2008 Chevrolet Express

2008 Chevrolet Express van stalled while driving. I was able to coast over to the highway's shoulder. Van restarted after a few attempts and I resumed driving towards a small town ahead. Van re-stalled in the town. Attendant at small garage said the van had diagnostic codes for the fuel system. I was able to idle the van to a Chevrolet dealership for servicing. The dealership diagnosed and replaced the Fuel Pump Driver Module (part 20759945) (aka: Chassis Electronic Control Module) 17-days later, for about $650. Why wasn't I given notice and serviced under GM Recall Bulletin 14515 or 14515B, which specifies my van and that exact part? The dealership said my van is not part of that recall. The NHTSA site says my van has no pending recalls. The problem is serious enough that the Recall Bulletin applies regardless of years or miles. Even if an affected vehicle came in for an oil change, it can't be released until 20759945 is replaced. Van now suffering from code for upset oxygen sensor. VAN IS SPECIFIED IN THE RECALL BULLETIN BUT WAS NOT ADDED TO THE DATABASE OF VEHICLES TO BE SERVICED! The contact stated that the dealership told them that the module failure "probably" did not ruin the catalytic converters. The contact said they would look into the issue within their home garage.

TL* THE CONTACT OWNS A 2008 CHEVROLET EXPRESS. WHILE DRIVING, THE TRANSMISSION DISENGAGED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE CONTROL MODULE AND TRANSMISSION CONTROL MODULE NEEDED TO BE REPROGRAMMED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V313000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000. UPDATED 10/28/16*LJ THE CONSUMER STATED THE LOCAL DEALER REPROGRAMMED THE ECM AND TCM. UPDATED 11/02/16.*JB

WHEN I WAS DRIVING IN MY LOCAL AREA,MY BRAKES STARTED TO GIVE OUT.IN ORDER TO STOP I NEEDED TO PRESS VERY HARD ON THE BRAKES TO STOP. NOT EASY TO DO.THE WARNING BRAKE INDICATOR LIGHT CAME ON.I TOOK IT TO A LOCAL AUTO REPAIR SHOP.THEY SAID THEY COULD NOT FIX IT.THE BRAKE LINE WAS THE ISSUE.THEY FILLED IT WITH BRAKE FLUID THEN I WAS ABLE TOO DRIVE IT TO THE DEALER WHO THEN REPAIRED THE LINE ,FOR 600 DOLLARS. MY QUESTION IS WERE THERE OTHER COMPLAINTS ABOUT THIS ISSUE.?IF MY KIDS WERE DRIVING THIS IT MIGHT HAVE BEEN A DIFFERENT STORY.THANK GOODNESS NO ONE WAS HURT. THERE WAS NO OTHER INDICATORS OF THIS ISSUE. *TR

THE SIDE DOORS ON BOTH SIDES VERY HARD TO OPEN BECAUSE YOU CANNOT GREASE THEM, THE SUNROOF LEAKS ,BACK REAR DOORS HANDLES STOP WORKING, TOOK THESE PROBLEMS SEVERAL TIMES TO BE ADDRESS AND PAID FOR SOME OF THE WORK TO BE DONE TO NO AVAIL STILL HAVE THE PROBLEMS, I HAVE A SON THAT'S DISABLE AND ITS VERY DANGEROUS IF SOMETHING HAPPENS AND WE CANNOT GET HIM OUT THE DOORS, PLUS THE SUNROOF LEAKS SO BAD THAT ANYONE IN THE REAR WILL GET SOAK AGAIN PAID TO HAVE IT DONE BUT TO NO AVAIL. CALL GM BUT AGAIN NO HELP JUST WAS TOLD THEY KNEW ABOUT THE PROBLEM AND THAT'S WHY THEY CHANGE THE HINGES THIS YEAR, GRANTED I HAD THIS PROBLEM WITH THE HINGES ON A 2001 CHEVY 1500 EXPRESS BOTH VAN I PURCHASED NEW TO SAY I HAD THESE PROBLEMS WITHIN A FEW WEEKS OR MONTHS AFTER PURCHASE AND NO RECALL AND TO SAY THEY KNEW ABOUT THE PROBLEM. *TR

WHILE DRIVING DOWN THE ROAD AT APPROXIMATELY 50 MPH ALL WARNING LIGHTS ON THE DASH LIT UP, THE SPEEDOMETER CEASED TO FUNCTION, THE RADIO CUT OUT, THE AIRBAGS WERE REPORTING AS NONFUNCTIONAL, THE ABS SYSTEM WAS REPORTING NONFUNCTIONAL. TOOK VEHICLE TO LOCAL MECHANIC WHO SAID THE PROBLEM APPEARED TO BE CAUSED BY CORROSION ON THE ABS SENSOR AS WELL AS CORROSION ON THE POWER DISTRIBUTION CABLES INTO THE FUSE BOX. ACCORDING TO THE MECHANIC GM WAS AWARE OF THE PROBLEM, AS TECHNICAL BULLETINS DATING BACK TO AROUND 2005 WERE ISSUED. HE ALSO STATED SHOULD IT HAPPEN AT THE TIME OF AN ACCIDENT THE AIR BAGS WOULD LIKELY FAIL TO DEPLOY, AND THE PROBLEM IN GENERAL COULD LEAD TO THE POSSIBILITY OF A VEHICLE FIRE. ACCORDING TO HIM THE ENTIRE PROBLEM COULD HAVE BEEN AVOIDED BY THE MANUFACTURER IF THEY HAD MADE SURE THE CABLES WERE WRAPPED IN SHRINK TUBE-THUS ELIMINATING THE INTRODUCTION OF MOISTURE TO THE ELECTRICAL WIRES. *TR

TL* THE CONTACT OWNS A 2008 CHEVROLET EXPRESS. THE CONTACT WAS DRIVING 45 MPH WHEN THE EXTERIOR AND INTERIOR LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER SEVEN TIMES. THE DEALER STATED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 12,000 AND THE CURRENT MILEAGE WAS 47,115.

WHILE MERGING ON THE EXPRESSWAY THE TRANSMISSION FAILED TO SHIFT OUT OF FIRST OR SECOND GEAR CAUSING HIGH ENGINE RPM'S . I HAD TO SHIFT INTO NEUTRAL AND BACK INTO DRIVE SEVERAL TIMES BUT IT STILL FAILED TO SHIFT INTO ANY GEAR. I HAD TO PUT ON FLASHERS ( HEAVY TRAFFIC ) AND MAKE MY WAY TO THE EMERGENCY LANE. WHEN I CAME TO A COMPLETE STOP AND SHIFTED BACK INTO DRIVE IT SHIFTED CORRECTLY. I HAVE HAD THIS PROBLEM FOR SEVERAL MONTHS TO PRESENT DATE. I TOOK THE VAN TO THE DEALERSHIP WHO SAID THEY COULD NOT REPLICATE THE PROBLEM AND THEIR WERE NO CODE REPORTS SO THEY COULD NOT FIX THE ISSUE. THIS IS STILL A VERY REAL DANGER FOR MY FAMILY ( SEVEN CHILDREN ) BECAUSE THIS MALFUNCTION OCCURS WHILE AT HIGH SPEEDS USUALLY WHILE ENTERING THE EXPRESSWAY. *TR