2002 MALIBU TURN SIGNAL WORK WHEN THEY WANT. HAVE TO HIT DASH BY HAZARD LIGHTS TO MAKE THEM WORK. HAVEN;T HAD A ACCIDENT YET ,BUT AM SCARED TO DRIVE MY CAR. BOUGHT THE CAR NEW FROM THE DEALERSHIP. HAVE NEVER RECEIVED ANY RECALL NOTICES. HORN ALSO HAS A MIND OF IT'S OWN. ONLY HAVE 45,000 MILES ON MY CAR. I USED TO LOVE IT BUT NO…
Read full complaint
2002 MALIBU TURN SIGNAL WORK WHEN THEY WANT. HAVE TO HIT DASH BY HAZARD LIGHTS TO MAKE THEM WORK. HAVEN;T HAD A ACCIDENT YET ,BUT AM SCARED TO DRIVE MY CAR. BOUGHT THE CAR NEW FROM THE DEALERSHIP. HAVE NEVER RECEIVED ANY RECALL NOTICES. HORN ALSO HAS A MIND OF IT'S OWN. ONLY HAVE 45,000 MILES ON MY CAR. I USED TO LOVE IT BUT NOW I AM AFRAID OF HAVING A WRECK AND EITHER DYING OR KILLING SOMEONE ELSE. CHEVY NEEDS TO RECALL ALL THE PROBLEM CARS AND NOT JUST A FEW. *TR
NHTSA ODI #10242353
106,753 miles · Aug 6, 2008
Exterior Lighting
I OWN A 2002 CHEVY MALIBU AND I AM EXPERIENCING AN INTERMITTENT CLICKING NOISE COMING FROM SOMEWHERE IN THE DASH. I TOOK IT TO THE DEALERSHIP AND THEIR DIAGNOSIS WAS "SMALL INTERMITTENT VOLTAGE BLEED FROM THE TURN SIGNAL SWITCH. NEEDS THE SWITCH REPLACED." ALTHOUGH I REFERRED THE TO THE DEFECT FOUND BY THE ODI, GM REFUSED TO R…
Read full complaint
I OWN A 2002 CHEVY MALIBU AND I AM EXPERIENCING AN INTERMITTENT CLICKING NOISE COMING FROM SOMEWHERE IN THE DASH. I TOOK IT TO THE DEALERSHIP AND THEIR DIAGNOSIS WAS "SMALL INTERMITTENT VOLTAGE BLEED FROM THE TURN SIGNAL SWITCH. NEEDS THE SWITCH REPLACED." ALTHOUGH I REFERRED THE TO THE DEFECT FOUND BY THE ODI, GM REFUSED TO REPLACE THE SWITCH AT NO COST BECAUSE THEIR INTERNAL POLICY IS THAT THEY WILL ONLY REPLACE THE HAZARD SWITCH. WHEN I SHOWED THAT THE REPORT LISTED THE COMPONENTS AS THE HAZARD SWITCH AND THE TURN SIGNAL SWITCH. THEY STILL DECLINED. THEY STATED THAT ALTHOUGH THE TWO EXHIBIT THE SAME SYMPTOMS, THEIR POLICY STATES THEY ONLY COVER THE HAZARD SWITCH ALONE. THEY RECOMMENDED REPLACING THE TURN SIGNAL SWITCH AT MY COST. THEN "IF THE PROBLEM PERSISTS, WHICH IT MAY, THEN REPLACE THE HAZARD SWITCH." WHICH AT THAT POINT, I WOULD BE ELIGIBLE TO REPLACE THE HAZARD SWITCH AT NO COST. *TR
NHTSA ODI #10237270
30,400 miles · Jul 24, 2008
Exterior Lighting
TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE HAZARD WARNING SWITCH WORKED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE DIAGNOSTIC INDICATED THAT THE HAZARD SWITCH WIRE SHORTED OUT, WHICH CAUSED THE HAZARD LIGHTS TO WORK INTERMITTENTLY. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V327000 (EXTERIOR…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE HAZARD WARNING SWITCH WORKED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE DIAGNOSTIC INDICATED THAT THE HAZARD SWITCH WIRE SHORTED OUT, WHICH CAUSED THE HAZARD LIGHTS TO WORK INTERMITTENTLY. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V327000 (EXTERIOR LIGHTING: HAZARD: FLASHING WARNING LIGHTS: SWITCH RECALL). THE FAILURE MILEAGE WAS 30,400 AND CURRENT MILEAGE WAS 31,100. UPDATED 09/10/08 *BF UPDATED 09/10/08. *JB
NHTSA ODI #10235672
80,145 miles · Jul 6, 2008
Exterior Lighting
WHILE DRIVING IN WITH CRUISE CONTROL ON AT 55 MPH, THE CRUISE QUIT WITH NO WARNING AND THE TURN SIGNALS STOPPED WORKING. ALTHOUGH THE CRUISE HAS HAD NO PROBLEMS TO DATE, HAVE TO TAP (SOMETIMES BEAT) ON THE TOP OF THE DASH TO GET THE TURN SIGNALS WORKING AGAIN. HAVE HAD A COUPLE OF CLOSE CALLS WHERE I HAD SOMEONE BEHIND ME - TH…
Read full complaint
WHILE DRIVING IN WITH CRUISE CONTROL ON AT 55 MPH, THE CRUISE QUIT WITH NO WARNING AND THE TURN SIGNALS STOPPED WORKING. ALTHOUGH THE CRUISE HAS HAD NO PROBLEMS TO DATE, HAVE TO TAP (SOMETIMES BEAT) ON THE TOP OF THE DASH TO GET THE TURN SIGNALS WORKING AGAIN. HAVE HAD A COUPLE OF CLOSE CALLS WHERE I HAD SOMEONE BEHIND ME - THE SIGNALS WOULD JUST STOP. SAW NHTSA CAMPAIGN ID 03V327 BUT THAT RECALL WAS FOR 2000-2001 MALIBU. *TR
NHTSA ODI #10233313
41,600 miles · Jun 20, 2008
Exterior Lighting
TURN INDICATORS INTERMITTENTLY QUIT WORKING. *TR
NHTSA ODI #10231819
70,000 miles · Jun 9, 2008
Exterior Lighting
THE TURN SIGNALS AND HAZARD LIGHTS WORK INTERNITTANTLY ON THIS AND SOMETIMES NOT AT ALL. *TR
NHTSA ODI #10230345
68,961 miles · Jun 3, 2008
Exterior Lighting
TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 45 MPH, THE TURN SIGNAL MECHANISM FAILED. THE TURN SIGNAL HAS NOT YET BEEN REPAIRED. THE CONTACT PLANS TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER FOR REPAIR. THE CURRENT AND FAILURE MILEAGES WERE 68,961.
