/HAZARD SIGNAL WENT OUT AND I HAVEN'T HAD IT REPLACED YET AFTER 4YRS OF HAVING THIS CAR. IF I WANT TO USE IT I HAVE TO KEEP PRESSING THE HAZARD BUTTON TO MAKE IT COME ON. NOV 2005 I TRIED TO START MY CAR, BUT IT KEPT CUTTING OFF. MY DAD STATED IT WAS THE FUEL PUMP. I HAD THE FUEL PUMP,CRANK SENSOR AND MODULE REPLACED. MY CAR STILL DIDN'T START. FINALLY MY DAD WENT UNDER THE STEERING WHEEL AND PRESSED THIS BLACK BUTTON (CUT OFF SWITCH) AND THAT WAS THE ONLY WAY IT WOULD START. I HAVE TO TRAVEL 25 MILES TO WORK SO I WAS TIRED OF WORRYING ABOUT THE CAR. I THOUGHT IT WAS THE THEFT SYSTEM. I TOOK MY CAR TO THE DEALER 11/29/2005 THEY HAD THE CAR UNTIL 12/15/2005. I WAS TOLD THAT IT WAS MY IGNITION SWITCH, CRANK SENSOR AND MY ALARM/AUTOMATIC STARTER. I WAS OUT OF $366.73 TO THE DEALER AND TAKING A CAB TO WORK AT 5:30AM FOR X7DY COASTED$210.00. I WAS ALSO OUT OF MONEY FOR A RENTAL CAR FOR THE LAST 7YS THEY HAD MY CAR PLUS GAS ON BOTH BECAUSE THEY USED ALL GAS IN MY CAR. I HAVE HAD X2 IGNITION SWITCHES PUT ON MY CAR, I HAVE TO CHANGE MY TAIL/PARK/BRAKE BULB SEEMINGLY EVERY 6MOS. I AM ONLY GETTING MY HAZARD/TURN SIGNAL REPLACED WHEN NHTSA REVIEWS IT AS BEING AN DEFECT. I AM HAVING A HARD TIME WITH THE SPEED OF MY CAR ALSO ON THE E WAY. I HAVE TO PUT MY FOOT TO THE FLOOR IN ORDER TO MAKE IT TAKE OFF AT 60MPH. I HAVE TO PUT GAS IN MY CAR EVERY 3DYS. I LAST CHANGED MY FUEL FILTER 1YR AGO AND AGAIN HAVING IT REPLACED 1/1/06. MY CHECK ENGINE LIGHT CAME ON 1WK AFTER I GOT MY CAR OUT OF THE SHOP ON 12/22 AND IT HAS BEEN ON SINCE. MY COOLANT LIGHT COMES AND GOES OFF EVERY NOW AND THEN. I HAVE HAD MY COOLANT/FUEL FLUSHED. I HAD IT WINTERIZED WHAT'S THE PROBLEM. IF WE HAVE 47-50 PEOPLE COMPLAINING ABOUT THE SAME THING WHY CANT IT GET DONE. PLEASE RESPOND AND HELP US CHEVY OWNERS ASAP/WF. *JB
ON MY 2002 CHEVY MALIBU LS THE TURN SIGNAL/HAZARD BUTTON HAS BECOME INOPERATIVE AT RANDOM DRIVING TIMES. BASICALLY IT MIMMICKS THE EXACT RECALL OF THE 2001 MALIBUS. I HAD SOMEONE WHO PREVIOUSLY OWNED A MALIBU STATE THAT THEY HAD THE SAME PROBLEM. MORE TIMES THAN NOT, THE SIGNALS DO NOT WORK. *NM
TURN SIGNALS STOPPED WORKING, HAZDARDS WORK ALL OTHER LIGHTS WORK AND ALL FUSES ARE GOOD. THIS IS A COMMON PROBLEM ON THIS YEARS MALIBU. *NM
Official recalls
214V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
02V107000 · Exterior Lighting:headlights
Apr 10, 2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES WERE PRODUCED WITH A LEFT LOW-BEAM HEADLAMP THAT DOES NOT MEET THE PHOTOMETRIC PERFORMANCE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: LIGHT INTENSITIES BELOW THE MINIMUM INTENSITY REQUIREMENTS CAUSE REDUCTION IN VISIBILITY DOWN THE ROAD FOR THE DRIVER OF THE VEHICLE AND INTENSITIES ABOVE THE MAXIMUM INTENSITY REQUIREMENTS CAUSE INCREASE IN GLARE FOR DRIVERS AHEAD OF, OR APPROACHING, THE VEHICLE.
Remedy: DEALERS WILL INSPECT THE LEFT LOW-BEAM HEADLAMP AND REPLACE IT IF IT DOES NOT MEET REQUIREMENTS. OWNER NOTIFICATION BEGAN MAY 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE05055 · Turn Signal Failures
Opened Sep 27, 2005 · Closed Jan 13, 2006
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.