Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
2125–50K
3050–75K
2375–100K
16100–150K
8150K+
120 reports with mileage · 195 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports8 fire reports13 injury reports
What owners actually said
315 reports
20,800 miles · Mar 15, 2023
Exterior Lighting
The contact owns a 2000 Chevrolet Cavalier. The contact stated that while driving at an unknown speed, the interior passenger side directional signal began blinking rapidly while activated. Additionally, the contact stated that an onlooker observed that the exterior driver side indicator light was not illuminated when indicator …
Read full complaint
The contact owns a 2000 Chevrolet Cavalier. The contact stated that while driving at an unknown speed, the interior passenger side directional signal began blinking rapidly while activated. Additionally, the contact stated that an onlooker observed that the exterior driver side indicator light was not illuminated when indicator was activated. The vehicle was driven to the dealer where it was diagnosed that the interior lighter fuse needed to be replaced. The vehicle was repaired but the failure persisted. The contact stated that when the weather was cooler, the exterior indicator light was experiencing the failure; however, during warmer weather, the indicator lights operated properly. The manufacturer was notified of the failure. The failure mileage was approximately 20,800.
NHTSA ODI #11511963
200,000 miles · Feb 13, 2018
Electrical SystemEngineStructureFire
IGNITION GETS VERY HOT WHEN KEY IS TURNED CAN SMELL PLASTIC IGNITION OR BATT 1 CIRCUIT PROBLEM.CLEARCOAT IS PEELING.LUG NUTS COMING LOOSE
NHTSA ODI #11072678
170,000 miles · Mar 21, 2016
Exterior Lighting
TL* THE CONTACT OWNS A 2000 CHEVROLET CAVALIER. WHILE STOPPED AT A RED LIGHT, THE CONTACT WAS INFORMED THAT THE REAR BRAKE LAMPS FAILED TO ILLUMINATE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000.
NHTSA ODI #10850852
167,000 miles · Dec 28, 2015
Fuel/propulsion SystemSeat BeltsSteering
UNNECESSARY GAS ODORS. SEAT BELTS KEEP UNLOCKING. STEERING
NHTSA ODI #10816442
Mileage unknown · Sep 16, 2015
Structure
REPORTING THIS AS A DEFECT ON CAR LIST ABOVE .I'M PA. STATE INSPECTION STATION. THIS IS JUST ONE OF MANY WE SEE AND REJECT FOR RUST OUT UNIT BODY REAR FRAMES . I FEEL THE PUBLIC SHOULD BE AWARE OF THEY OWN ONE THESE MODELS CAR COULD BUCKLE ON A REAR END COLLISION. I DID NOT SEE THIS ON YOUR SITE TO HAVE BEEN REPORTED THANKS KE…
Read full complaint
REPORTING THIS AS A DEFECT ON CAR LIST ABOVE .I'M PA. STATE INSPECTION STATION. THIS IS JUST ONE OF MANY WE SEE AND REJECT FOR RUST OUT UNIT BODY REAR FRAMES . I FEEL THE PUBLIC SHOULD BE AWARE OF THEY OWN ONE THESE MODELS CAR COULD BUCKLE ON A REAR END COLLISION. I DID NOT SEE THIS ON YOUR SITE TO HAVE BEEN REPORTED THANKS KEN AT C&W PERFORMANCE PA. STATION # E7 .