NHTSA ODI #10229799
90,000 miles · May 7, 2008
Exterior Lighting
I HAVE A 2002 CHEVY MALIBU. IT HAS THE TURN SIGNAL/FLASHER PROBLEM THAT WAS COVERED IN PE05055. THE DEALER INSTALLED THE NEW FLASHER PER THE SERVICE LETTER BUT THIS DID NOT FIX THE PROBLEM. DEALER WANTS $94 TO DIAGNOSE THE REAL PROBLEM PLUS POSSIBLY HUNDREDS TO FIX IT. CHEVY CUSTOMER SERVICE WILL NOT DO ANYTHING UNTIL I PAY …
Read full complaint
I HAVE A 2002 CHEVY MALIBU. IT HAS THE TURN SIGNAL/FLASHER PROBLEM THAT WAS COVERED IN PE05055. THE DEALER INSTALLED THE NEW FLASHER PER THE SERVICE LETTER BUT THIS DID NOT FIX THE PROBLEM. DEALER WANTS $94 TO DIAGNOSE THE REAL PROBLEM PLUS POSSIBLY HUNDREDS TO FIX IT. CHEVY CUSTOMER SERVICE WILL NOT DO ANYTHING UNTIL I PAY FOR THE DIAGNOSIS, EVEN THEN THEY WILL NOT GIVE ANY ASSURANCES. A QUICK INTERNET SEARCH INDICATES THAT MANY OTHERS HAVE HAD SIMILAR EXPERIENCES. I THINK THAT YOU CLOSED YOUR INVESTIGATION PREMATURELY. *TR
NHTSA ODI #10226971
120,000 miles · Mar 4, 2008
Exterior Lighting
TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE HAZARD LIGHTS FAILED. THEY BEGAN WORKING INTERMITTENTLY, BUT WERE BLINKING VERY FAST. CURRENTLY, THE HAZARD LIGHTS DO NOT WORK AT ALL. THE DEALER STATED THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 02V107000 (EXTERIOR LIGHTING:HEADLIGHTS) AND INVESTIGATION NUMBER …
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE HAZARD LIGHTS FAILED. THEY BEGAN WORKING INTERMITTENTLY, BUT WERE BLINKING VERY FAST. CURRENTLY, THE HAZARD LIGHTS DO NOT WORK AT ALL. THE DEALER STATED THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 02V107000 (EXTERIOR LIGHTING:HEADLIGHTS) AND INVESTIGATION NUMBER PE05055 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH EXTERIOR LIGHTING: TURN SIGNAL:SWITCH). THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 133,000 AND FAILURE MILEAGE WAS 120,000. UPDATED 03/26/08. *LJ THE CONSUMER HAS REPLACED BULBS AND FUSES IN AN ATTEMPT TO CORRECT THE PROBLEM
NHTSA ODI #10220032
60,000 miles · Feb 14, 2008
Exterior Lighting
THERE HAVE BEEN PROBLEMS WITH MY HAZARD SWITCH AND BLINKERS ON MY CAR. THEY WORK BASICALLY WHEN THEY WANT TO. I HAD BROUGHT IT TO A CHEVROLET DEALER OVER A YEAR AGO AND THEY HAD NO IDEA WHAT I WAS REFERRING TO. IT SEEMS AS IF ITS A DEFECT WITH THE CAR AND I'M NOT SURE BOUT FINDING OUT WHAT TO DO ABOUT IT. *TR
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES WERE PRODUCED WITH A LEFT LOW-BEAM HEADLAMP THAT DOES NOT MEET THE PHOTOMETRIC PERFORMANCE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: LIGHT INTENSITIES BELOW THE MINIMUM INTENSITY REQUIREMENTS CAUSE REDUCTION IN VISIBILITY DOWN THE ROAD FOR THE DRIVER OF THE VEHICLE AND INTENSITIES ABOVE THE MAXIMUM INTENSITY REQUIREMENTS CAUSE INCREASE IN GLARE FOR DRIVERS AHEAD OF, OR APPROACHING, THE VEHICLE.
Remedy: DEALERS WILL INSPECT THE LEFT LOW-BEAM HEADLAMP AND REPLACE IT IF IT DOES NOT MEET REQUIREMENTS. OWNER NOTIFICATION BEGAN MAY 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2002 Chevrolet Malibu Problems, Complaints & Recalls | Skip That Year
Illustration