WHILE PULLING INTO GARAGE RIGHT FRONT WHEEL FELL OFF DUE TO BALL JOINT NUT FALLING OFF. THIS CAUSED FRONT WHEEL TO THEN FALL OFF .IT WAS A LUCKY THING THAT I WASNT GOING FAST . A 615.33 REPAIR BILL. NOW IM AFRAID IT WILL HAPPEN TO THE OTHER SIDE. I DON'T TRUST IT. CHEVROLET SAID NO RECALL FOR IT, AND WOULDN'T HELP. SO AT LE…
Read full complaint
WHILE PULLING INTO GARAGE RIGHT FRONT WHEEL FELL OFF DUE TO BALL JOINT NUT FALLING OFF. THIS CAUSED FRONT WHEEL TO THEN FALL OFF .IT WAS A LUCKY THING THAT I WASNT GOING FAST . A 615.33 REPAIR BILL. NOW IM AFRAID IT WILL HAPPEN TO THE OTHER SIDE. I DON'T TRUST IT. CHEVROLET SAID NO RECALL FOR IT, AND WOULDN'T HELP. SO AT LEAST I CAN COMPLAIN TO YOU TO LET YOU KNOW HOW UNSAFE THIS VEHICLE IS. THANK YOU. *AK
THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.
Consequence & remedy
Consequence: THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.
DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.
Consequence & remedy
Consequence: IF THE LOWER CONTROL ARM BALL JOINT LOOSENS, FATIGUES AND SEPARATES FROM THE FRONT SUSPENSION KNUCKLE, IT COULD CAUSE LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED FROM THE KNUCKLE, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.
THESE VEHICLES FAIL TO CONFORM TO FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS." AT LOW TEMPERATURES, EXCESSIVE FRICTION CAN OCCUR IN THE ACCELERATOR PEDAL ASSEMBLY.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A FAILURE OF THE TROTTLE RETURN SPRING, IF THERE IS EXCESSIVE FRICTION IN THE PEDAL ASSEMBLY, THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY.
THE FUEL TANK ATTACHMENT STRAP FASTENERS WERE NOT PROPERLY TIGHTENED. THE FASTENERS CAN COMPLETELY DETACH, EVENTUALLY ALLOWING THE FUEL TANK TO SAG AND THE BOTTOM OF THE TANK TO STRIKE THE ROADWAY.
Consequence & remedy
Consequence: THIS CAN RESULT IN A FUEL TANK LEAK AND FIRE IF THE LEAKING FUEL IS EXPOSED TO A SOURCE OF IGNITION.
Remedy: DEALERS WILL RETIGHTEN THE FUEL TANK STRAP FASTENERS.
PAINT ON THE WHEEL MOUNTING SURFACES CAN ACT AS A SHIM BETWEEN THE WHEEL AND THE ROTOR/DRUM. AS THE VEHICLE IS DRIVEN, THE WHEEL IMBEDS INTO THE PAINT, LOOSENING THE LUG NUT AND CAUSING A LOSS OF CLAMP LOAD.
Consequence & remedy
Consequence: ONCE CLAMP LOAD IS LOST, ALL TIRE LOADS ARE TAKEN BY THE WHEEL STUDS RESULTING IN A FRACTURE OF THE WHEEL STUDS. THIS COULD CAUSE THE WHEEL TO SEPARATE FROM THE VEHICLE AND COULD RESULT IN A VEHICLES CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL CLEAN THE WHEEL MOUNTING SURFACES FOR ALL FOUR WHEELS. ALSO, THE WHEEL STUDS WILL BE INSPECTED FOR DAMAGE AND WILL BE REPLACED AS NECESSARY.
THE ENGINE OIL COOLER INLET HOSE MAY HAVE BEEN INSTALLED TOO CLOSE TO THE STEERING GEAR CAUSING CHAFING. THE CHAFING CAN EVENTUALLY WEAR THROUGH THE HOSE'S PROTECTIVE SLEEVE RESULTING IN ENGINE OIL LEAKING ONTO THE ENGINE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE OIL LEAK ONTO THE ENGINE CAN RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: Not supplied
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA99003 · Coolant Fires
Opened Jan 13, 1999 · Closed Aug 17, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98049 · Coolant Fires
Opened Sep 4, 1998 · Closed Jan 13, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
EA96022 · Steering Wheel Breakage
Opened Sep 24, 1996 · Closed Apr 4, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE96037 · Sterring Wheel Breakage
Opened May 16, 1996 · Closed Sep 24, 1996
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1994 Chevrolet Caprice Problems, Complaints & Recalls | Skip That Year
Illustration