NHTSA ODI #10764097
97,000 miles · Aug 23, 2015
EngineUnknown Or Other
I HAD THE AIR CONDITIONER REPLACED. THE TECH SAID THE TENSIONER NEEDED TO BE REPLACED. ONE WEEK LATER I RETURNED AND HAD A NEW BELT TENSIONER INSTALLED. ABOUT A MONTH LATER THE NEW AIR CONDITIONER HAD PREMATURE FAILURE. I HAD IT REPAIRED UNDER WARRANTY AND ALSO HAD A NEW DRIVE BELT INSTALLED DURING THE REPAIR. ABOUT ONE YEAR LAT…
Read full complaint
I HAD THE AIR CONDITIONER REPLACED. THE TECH SAID THE TENSIONER NEEDED TO BE REPLACED. ONE WEEK LATER I RETURNED AND HAD A NEW BELT TENSIONER INSTALLED. ABOUT A MONTH LATER THE NEW AIR CONDITIONER HAD PREMATURE FAILURE. I HAD IT REPAIRED UNDER WARRANTY AND ALSO HAD A NEW DRIVE BELT INSTALLED DURING THE REPAIR. ABOUT ONE YEAR LATER I BEGAN HEARING A CHATTER WHEN ACCELERATING FROM STOP POSITION AND HAD EXCESSIVE VIBRATION. I TOOK TO THE SHOP AND THEY SAID THE BELT TENSIONER WAS BAD. THIS SEEMS EXCESSIVELY SHORT LIFE SPAN FOR A REPLACEMENT PART OF GOOD QUALITY. TODAY THE SHOP TRIED THREE DIFFERENT TENSIONERS AND STILL IT WAS NOT CORRECTING THE ISSUE. I EVEN DOUBLE CHECKED THE BELT ROUTING PATTERN TO ENSURE IT WAS CORRECT. I DONT UNDERSTAND WHAT THE PROBLEM IS WITH THE BELT TENSIONERS FOR THIS VEHICLE. ALL MY PRIOR FORD VEHICLE NEVER HAD THIS PROBLEM WITH THEIR TENSIONERS OF SAME DESIGN. PLEASE LOOK INTO THIS PROBLEM AS A BELT THAT BREAKS OR SLIDES OF A PULLEY DUE TO A FAULTY TENSIONER CAN CAUSE IMMEDIATE LOSS OF POWER STEERING RESULTING IN HAZARDOUS AND POTENTIALLY FATAL DRIVING CONDITIONS AND SITUATIONS. ALSO THE BACKLIGHTING ON THE ODOMETER DOES NOT WORK.THE ODOMETER REGISTERS MILAGE DRIVEN BUT THE BACKLIGHT DOES NOT WORK AT ALL.PLEASE LOOK INTO AND DONT WAIT FOR SOMEONE TO HAVE TO DIE BEFORE THIS ISSUE BECOME IMPORTANT.THANKS.
NHTSA ODI #10758684
96,000 miles · Jun 17, 2015
Structure
TL* THE CONTACT OWNS A 2000 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE DASHBOARD CRACKED CAUSING SHARP EDGES. THE CONTACT ALSO STATED THAT THERE WERE CRACKS WERE NEAR THE AIR BAGS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 96,000.
NHTSA ODI #10725682
123,306 miles · Dec 25, 2014
Wheels
WHILE PUMPING MY TIRES WITH AIR I NOTICED MY TWO BACK TIRES (A DIFFERENT BRAND FROM THE TWO FRONT TIRES) HAD CRACKING IN BETWEEN THE TREADS ALL THE WAY AROUND THE TIRES. THIS MUST BE A MANUFACTURERS DEFECT AND AN OBVIOUS SAFETY CONCERN. HERE IS TIRE INFORMATION (AND DESIGNATIONS) AS DESIGNATED ON THE SIDEWALL: REAR DRIVERSIDE…
Read full complaint
