IllustrationThe vats system is the problem on my 96 Impala it just shut my car off for the past 3 mos
1996 Chevrolet Caprice
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caprice years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 65 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
What owners actually said
65 reportsSAFETY EMISSIONS. *KB
TL* THE CONTACT OWNS A 1996 CHEVROLET CAPRICE. THE CONTACT WAS DRIVING 45 MPH WHEN HE HEARD A DRAGGING NOISE COMING FROM UNDER THE VEHICLE. THE VEHICLE WAS MANEUVERED TO THE SHOULDER AND THE CONTACT NOTICED THAT THE STRAPS WHICH HELD THE FUEL TANK IN PLACE WERE FRACTURED DUE TO CORROSION. THE VEHICLE WAS SAFELY DRIVEN HOME AND P…
Read full complaint
TL* THE CONTACT OWNS A 1996 CHEVROLET CAPRICE. THE CONTACT WAS DRIVING 45 MPH WHEN HE HEARD A DRAGGING NOISE COMING FROM UNDER THE VEHICLE. THE VEHICLE WAS MANEUVERED TO THE SHOULDER AND THE CONTACT NOTICED THAT THE STRAPS WHICH HELD THE FUEL TANK IN PLACE WERE FRACTURED DUE TO CORROSION. THE VEHICLE WAS SAFELY DRIVEN HOME AND PARKED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 145,000.
TL*THE CONTACT OWNS A 1996 CHEVROLET CAPRICE. WHILE DRIVING 45 MPH, THE INSTRUMENT PANEL CLUSTER LIGHTS BEGAN BLINKING ON AND OFF. THE FAILURE CONTINUED FOR APPROXIMATELY SIX MONTHS UNTIL IT COMPLETELY SHUT OFF. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE PANEL CLUSTER WAS A RECURRING FAILURE WITH THA…
Read full complaint
TL*THE CONTACT OWNS A 1996 CHEVROLET CAPRICE. WHILE DRIVING 45 MPH, THE INSTRUMENT PANEL CLUSTER LIGHTS BEGAN BLINKING ON AND OFF. THE FAILURE CONTINUED FOR APPROXIMATELY SIX MONTHS UNTIL IT COMPLETELY SHUT OFF. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE PANEL CLUSTER WAS A RECURRING FAILURE WITH THAT MAKE AND MODEL VEHICLE. SHE HAD TO REPLACE THE ENTIRE PANEL CLUSTER WITH THE SPEEDOMETER AND ODOMETER, WHICH CORRECTED THE FAILURE FOR TWO YEARS. RECENTLY, WHILE DRIVING 5 MPH, THE INSTRUMENT PANEL BEGAN TO FLICKER ON AND OFF AGAIN. WITHIN THE LAST TWO WEEKS, THE INSTRUMENT PANEL SUDDENLY SHUT OFF AND WOULD OCCASIONALLY TURN BACK ON. THE FAILURE CAUSES THE CONTACT TO BE UNSURE OF THE SPEED THAT SHE IS TRAVELING OR HOW MANY MILES ARE ON HER VEHICLE. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 59,000.
DURING MAINTENANCE OF MY VEHICLE IT WAS FOUND TO BE MISSING THE BOLTS, GUIDES, WASHERS, BUSHINGS AND NUTS THAT CONNECT THE RADIATOR SUPPORT TO THE FRAME. THIS 1996 CHEVROLET CAPRICE CLASSIC MAY BE ONLY ONE OF MANY WHEREIN THESE CRITICAL BOLTS AND ASSEMBLIES WERE NEVER INSTALLED AT THE FACTORY. *JB
THE TIRE ON THE CONSUMER'S 1996 CHEVROLET CAPRICE BLEWOUT WHILE PARKED DAMAGING THE ENTIRE FRONT END (COOPER CORNELL TIRE).*MR *NM
DEFECTIVE TIRES, RESULTING IN TIRES EXPLODING WHILE CAR WAS PARKED, DAMAGING ENTIRE FRONT END OF VEHICLE. *BF THE TIRE STATED THEY SOLD THE CONSUMER THE WRONG TIRES FOR THE WEIGHT OF THE VEHICLE AND EVEN THOUGH IT WAS THE TIRES STORE'S FAULT, THE CONSUMER STILL HAD TO PAY FOR THE UPGRADE. *JB
WHILE DRIVING AT ANY SPEED CONSUMER HEARD A LOUD KNOCKING NOISE AND THE VEHICLE STARTED TO JERK. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC DETERMINED THAT THE UPPER AND LOWER BALL JOINTS NEEDED TO BE REPLACED. *AK
WHEN DRIVING BELOW 20 MPH VEHICLE WOULD STALL. THE VEHICLE WAS TAKEN TO THE DEALER ON THREE SEPARATE OCCASIONS AND THE DEALER REPLACED THE DISTRIBUTOR/SPARK PLUGS AND SOMETHING ON THE DRIVESHAFT. HOWEVER, THE PROBLEM RECURRED. *AK THE DISTRIBUTOR CAP WAS REPLACED DUE TO A BROKEN SCREW ON THE CAP AND ROTOR. *SCC *JB
VEHICLE EXPERIENCED THE SAME DEFECT WITH ITS LOWER CONTROL ARM AS STATED IN RECALL 96 V 018 001; BUT THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK
Official recalls
496V245000 · Wheels:lugs/nuts/bolts/studs
Dec 10, 1996
THE WHEEL LUG NUTS WERE NOT TIGHTENED TO THE PROPER SPECIFICATION DURING ASSEMBLY.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN A FRACTURE OF THE WHEEL STUDS CAUSING THE WHEEL TO SEPARATE FROM THE VEHICLE.
Remedy: DEALERS WILL TIGHTEN THE VEHICLE'S WHEEL LUG NUTS TO THE PROPER SPECIFICATION.
96V020000 · Suspension:rear
Jan 31, 1996
THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.
Consequence & remedy
Consequence: THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.
96V018000 · Suspension:front:control Arm:lower Ball Joint
Jan 30, 1996
DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.
Consequence & remedy
Consequence: THE LOWER CONTROL ARM BALL JOINT CAN LOOSEN, FATIGUE, AND SEPARATE FROM THE FRONT SUSPENSION KNUCKLE RESULTING IN A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.
95V215000 · Air Bags
Nov 3, 1995
THESE VEHICLES WERE SHIPPED WITH BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT CAUTION LABEL AND A ROOF RACK CAUTION LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO.208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABELS.
Remedy: A NEW ROOF RACK CAUTION LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS WILL INSTALL THE LABEL OR HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA99003 · Coolant Fires
Opened Jan 13, 1999 · Closed Aug 17, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
EA96007 · Rear Wheel Separation
Opened May 31, 1996 · Closed Dec 24, 1996
Status: closed (inferred from source dates) · Suspension
GM NOTIFIED ODI THAT THEY ARE CONDUCTING A RECALL TO RETORQUE THE WHEEL LUG NUTS ON VEHICLES BUILT BETWEEN AUGUST AND SEPTEMBER OF 1995.IT IS ANTICIPATED THAT MOST VEHICLES WILL REQUIRE THE WHEEL LUG NUTS TO BE RETORQUED TO 135 N.M(100 LB. FT.).CUSTOMERS WHO HAVE HAD ALL FOUR OF THEIR TIRES AND WHEELS ROTATED SHOULD HAVE PROPERLY TORQUED LUG NUTS.HOWEVER, GM IS OFFERING CUSTOMERS WHO HAVE HAD THEIR TIRES AND WHEELS ROTATED THE OPTION OF RETURNING TO THEIR DEALER FOR THIS REPAIR OR COMPLETING AND RETURNING AN OWNER REPLY CARD INCLUDED WITH THEIR RECALL NOTICE.THIS ENGINEERING ANALYSIS IS CLOSED.
PE96001 · Rear Wheel Separation
Opened Jan 4, 1996 · Closed May 31, 1996
Status: closed (inferred from source dates) · Suspension
INFORMATION OBTAINED FROM GM INDICATES THAT FURTHER INVESTIGATION TO DETERMINE THE CAUSE OF WHEEL SEPARATIONS IS WARRANTED.IN GM'S RESPONSE DATED APRIL 26, 1996, GM STATED THAT:GM HAS NOT IDENTIFIED ANY DEFECT IN THE MANUFACTURE OF THE SUBJECT VEHICLES WHIH MAY CONTRIBUTE TO WHEEL SEPARATION.INVESTIGATION AS TO THE ROOT CAUSE OF WHEEL SEPARATIONS IS CONTINUING.THE RESULTS OF THESE FURTHER INVESTIGATIONS ARE REQUIRED TO ASSESS THE PROBABILITY OF ANY FUTURE INCIDENTS . . .