← New search

2004 Chevrolet Cavalier

Owner reports · Recalls · Investigations

More warning signs than most Cavalier years

Owner complaints for the 2004 Chevrolet Cavalier are substantially higher than the model-year median of 140.

About this comparison →

When problems were reported

Mileage at the reported incident

264 reports with mileage · 66 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 185 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Vehicle Speed Control. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

17 crash reports6 fire reports15 injury reports

What owners actually said

330 reports
Mileage unknown · May 17, 2024
Steering

The whole steering column is loose The pins are all backed out I’m afraid to drive it I think this is a manufactured design flaw

NHTSA ODI #11589380

Mileage unknown · Feb 7, 2022
Suspension

The vehicle failed to pass pa. state inspection due to a severely rusted frame over the rear axles. The estimate to repair the frame was @$3000.

NHTSA ODI #11450759

200,000 miles · Nov 1, 2021
Suspension

The contact owns a 2004 Chevrolet Cavalier. The contact stated while driving 10 MPH, the front driver’s side tire had detached. The vehicle was towed to the contact's residence. An independent mechanic went to the contact's residence and diagnosed that the lower control arm rusted and detached from the subframe. The vehicle was …

Read full complaint

The contact owns a 2004 Chevrolet Cavalier. The contact stated while driving 10 MPH, the front driver’s side tire had detached. The vehicle was towed to the contact's residence. An independent mechanic went to the contact's residence and diagnosed that the lower control arm rusted and detached from the subframe. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000.

NHTSA ODI #11438861

85,509 miles · Dec 13, 2020
Power Train

IN THE PARKING LOT WHERE I WORK MY CAR WOULD NOT START. WHEN MOVING THE AUTOMATIC TRANSMISSION LEVER IT DID NOT CATCH ON TO ANYTHING. THE CAR JUST ROLLED BACKWARDS AND I HAD TO IMMEDIATELY PRESS ON THE BRAKES PREVENTING AN ACCIDENT. MY CAR HAD TO BE TOWED TO THE AUTO SHOP. DIAGNOSIS: SHIFTER CABLE WAS DETACHED FROM TRANSMISSION.…

Read full complaint

IN THE PARKING LOT WHERE I WORK MY CAR WOULD NOT START. WHEN MOVING THE AUTOMATIC TRANSMISSION LEVER IT DID NOT CATCH ON TO ANYTHING. THE CAR JUST ROLLED BACKWARDS AND I HAD TO IMMEDIATELY PRESS ON THE BRAKES PREVENTING AN ACCIDENT. MY CAR HAD TO BE TOWED TO THE AUTO SHOP. DIAGNOSIS: SHIFTER CABLE WAS DETACHED FROM TRANSMISSION. PREVIOUSLY ON 09/13/2011 THE SAME THING HAPPENED TO MY CAR. THE SHIFTER CABLE BROKE AND I HAD TO BE TOWED TO LOU BACHRODT CHEVROLET BOTH TIMES. THE 2ND TIME INVOICE NO. CWCS692729 $502.24 AND $477.55 INVOICE NO.CWCS149491 THE FIRST TIME. THIS CAR SHOULD BE RECALLED. TWO TIMES IS TOO MANY.

NHTSA ODI #11383222

49,000 miles · Mar 18, 2020
Seat Belts

CAN'T SAFELY INSTALL A CAR SEAT BECAUSE THE SAFETY BELTS DO NOT PROPERLY RETRACT. THEREFORE THE CAR SEAT IS NOT STABLE. THE VEHICLE WAS STATIONARY.

NHTSA ODI #11318646

11,000 miles · Nov 23, 2019
Vehicle Speed Control

WHEN I'M DRIVEN ABOUT 25 MILES THE ACCELERATOR STAYS STUCK AND THE SPEED KEEP GOIN UP IF YOU DON'T PUT THE BRAKES

NHTSA ODI #11281975

165,700 miles · Nov 4, 2019
Air Bags

AIRBAG LIGHT COMES ON AT RANDOM INTERVALS FOR ABOUT 5 SECONDS, THEN TURNS OFF. SPEED, ROAD CONDITIONS, AND GEAR MAKE NO DIFFERENCE AS TO WHEN IT COMES ON. IT HAS COME ON WHILE TURNING, WHILE DRIVING IN TOWN AT 20 MPH, WHILE AT A COMPLETE STOP, WHILE GOING OVER A BUMP, AND WHILE GOING 50MPH ON THE HIGHWAY.

NHTSA ODI #11277967

166,000 miles · Jun 29, 2019
Steering

EVERY TIME I GO TO MY JOB MY POWER STEERING RESERVOIR BECOMES EMPTY AFTER I PUT ONE OR MORE QUARTS IN THE RESERVOIR. ANYTIME I DRIVE AT HIGHWAY SPEEDS I SWAY BACK AND FORTH NO MATTER HOW MUCH CONTROL I HAVE OVER THE VEHICLE. MY STEERING GETS SO HARD TO THE POINT WHERE I ALMOST CRASH EVERY TIME I DRIVE MY CAR ANYWHERE BECAUSE I H…

Read full complaint

EVERY TIME I GO TO MY JOB MY POWER STEERING RESERVOIR BECOMES EMPTY AFTER I PUT ONE OR MORE QUARTS IN THE RESERVOIR. ANYTIME I DRIVE AT HIGHWAY SPEEDS I SWAY BACK AND FORTH NO MATTER HOW MUCH CONTROL I HAVE OVER THE VEHICLE. MY STEERING GETS SO HARD TO THE POINT WHERE I ALMOST CRASH EVERY TIME I DRIVE MY CAR ANYWHERE BECAUSE I HAVE NO POWER STEERING OR DON'T HAVE A LOT OF CONTROL OVER THE STEERING BECAUSE IT BECOMES SO TIGHT.

NHTSA ODI #11228454

135,000 miles · Feb 18, 2019
Vehicle Speed Control

WHILE DRIVING THE GAS PEDAL GETS STUCK AND ACCELERATES.

NHTSA ODI #11180951

185,000 miles · Sep 3, 2018
SteeringVehicle Speed Control

LOST PARTIAL CONTROL OF THE STEERING BECAUSE SHEER PEN RELEASED AND ERRATIC SPEEDOMETER-( INSTRUMENT CLUSTER FAILURE )

NHTSA ODI #11124077

Official recalls

1

04V300000 · Seat Belts:rear/other

Jun 23, 2004

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, 'SEAT BELT ASSEMBLY ANCHORAGES.' THE PASSENGER-SIDE REAR SAFETY BELT MAY HAVE BEEN INSTALLED WITH AN INCORRECT NUT AND BOLT.

Consequence & remedy

Consequence: IN A SEVERE CRASH, THE UPPER SEAT BELT ANCHORAGE MAY SEPARATE. THE EFFECTIVENESS OF THE SEAT BELT COULD THEN BE REDUCED AND THE OCCUPANT COULD RECEIVE GREATER INJURIES.

Remedy: DEALERS ARE TO INSPECT THE SAFETY BELT ANCHORAGE AND INSTALL A NEW NUT AND BOLT, IF NECESSARY. THE RECALL BEGAN ON AUGUST 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.