WHILE PUMPING MY TIRES WITH AIR I NOTICED MY TWO BACK TIRES (A DIFFERENT BRAND FROM THE TWO FRONT TIRES) HAD CRACKING IN BETWEEN THE TREADS ALL THE WAY AROUND THE TIRES. THIS MUST BE A MANUFACTURERS DEFECT AND AN OBVIOUS SAFETY CONCERN. HERE IS TIRE INFORMATION (AND DESIGNATIONS) AS DESIGNATED ON THE SIDEWALL: REAR DRIVERSIDE TIRE: ACHILES PLATINUM MADE IN INDONESIA (5N1) MANUFACTURED BY MULTI STRADA ARAHSARANA TUBELESS STEEL BELTED RADIAL 195/70 R1491H MOLD NO. 03-02 E4 (ENCIRCLED) 0228041 DOT 5KJN HP 3606 THREAD: 1 POLYESTER, 2 STEEL, 2 NYLON; SIDEWALL 1 POLYESTER THREADWEAR 280 TRACTION A TEMPERATURE A ODDLY ENOUGH, THE REAR PASSENGER TIRE SEEMS TO MATCH THE ABOVE INFORMATION WITH TWO EXCEPTIONS: THREADWEAR 420 TRACTION AA TEMPERATURE A MOLD NO. 03-03 WE BOUGHT TIRES FROM FIGUEROA TIRES IN LOS BANOS. WE DON'T HAVE A RECEIPT TO CONFIRM THIS. THESE TIRES MUST HAVE BEEN PURCHASED BEFORE 04/29/10 SINCE WE DID FIND A SERVICE ORDER RECEIPT FROM WALMART TIRE & LUBE EXPRESS DATED 04/29/10 THAT STATES IN THE TPMS AND TIRE DISCLAIMER RECEIPT: ACTIONS: REPLACE ONE OR MORE OF THE TIRES ON THE VEHICLE...REASONS: VISIBLE TIRE CUT, PUNCTURE, BALD SPOT, OR OTHER IRREGULARITY. *TR
NHTSA ODI #10668234
133,000 miles · Nov 15, 2014
Electrical SystemEngine
AFTER ACCELERATING OVER 35MPH VEHICLE CONTINUES TO ACCELERATE. VEHICLE ABLE TO STOP BUT YOU CAN STILL HEAR AND FEEL THE MOTOR TO CONTINUE TO ACCELERATE AND THE VEHICLE STARTS TO JERK AROUND. ITS VERY UNSAFE AND NO ONE AT THE CAR SHOP ABLE TO TELL ME EXACTLY WHAT IS WRONG. I'VE HAD SEVERAL THINGS FIXED AND STILL HAVING THE SAME…
Read full complaint
AFTER ACCELERATING OVER 35MPH VEHICLE CONTINUES TO ACCELERATE. VEHICLE ABLE TO STOP BUT YOU CAN STILL HEAR AND FEEL THE MOTOR TO CONTINUE TO ACCELERATE AND THE VEHICLE STARTS TO JERK AROUND. ITS VERY UNSAFE AND NO ONE AT THE CAR SHOP ABLE TO TELL ME EXACTLY WHAT IS WRONG. I'VE HAD SEVERAL THINGS FIXED AND STILL HAVING THE SAME PROBLEM. THE VEHICLE SOMETIMES AFTER STARTING UP WILL ACCELERATE ON IT OWN. *TR
NHTSA ODI #10655162
130,000 miles · Sep 3, 2014
EngineSteering
TL* THE CONTACT OWNS A 2000 CHEVROLET CAVALIER. THE CONTACT STATED THE VEHICLE WAS DIFFICULT TO START AND THE STEERING WHEEL BECAME LOOSE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE BI-FUEL OPTION FAIL TO COMPLY WITH FMVSS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION." THE INSTRUMENT PANEL LIGHTS IN THESE VEHICLES ARE AT FULL ILLUMINATION LEVELS AND CANNOT BE ADJUSTED. THE STANDARD REQUIRES AT LEAST TWO LEVELS OF ILLUMINATION.
Consequence & remedy
Consequence: THIS COULD MAKE IT MORE DIFFICULT TO SEE OBJECTS OUTSIDE THE VEHICLE WHEN DRIVING AT NIGHT.
Remedy: DEALERS WILL REPLACE THE FUEL TYPE INDICATOR SWITCH ASSEMBLY, WHICH INCLUDES THE INSTRUMENT PANEL ILLUMINATION CONTROL.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2000 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration