IllustrationRIGHT FRONT BALL JOINTS BROKE. *JB
1996 Chevrolet Caprice
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caprice years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 65 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
What owners actually said
65 reportsTHE CONSUMER MUST APPLY EXCESSIVE FORCE TO THE ACCELERATOR PEDAL TO GAIN SPEED. *JB
THE ACCELERATOR IDLED WHILE DRIVING. *JB
THE ACCELERATOR IDLED WHILE DRIVING. *JB
I HAVE A 1996 CHEVROLET CAPRICE WITH ONLY 28, 000 MILES ON IT. SEVERAL OCCURANCES OF STEERING LOOCKUP WHEN GOING AT VERY SLOW SPEEDS AND TURNING EITHER LET OR RIGHT. RACING THE ENGINE SEEMS TO CLEAR THE PROBLEM SOMETIMES. THE STEERING PUMP WAS REPLACED BUT THE PROBLEM CONTINES TO OCCUR OCCASIONALLY.
CONSUMER STATED THAT WHILE DRIVING AT 15MPH ON FLAT SURFACE AND WITHOUT WARNING THE STEERING WHEEL LOCKED UP. DEALER NOTIFIED. TS
CONSUMER COMPLAINED ABOUT FUEL PUMP PROBLEMS. ALSO, WHILE DRIVING FUEL PUMP BURNED OUT, AND LUCKILY IT DID NOT EXPLODE. FUEL PUMP AND FUEL SENDING MODULE WERE REPLACED. *TS *TT *NLM.*AK
CONSUMER STATES THE FUEL PUMP ON THE VEHICLE WENT OUT WHILE THE CONSUMER WAS DRIVING, CAUSING THE VEHICLE TO SHUT OFF AND NOT MOVE ANY WHERE. ALSO THE CONSUMER DOES NOT THINK THAT THE FUEL PUMP IS IN A PROPER PLACE, BECAUSE IF THERE WAS A SPARK THE VEHICLE COULD HAVE CAUGHT ON FIRE. CONTACTED DEALER.*JB
WHILE DRIVING, BRAKE HOSE RUBS ITS MOUNTING BOLT. IT WAS INSTALLED WITH A LOOP IN THE HOSE. REPAIR HAS BEEN MADE ON VEHICLE.*AK CONSUMER STATED THE HOSE WAS WORN IN THE REENFORCING LAYER OF THE HOSE, CONSUMER NOTICED THIS WHEN THE WHEEL WAS OFF.*JB
HEATER IS NOT WORKING ALTHOUGH THE SYSTEM HAS BEEN FLUSHED THREE TIMES. DEALER HAS BEEN CONTATCED. PLEASE PROVIDE FURTHER DETAILS.*AK
Official recalls
496V245000 · Wheels:lugs/nuts/bolts/studs
Dec 10, 1996
THE WHEEL LUG NUTS WERE NOT TIGHTENED TO THE PROPER SPECIFICATION DURING ASSEMBLY.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN A FRACTURE OF THE WHEEL STUDS CAUSING THE WHEEL TO SEPARATE FROM THE VEHICLE.
Remedy: DEALERS WILL TIGHTEN THE VEHICLE'S WHEEL LUG NUTS TO THE PROPER SPECIFICATION.
96V020000 · Suspension:rear
Jan 31, 1996
THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.
Consequence & remedy
Consequence: THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.
96V018000 · Suspension:front:control Arm:lower Ball Joint
Jan 30, 1996
DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.
Consequence & remedy
Consequence: THE LOWER CONTROL ARM BALL JOINT CAN LOOSEN, FATIGUE, AND SEPARATE FROM THE FRONT SUSPENSION KNUCKLE RESULTING IN A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.
95V215000 · Air Bags
Nov 3, 1995
THESE VEHICLES WERE SHIPPED WITH BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT CAUTION LABEL AND A ROOF RACK CAUTION LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO.208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABELS.
Remedy: A NEW ROOF RACK CAUTION LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS WILL INSTALL THE LABEL OR HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA99003 · Coolant Fires
Opened Jan 13, 1999 · Closed Aug 17, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
EA96007 · Rear Wheel Separation
Opened May 31, 1996 · Closed Dec 24, 1996
Status: closed (inferred from source dates) · Suspension
GM NOTIFIED ODI THAT THEY ARE CONDUCTING A RECALL TO RETORQUE THE WHEEL LUG NUTS ON VEHICLES BUILT BETWEEN AUGUST AND SEPTEMBER OF 1995.IT IS ANTICIPATED THAT MOST VEHICLES WILL REQUIRE THE WHEEL LUG NUTS TO BE RETORQUED TO 135 N.M(100 LB. FT.).CUSTOMERS WHO HAVE HAD ALL FOUR OF THEIR TIRES AND WHEELS ROTATED SHOULD HAVE PROPERLY TORQUED LUG NUTS.HOWEVER, GM IS OFFERING CUSTOMERS WHO HAVE HAD THEIR TIRES AND WHEELS ROTATED THE OPTION OF RETURNING TO THEIR DEALER FOR THIS REPAIR OR COMPLETING AND RETURNING AN OWNER REPLY CARD INCLUDED WITH THEIR RECALL NOTICE.THIS ENGINEERING ANALYSIS IS CLOSED.
PE96001 · Rear Wheel Separation
Opened Jan 4, 1996 · Closed May 31, 1996
Status: closed (inferred from source dates) · Suspension
INFORMATION OBTAINED FROM GM INDICATES THAT FURTHER INVESTIGATION TO DETERMINE THE CAUSE OF WHEEL SEPARATIONS IS WARRANTED.IN GM'S RESPONSE DATED APRIL 26, 1996, GM STATED THAT:GM HAS NOT IDENTIFIED ANY DEFECT IN THE MANUFACTURE OF THE SUBJECT VEHICLES WHIH MAY CONTRIBUTE TO WHEEL SEPARATION.INVESTIGATION AS TO THE ROOT CAUSE OF WHEEL SEPARATIONS IS CONTINUING.THE RESULTS OF THESE FURTHER INVESTIGATIONS ARE REQUIRED TO ASSESS THE PROBABILITY OF ANY FUTURE INCIDENTS . . .