DURING THE TIME OF JUNE 24 2007 I WAS INVOLVED IN A ACCIDENT WHERE THE VALVE STEM BLOW OUT OF A TIRE AND THE TIRE BLEW OF THE RIM AT NIGHT CAUSING MY CAR TO GO OFF THE ROAD INTO A DITCH EMBANKMENT AND CAUSE THE CAR TO BE CONSIDERED TO BE TOTAL AND I THEN CONTACTED THE COMPANY OF FIRESTONE ON RESEARCH BLVD HERE IN AUSTIN TX .I WA…
Read full complaint
DURING THE TIME OF JUNE 24 2007 I WAS INVOLVED IN A ACCIDENT WHERE THE VALVE STEM BLOW OUT OF A TIRE AND THE TIRE BLEW OF THE RIM AT NIGHT CAUSING MY CAR TO GO OFF THE ROAD INTO A DITCH EMBANKMENT AND CAUSE THE CAR TO BE CONSIDERED TO BE TOTAL AND I THEN CONTACTED THE COMPANY OF FIRESTONE ON RESEARCH BLVD HERE IN AUSTIN TX .I WAS INJURED WITH NECK PAINS AND BACK PAINS . CALL #200703564 ELGIN TEXAS 78621 ELGIN POLICE DEPARTMENT #5122855757. *TR
NHTSA ODI #10235242
1,666 miles · Mar 25, 2005
Air BagsExterior LightingService Brakes, Hydraulic
CHEVROLET CAVALIER Z 2003, MULTIPLE FAILURES. *BF THE DEFROSTER WOULD NOT CLEAR THE WINDOWS, THE HEATER DID NOT WORK, THE AIR BAG LIGHT ILLUMINATED BECAUSE THERE WAS A SPLIT IN THE CENTER OF THE STEERING WHEEL. WHEN THE CONSUMER MADE A RIGHT TURN A NOISE WAS HEARD. THE LEFT REAR TURN SIGNAL BULB WAS REPLACED, THE RIGHT REA…
Read full complaint
CHEVROLET CAVALIER Z 2003, MULTIPLE FAILURES. *BF THE DEFROSTER WOULD NOT CLEAR THE WINDOWS, THE HEATER DID NOT WORK, THE AIR BAG LIGHT ILLUMINATED BECAUSE THERE WAS A SPLIT IN THE CENTER OF THE STEERING WHEEL. WHEN THE CONSUMER MADE A RIGHT TURN A NOISE WAS HEARD. THE LEFT REAR TURN SIGNAL BULB WAS REPLACED, THE RIGHT REAR BRAKE LIGHT BULB. THERE WAS A NOISE COMING FROM THE FRONT OF THE VEHICLE, THE DEALER LUBED THE FRONT SWAY BAR BUSHING. THE TIRES WERE OVER INFLATED, SO THE VEHICLE WOULD SWAY WHEN GOING OVER BUMPS, THE BLOWER MOTOR, AND HEATER CONTROL WAS REPLACED. THE ABS LAMP ILLUMINATED. THE VEHICLE NEEDED BRAKE PADS. THERE WAS MOLD ON THE DRIVERS FRONT DOOR. THE AC COMPRESSOR WAS REPLACED. THE WINDOW WENT DOWN EXTREMELY SLOW, THE DEALER LUBED THE WINDOW TRACK AND REGULATOR. THE FOG LIGHT BULB WAS INOPERATIVE, THE DOOR LATCH WAS INOPERATIVE. *JB
NHTSA ODI #10115838
Mileage unknown · Oct 30, 2003
Tires
ON SEPT 23, 2003 I CALLED THE SERVICE DEPARTMENT AT SHOWCASE CHEVROLET WHERE I BOUGHT THE CAVALIER. TALKED TO A SERVICE ADVISOR ABOUT THE PROBLEM WITH MY VEHICLE. THE CAR WAS VERY HARD TO HANDLE ON GROOVE ROADS. IT FELT LIKE THE BACK-END WAS GOING ONE WAY AND THE FRONT THE OTHER. HE SAID HE WOULD LOOK AT IT, HE STATED THAT T…
Read full complaint
ON SEPT 23, 2003 I CALLED THE SERVICE DEPARTMENT AT SHOWCASE CHEVROLET WHERE I BOUGHT THE CAVALIER. TALKED TO A SERVICE ADVISOR ABOUT THE PROBLEM WITH MY VEHICLE. THE CAR WAS VERY HARD TO HANDLE ON GROOVE ROADS. IT FELT LIKE THE BACK-END WAS GOING ONE WAY AND THE FRONT THE OTHER. HE SAID HE WOULD LOOK AT IT, HE STATED THAT THEY PUT MORE AIR IN THE TIRES AND THAT SHOULD DO IT. THE NEXT DAY I CALLED AND ASK TO SPEAK TO THE SERVICE MANAGER AS THE VEHICLE WAS WORSE. TROY (SVC. MGR.) SAID HE WOULD DRIVE WITH ME. WE TOOK THE VEHICLE DOWN THE ROAD AND IT SWERVED AND TROY STATED TO ME HE FELT THE PROBLEM AND WAS HOLDING ON. HE TOLD ME TO TAKE IT BACK AS HE IS NOT SAFE IN IT. HE STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE AND THAT HE FEELS THAT IT IS THE TIE RODS. HE TOOK THE VEHICLE BACK TO THE SHOP AND READJUSTED THE TIE RODS, REBALANCED TIRES, AND STATED THAT HE DROVE THE OTHER CAVALIERS AND ALL WITH 14 INCH TIRES HAD THE SAME PROBLEM. I ASKED HIM WHAT HE COULD DO ABOUT THIS AND HE STATED THAT THE VEHICLES WITH 15 INCH TIRES DIDN'T DO THAT AND WE COULD BUY RIMS AND TIRES AND HE FEELS THAT SHOULD SOLVE THE PROBLEM. ON THE THIRD TRIP TO THE SERVICE DEPT. HE SAID HE COULDN'T HELP WITH THE TIRES AS THEY DIDN'T HAVE ANY 15 INCH RIMS AROUND AND I WOULD HAVE TO PAY FOR THEM. HE STATED HE COULD NOT WARRANTY THEM OUT AS IT IS AN UPGRADE IN THE VEHICLE. I HAVE NO WAY OF KNOWING THAT PUTTING 15 INCH TIRES ON THIS VEHICLE WILL SOLVE THE PROBLEM. I HAVE CONTACTED GM AND THEY STATE THE VEHICLE IS UP TO THEIR SPECIFICATIONS FOR THAT CAR AND THEY WILL NOT DO ANYTHING TO THE VEHICLE OR VEHICLE WITH 14 INCH TIRES. IT WAS NOT BROUGHT UP AS AN OPTION TO ME WHEN I BOUGHT THE VEHICLE AS THE GM CUSTOMER SERVICE REPRESENTATIVE STATED. HOW CAN THEY LET THESE CARS STAY ON THE ROAD WITH A PROBLEM CONTROLLING THEM ON GROOVE ROADS? THE SERVICE MANAGER STATED THAT HE WOULD NOT DRIVE THIS VEHICLE ON THE ROAD DURING RAIN OR SNOW AS YOU COULD EASILY LOOSE CONTROLS IN THE GROOVES. *LA
ON CERTAIN PASSENGER VEHICLES, THE REAR LAMPS THAT PROVIDE STOP AND TURN SIGNALS AND TAIL LAMP FUNCTIONS STOP WORKING BECAUSE OF INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET. IN ADDITION, IF ONE BULBS WERE TO BECOME INOPERATIVE WHILE THE VEHICLE WAS OPERATING IN CRUISE CONTROL, THE CRUISE CONTROL WOULD DISENGAGE WHEN THE REMAINING BULB WAS ACTIVATED. IF BOTH LAMPS WERE TO BECOME INOPERATIVE, THE CRUISE CONTROL WOULD NOT ENGAGE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR LAMP BULB SOCKET ASSEMBLIES AND APPLY GREASE OR REPLACE THEM IF NECESSARY. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ODI'S ANALYSIS OF THE STALLING INCIDENTS THAT HAVE RESULTED FROM SUBJECT COMPONENT FAILURES FOUND THAT THEY CAN OCCUR AT ANY SPEED AND GENERALLY RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE POTENTIAL SEVERITY OF STALLING INCIDENTS.HOWEVER, THESE INCIDENTS HAVE OCCURRED AT RELATIVELY LOW RATES IN THE SUBJECT VEHICLE POPULATION WHEN COMPARED WITH PRIOR INVESTIGATIONS INVOLVING SIMILAR CATEGORIES OF ENGINE STALL CONSEQUENCES.EVEN FOR THE EARLY MY 2003 PRODUCTION, WHERE HIGHER FAILURE RATES WERE NOTED, THE RATES OF PUMP FAILURES RESULTING IN ENGINE STALL ARE LOWER THAN RATES RECORDED IN PRIOR INVESTIGATIONS OF POPULATIONS THAT WERE NOT RECALLED.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR MORE INFORMATION ABOUT THIS CLOSING RESUME.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
ODI'S ANALYSIS OF THE STALLING INCIDENTS THAT HAVE RESULTED FROM SUBJECT COMPONENT FAILURES FOUND THAT THEY CAN OCCUR AT ANY SPEED AND GENERALLY RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE POTENTIAL SEVERITY OF STALLING INCIDENTS.HOWEVER, THESE INCIDENTS HAVE OCCURRED AT RELATIVELY LOW RATES IN THE SUBJECT VEHICLE POPULATION WHEN COMPARED WITH PRIOR INVESTIGATIONS INVOLVING SIMILAR CATEGORIES OF ENGINE STALL CONSEQUENCES.EVEN FOR THE EARLY MY 2003 PRODUCTION, WHERE HIGHER FAILURE RATES WERE NOTED, THE RATES OF PUMP FAILURES RESULTING IN ENGINE STALL ARE LOWER THAN RATES RECORDED IN PRIOR INVESTIGATIONS OF POPULATIONS THAT WERE NOT RECALLED.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR MORE INFORMATION ABOUT THIS CLOSING RESUME.
Fuel System, Gasoline:delivery
ODI'S ANALYSIS OF THE STALLING INCIDENTS THAT HAVE RESULTED FROM SUBJECT COMPONENT FAILURES FOUND THAT THEY CAN OCCUR AT ANY SPEED AND GENERALLY RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE POTENTIAL SEVERITY OF STALLING INCIDENTS.HOWEVER, THESE INCIDENTS HAVE OCCURRED AT RELATIVELY LOW RATES IN THE SUBJECT VEHICLE POPULATION WHEN COMPARED WITH PRIOR INVESTIGATIONS INVOLVING SIMILAR CATEGORIES OF ENGINE STALL CONSEQUENCES.EVEN FOR THE EARLY MY 2003 PRODUCTION, WHERE HIGHER FAILURE RATES WERE NOTED, THE RATES OF PUMP FAILURES RESULTING IN ENGINE STALL ARE LOWER THAN RATES RECORDED IN PRIOR INVESTIGATIONS OF POPULATIONS THAT WERE NOT RECALLED.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR MORE INFORMATION ABOUT THIS CLOSING RESUME.
Fuel System, Gasoline
ODI'S ANALYSIS OF THE STALLING INCIDENTS THAT HAVE RESULTED FROM SUBJECT COMPONENT FAILURES FOUND THAT THEY CAN OCCUR AT ANY SPEED AND GENERALLY RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE POTENTIAL SEVERITY OF STALLING INCIDENTS.HOWEVER, THESE INCIDENTS HAVE OCCURRED AT RELATIVELY LOW RATES IN THE SUBJECT VEHICLE POPULATION WHEN COMPARED WITH PRIOR INVESTIGATIONS INVOLVING SIMILAR CATEGORIES OF ENGINE STALL CONSEQUENCES.EVEN FOR THE EARLY MY 2003 PRODUCTION, WHERE HIGHER FAILURE RATES WERE NOTED, THE RATES OF PUMP FAILURES RESULTING IN ENGINE STALL ARE LOWER THAN RATES RECORDED IN PRIOR INVESTIGATIONS OF POPULATIONS THAT WERE NOT RECALLED.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR MORE INFORMATION ABOUT THIS CLOSING RESUME.
AN ENGINEERING ANALYSIS HAS BEEN OPENED TO FURTHER INVESTIGATE THE SCOPE, FREQUENCY AND POTENTIAL SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.GENERAL MOTORS (GM) HAS IDENTIFIED AN ISSUE WITH ACCELERATED MOTOR BRUSH WEAR IN THE FUEL PUMP ASSEMBLY OF MODEL YEAR (MY) 2001 THROUGH 2003 CHEVROLET VEHICLES THAT CAN CAUSE THE PUMP TO STOP OPERATING.GENERAL MOTORS INDICATED THAT PEROXIDE OR SULFUR, WHICH ARE BOTH PRESENT IN VARYING AMOUNTS IN GASOLINE, CAN REACT WITH THE COPPER COMMUTATOR OF THE PUMP MOTOR AND CORRODE/ROUGHEN THE SURFACE.A ROUGH COMMUTATOR SURFACE INCREASES THE RATE OF BRUSH WEAR.THE INCREASED ELECTRICAL RESISTANCE CAUSED BY DEGRADATION OF THE BRUSH-COMMUTATOR INTERFACE INHIBITS CURRENT FLOW THROUGH THE MOTOR WINDINGS.ACCORDING TO GM, THE CONDITION WILL USUALLY RESULT IN A NO-START CONDITION BECAUSE OF THE HIGH CURRENT REQUIRED DURING START-UP.WHEN THE ALLEGED DEFECT DOES CAUSE A STALL WHILE DRIVING INCIDENT, THE VEHICLE TYPICALLY CANNOT BE RESTARTED.GM'S ANALYSIS OF WARRANT CLAIMS SHOWED THAT NO START/HARD START WAS THE MOST COMMON CONDITION AND THE FREQUENCY OF CLAIMS ASSOCIATED WITH STALL WHILE DRIVING INCIDENTS WAS TOO LOW TO WARRANT FIELD ACTION. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-015) TO FURTHER ASSESS THE COMPLAINT AND WARRANTY CLAIM DATA AND THE ANALYSES PROVIDED BY GM.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
AN ENGINEERING ANALYSIS HAS BEEN OPENED TO FURTHER INVESTIGATE THE SCOPE, FREQUENCY AND POTENTIAL SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.GENERAL MOTORS (GM) HAS IDENTIFIED AN ISSUE WITH ACCELERATED MOTOR BRUSH WEAR IN THE FUEL PUMP ASSEMBLY OF MODEL YEAR (MY) 2001 THROUGH 2003 CHEVROLET VEHICLES THAT CAN CAUSE THE PUMP TO STOP OPERATING.GENERAL MOTORS INDICATED THAT PEROXIDE OR SULFUR, WHICH ARE BOTH PRESENT IN VARYING AMOUNTS IN GASOLINE, CAN REACT WITH THE COPPER COMMUTATOR OF THE PUMP MOTOR AND CORRODE/ROUGHEN THE SURFACE.A ROUGH COMMUTATOR SURFACE INCREASES THE RATE OF BRUSH WEAR.THE INCREASED ELECTRICAL RESISTANCE CAUSED BY DEGRADATION OF THE BRUSH-COMMUTATOR INTERFACE INHIBITS CURRENT FLOW THROUGH THE MOTOR WINDINGS.ACCORDING TO GM, THE CONDITION WILL USUALLY RESULT IN A NO-START CONDITION BECAUSE OF THE HIGH CURRENT REQUIRED DURING START-UP.WHEN THE ALLEGED DEFECT DOES CAUSE A STALL WHILE DRIVING INCIDENT, THE VEHICLE TYPICALLY CANNOT BE RESTARTED.GM'S ANALYSIS OF WARRANT CLAIMS SHOWED THAT NO START/HARD START WAS THE MOST COMMON CONDITION AND THE FREQUENCY OF CLAIMS ASSOCIATED WITH STALL WHILE DRIVING INCIDENTS WAS TOO LOW TO WARRANT FIELD ACTION. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-015) TO FURTHER ASSESS THE COMPLAINT AND WARRANTY CLAIM DATA AND THE ANALYSES PROVIDED BY GM.
Fuel System, Gasoline:delivery
AN ENGINEERING ANALYSIS HAS BEEN OPENED TO FURTHER INVESTIGATE THE SCOPE, FREQUENCY AND POTENTIAL SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.GENERAL MOTORS (GM) HAS IDENTIFIED AN ISSUE WITH ACCELERATED MOTOR BRUSH WEAR IN THE FUEL PUMP ASSEMBLY OF MODEL YEAR (MY) 2001 THROUGH 2003 CHEVROLET VEHICLES THAT CAN CAUSE THE PUMP TO STOP OPERATING.GENERAL MOTORS INDICATED THAT PEROXIDE OR SULFUR, WHICH ARE BOTH PRESENT IN VARYING AMOUNTS IN GASOLINE, CAN REACT WITH THE COPPER COMMUTATOR OF THE PUMP MOTOR AND CORRODE/ROUGHEN THE SURFACE.A ROUGH COMMUTATOR SURFACE INCREASES THE RATE OF BRUSH WEAR.THE INCREASED ELECTRICAL RESISTANCE CAUSED BY DEGRADATION OF THE BRUSH-COMMUTATOR INTERFACE INHIBITS CURRENT FLOW THROUGH THE MOTOR WINDINGS.ACCORDING TO GM, THE CONDITION WILL USUALLY RESULT IN A NO-START CONDITION BECAUSE OF THE HIGH CURRENT REQUIRED DURING START-UP.WHEN THE ALLEGED DEFECT DOES CAUSE A STALL WHILE DRIVING INCIDENT, THE VEHICLE TYPICALLY CANNOT BE RESTARTED.GM'S ANALYSIS OF WARRANT CLAIMS SHOWED THAT NO START/HARD START WAS THE MOST COMMON CONDITION AND THE FREQUENCY OF CLAIMS ASSOCIATED WITH STALL WHILE DRIVING INCIDENTS WAS TOO LOW TO WARRANT FIELD ACTION. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-015) TO FURTHER ASSESS THE COMPLAINT AND WARRANTY CLAIM DATA AND THE ANALYSES PROVIDED BY GM.
Fuel System, Gasoline
AN ENGINEERING ANALYSIS HAS BEEN OPENED TO FURTHER INVESTIGATE THE SCOPE, FREQUENCY AND POTENTIAL SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.GENERAL MOTORS (GM) HAS IDENTIFIED AN ISSUE WITH ACCELERATED MOTOR BRUSH WEAR IN THE FUEL PUMP ASSEMBLY OF MODEL YEAR (MY) 2001 THROUGH 2003 CHEVROLET VEHICLES THAT CAN CAUSE THE PUMP TO STOP OPERATING.GENERAL MOTORS INDICATED THAT PEROXIDE OR SULFUR, WHICH ARE BOTH PRESENT IN VARYING AMOUNTS IN GASOLINE, CAN REACT WITH THE COPPER COMMUTATOR OF THE PUMP MOTOR AND CORRODE/ROUGHEN THE SURFACE.A ROUGH COMMUTATOR SURFACE INCREASES THE RATE OF BRUSH WEAR.THE INCREASED ELECTRICAL RESISTANCE CAUSED BY DEGRADATION OF THE BRUSH-COMMUTATOR INTERFACE INHIBITS CURRENT FLOW THROUGH THE MOTOR WINDINGS.ACCORDING TO GM, THE CONDITION WILL USUALLY RESULT IN A NO-START CONDITION BECAUSE OF THE HIGH CURRENT REQUIRED DURING START-UP.WHEN THE ALLEGED DEFECT DOES CAUSE A STALL WHILE DRIVING INCIDENT, THE VEHICLE TYPICALLY CANNOT BE RESTARTED.GM'S ANALYSIS OF WARRANT CLAIMS SHOWED THAT NO START/HARD START WAS THE MOST COMMON CONDITION AND THE FREQUENCY OF CLAIMS ASSOCIATED WITH STALL WHILE DRIVING INCIDENTS WAS TOO LOW TO WARRANT FIELD ACTION. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-015) TO FURTHER ASSESS THE COMPLAINT AND WARRANTY CLAIM DATA AND THE ANALYSES PROVIDED BY GM.
EA04028 · Turn Signal Malfunction
Opened Sep 14, 2004 · Closed Nov 22, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
ON MAY 14, 2004 THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-043) BASED ON CONSUMER COMPLAINTS ALLEGING THAT THE BRAKE/TAIL TURN SIGNAL LAMPS WOULD NOT OPERATE PROPERLY WHEN EITHER THE TAIL LIGHTS WERE TURNED ON, THE BRAKE PEDAL WAS DEPRESSED, OR WHEN THE TURN SIGNAL SWITCH WAS ACTIVATED.ON SEPTEMBER 14, 2004 ODI UPGRADED PE 04-043 TO AN ENGINEERING ANALYSIS (EA04-028).GM STATES THAT SOME BRAKE/TAIL/TURN SIGNAL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO EXCESSIVE HEAT BUILDUP WITHIN THE BULB SOCKETS.THE CAUSE OF THE EXCESSIVE HEAT BUILD UP WAS DETERMINED TO BE A LACK OF THERMAL GREASE PLACED IN BETWEEN THE BULB AND THE SOCKET. BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V524) COVERING ALL MY 2003 VEHICLES.GM DEALERS WILL INSPECT THE REAR LAMP BULB SOCKET ASSEMBLIES AND APPLY THERMAL GREASE TO THEM OR REPLACE THEM WITH NEW ASSEMBLIES WITH THERMAL GREASE ALREADY ATTACHED.MODEL YEAR 2004 AND NEWER VEHICLES HAVE THE THERMAL GREASE INSTALLED FROM THE FACTORY. THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04043 · Turn Signal Malfunction
Opened May 14, 2004 · Closed Sep 14, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
COMPLAINANTS ALLEGE THAT THE REAR TURN SIGNALS FAIL TO ILLUMINATE AND DO NOT PROVIDE A SIGNAL TO DRIVERS IN FOLLOWING VEHICLES.ODI HAS RECEIVED ONE REPORT OF A CRASH WHERE THE COMPLAINANT BRAKED AND ATTEMPTED TO MAKE A LEFT TURN AND THE FOLLOWING VEHICLE IMPACTED THE COMPLAINANT'S VEHICLE IN THE DRIVER-SIDE DOOR.IN MAY 2002, GM'S SUPPLIER MADE CHANGES TO THE BULB SOCKET THAT INCLUDED STOPPING THE USE OF THERMAL-MASTIC GREASE IN THE BULB SOCKET.GM REPORTS THAT THE GREASE REDUCES ARCING AT THE CONTACTS AND DISSIPATES HEAT THUS PREVENTING MELTING OF THE SOCKET MATERIAL OR BURNING OF THE CONTACTS.MOST OF THE SUBJECT VEHICLES WERE PRODUCED WITHOUT GREASE APPLIED TO THE BULB SOCKET.IN JUNE 2003, GM DIRECTED THE SUPPLIER TO RESUME THE USE OF GREASE IN THE SOCKET.GM ISSUED TECHNICAL SERVICE BULLETIN (TSB) 04-08-42-004A ON JULY 15, 2004 ADVISING TECHNICIANS TO MAKE SURE THAT ADEQUATE AMOUNTS OF GREASE WERE ADDED TO THE BULB SOCKETS ON ALL SERVICE PARTS.ODI WILL UPGRADE THIS INVESTIGATION TO EA 04-028 TO FURTHER EXAMINE THE ISSUE.
2003 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration