BOTH REAR TIRES VEERUBBER TAIGA H/T SIZE LT 245/75R16 DOT # 6MSG-CH HAD BECOME UNSERVICEABLE DUE THE INSIDE SIDE WALL BELT PLYS SEPARATING RENDERING THE VEHICLE UNSAFE TO OPERATE. THE TIRES WERE REPLACED ON 5 MAR 2021 WITH NEW COPPER STFR SOLARUS LT245/75R16 THROUGH MAVIS TIRE WHICH HAD INSTALLED THE TAIGA TIRES MENTIONED ABOVE…
Read full complaint
BOTH REAR TIRES VEERUBBER TAIGA H/T SIZE LT 245/75R16 DOT # 6MSG-CH HAD BECOME UNSERVICEABLE DUE THE INSIDE SIDE WALL BELT PLYS SEPARATING RENDERING THE VEHICLE UNSAFE TO OPERATE. THE TIRES WERE REPLACED ON 5 MAR 2021 WITH NEW COPPER STFR SOLARUS LT245/75R16 THROUGH MAVIS TIRE WHICH HAD INSTALLED THE TAIGA TIRES MENTIONED ABOVE ON 21 MAY 2020. THIS IS UNACCEPTABLE FOR THESE TIES SINCE THEY ONLY APPROXIMATELY 15000 MILES ON THEM AND THEY HAD A SERVICE LIFE OF 45000 MILES. THIS ISSUE CAME TO LIGHT WHEN WE WERE OPERATING OUR VAN ON A HIGHWAY TRAVELING AT APPROXIMATELY 60 MILES AN HOUR.
NHTSA ODI #11402633
27,000 miles · Jul 28, 2007
SuspensionWheels
SUBJECT VEHICLE IS A 2005 CHEVY EXPRESS/EXPLORER CONVERSION VAN. THE PASSENGER SIDE SHOCK TOWER STEEL ARM COMPLETELY SEPARATED AT THE WELDED POINT. I DROVE VEHICLE TO CLOSEST DEALER. WAS TOLD THAT THE VEHICLE TOOK A HIT AND THAT IT WAS NOT COVERED BY MANUFACTURER'S WARRANTY, AND THAT IT WAS NOT SAFE TO DRIVE. WAS TOLD THAT AU…
Read full complaint
SUBJECT VEHICLE IS A 2005 CHEVY EXPRESS/EXPLORER CONVERSION VAN. THE PASSENGER SIDE SHOCK TOWER STEEL ARM COMPLETELY SEPARATED AT THE WELDED POINT. I DROVE VEHICLE TO CLOSEST DEALER. WAS TOLD THAT THE VEHICLE TOOK A HIT AND THAT IT WAS NOT COVERED BY MANUFACTURER'S WARRANTY, AND THAT IT WAS NOT SAFE TO DRIVE. WAS TOLD THAT AUTO INSURANCE MIGHT COVER THE DAMAGE. AT NO TIME WAS THAT VEHICLE INVOLVED IN AN ACCIDENT. FILED CLAIM WITH ALLSTATE. DEALER REPAIR SHOP WAS AUTHORIZED BY IN-HOUSE ADJUSTER TO DETERMINE IF DAMAGE WAS COVERED. INSURANCE ADJUSTER CALLED TO SAY THEY WOULD COVER THE CLAIM. WE DISPUTED THE CLAIM AND ASKED THE ADJUSTER TO VISUALLY INSPECT THE VEHICLE HIMSELF BECAUSE WE FELT IT WAS A MANUFACTURER'S DEFECT. ADJUSTER CONCURRED AND DENIED THE CLAIM. [WE WERE DISTURBED BY THE WAY OUR CLAIM WAS HANDLED AND WONDERED IF INSURANCE FRAUD WAS BEING PLAYED OUT. WE ARE FOLLOWING THRU WITH THE STATE INSURANCE DEPT.] WHEN THE CLAIM WAS DENIED THE DEALER TOLD US TO TAKE THE VEHICLE TO WHERE WE PURCHASED IT BECAUSE THEY THEN DETERMINED THAT IT WAS A CONVERSION VAN COMPANY ISSUE. WE TOOK THE VEHICLE TO OUR DEALERSHIP AND THEY DETERMINED THAT THE CONVERSION COMPANY INSTALLED 20 INCH RIMS/TIRES ON A VEHICLE WITH 16 INCH MAXIMUM RIM/TIRE REQUIREMENT PER ENGINEERING SPECS. THE QUESTIONS THAT ARISE NOW ARE: WHY DID THEY SELL TO US A VEHICLE WHICH DOES NOT MEET ENGINEERING SPECS? TO WHAT EXTENT WAS MY FAMILY AT RISK OR IN DANGER? HOW MANY OTHER FAMILIES ARE THERE WHO ARE POTENTIALLY AT RISK DUE TO THIS CONDITION? WHAT ARE THE CHANCES THAT THIS WON'T HAPPEN AGAIN? WHAT RECOURSE DO WE HAVE? WE CERTAINLY DO NOT WANT THAT VEHICLE BACK IF WE CANNOT HAVE THE 20 INCH RIMS/TIRES. [LOW PROFILE TIRES] 16 INCH RIMS/TIRES WILL TAKE AWAY FROM THE LOOK OF THE VEHICLE. *TR
CUSTOMIZERS IS RECALLING 3 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES," THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence & remedy
Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Remedy: CUSTOMIZERS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000.
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence & remedy
Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy: MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence & remedy
Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy: MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
MOBILITY IS RECALLING 86 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VAN EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence & remedy
Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy: MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY AT 714-674-0480.
MOBILITY IS RECALLING 43 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence & remedy
Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Remedy: MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY AT 714-674-0480.
ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALER WILL REPLACE ONLY THE UPPER BUCKLE COVER. THE RECALL WILL BE CONDUCTED IN PHASES. THE FIRST PHASE MAILING BEGAN DURING MARCH 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
CERTAIN CONVERSION VANS BUILT ON GMC/CHEVROLET CHASSIS FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT." THE HOUSING LENS OF THE CENTER HIGH MOUNTED STOP LAMP DOES NOT ALLOW ENOUGH LIGHT TO EMIT FROM THE LAMP.
Consequence & remedy
Consequence: FOLLOWING VEHICLES MAY NOT BE FULLY INFORMED OF VEHICLE BRAKING. REAR-END COLLISIONS AND INJURY TO OCCUPANTS MAY OCCUR.
Remedy: SANTA FE IS WORKING WITH AUDIOVOX TO REPLACE THE CENTER HIGH-MOUNTED BRAKE LAMP ASSEMBLY. OWNERS MAY CONTACT SANTA FE AT 1-800-274-1886 OR ASA AT 1-574-266-3172.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Chevrolet Express Problems, Complaints & Recalls | Skip That Year
Illustration